Professional Documents
Culture Documents
CIRCUIT:
1.
PROCEDURE:
1) Open OrCAD software, create a new blank project.
2) Pick up all the requirements for circuit 1 from the place section, Pspice
components and place them on project page.
3) Next connect them with the wire tool to complete circuit 1.
4) Then create the simulation for circuit1(Inverting Amplifier) and add the voltage
pointers at the input and ouput nodes. Then in simulation settings add Run to
Time as 5ms and Start saving Data after 0, in Time Domain Analysis Type; then
after simulating this respective circuit with these settings.
5) Then connect the components with wires to form Circuit2(Non-inverting
Amplifier),
6) With same simulation setting, run the simulation.
7) Analysis both the graphs.
SIMULATION RESULT:
1. Inverting Amplifier:
2. Non-Inverting Amplifier:
INFERENCE/RESULT:
➔ Therefore, we verified the characteristics of Inverting and Non-Inverting
Amplifiers.