Professional Documents
Culture Documents
Materials
The materials that the researchers used were 20W solar panel board, 7AH battery, 30AH
controller, 1000W inverter, 1m wire, mec4 connector, universal outlet, , air conditioner electrical
Methods
All the materials were prepared for making the product. First, the plywood was cut into
the dimension of 5 by 11 inches, 4 by 11 inches, and 4 by 8.5 inches. Those dimensions were
provided two pieces each to make a rectangular prism as the housing of the improvised solar-
powered extension wire board. Lineman's plier was used to splice or cut electrical wires into 3-5
inches long. Next, one of the bases of the housing was drilled enough to accommodate the plug
points. Wires were then connected to the plug points in a parallel circuit. After that, the solar
panel was mounted and was attached to the other side of the base by screwing it onto the
plywood. The 7AH battery cable was connected to the charge controller. Next, the charge
controller was evaluated by the researchers. Then, controllers were wired to the panel by the
mec4 connector. The inverter was connected to the solar panel to run or charge a device in AC