SSA
Oe ect
Oeste isc ucas
peace
P= ounce Venieneroscrent
Sysco
BATS AM
THERMOLYSIS WATER-COOLED CHILLER
USER MANUALINTRODUCTION
CW-3000 Series is professional cooling machine referring to international
advanced thermolysis cooling system design, suitable for small water-cooled
cooling devices requested machinery.
~]
>]
°
°
°
°
i]
Specific disconnection alarm security protection.
Hermetic type water tank, water is available for a long time used.
Real-time temperature monitoring, accurate knowledge of heating devices
working condition.
Professional air-cooled forced radiator with strong heat dissipating capacity
and difficult to be blocked up.
Equipped with alarm output port to protect sensitive components quickly.
High cost performance, low failure rate.
There are several options of power supply, complete in specifications.
CAUTION
It is strictly forbidden to plug and run the cooler without feeding water.
Cooler should be placed in a well-ventilated, dry environment place and
away from heat sources.
Please keep at least 30cm from obstructions to the air outlet which is in the
back of the cooler, and should leave at least 10cm between obstructions
and air inlets of two sides.
The cooling water must be drained if the cooler is out of use for long time
Or before being transported.
To protect laser heating devices, the radiator fan of cooler will suspend to
work when water temperature is lower (about 10 °C), and it will restart to
run when water temperature rises to higher(about 20 °C).SHAPE AND PARTS NAME
FRONT
TEMPERATURE DISPLAY
SYSTEM ALARM INDICATOR
RUNNING INDICATOR
POWERSW — |
BACK
— INJECTION PORT
ALARM SIGNAL OUTPUTTERMINAL
POWER SOCKET (WITH FUSE)
utter
INLET
RADIATOR FAN
MACHINE PARAMETERS
SERIALNo,
OUTFALLTHE FIRST INSTALLATION
very simple to install this industrial cooling machine. The first time installation of the
new machine can be carried out by following steps.
“, a) 8 (@ CI
| B —
a @
‘Open the package to check Open the injection port, According to system conditions,
the machine is intact and then add cooling water, connect the water inlet
ailthenecessary and outlet pipe well.
-acceszories are completed
V7 ;
Plugin power, turn on the Check the water level of the
ewer switch. (Do not allow water tank again. (It should
‘the water overflow} be 80-150mm from the surface
of water to the injection port)
ALARM DESCRIPTION
Geuses of the cooling water circulation loop alarm and the working condition table
DISPLAY GREEN LIGHT] RED LIGHT BUZZER nose pou
CONDITION
Normal @ on @ off | @ Novoice off DB on
Water stops up ® of @ on @) Voice @ on off
‘Surpasses 60°C ®@ of @ on (@) Voice Bo off
Pump breakdown @ or @ on | @) voice | DB on off
Alarm of watershortage | ® Off @ On @) Voice Bo off
Faulted circuit I Bee | on off
Power outage ey See Bo off
‘New the flow alarm port is connected to the normally open relay and normally closed relay contacts, requiring operating
ceventto be less than 54, working voltage less than 300V.ALARM CIRCUIT
Se |
? Fiowsn
|
j
Zone Tu
{
Output part diagram
We Hs Ht
Alarm output
MAINTENANCE
1.To ensure good heat dissipating, please open the lid to clean the dirt after the cooler
used in long-term.
2.Working in cold north area, itis better to use noncorrosive antifreeze fluid.
SPECIFICATIONS
MODEL cw-3000nc | cw-s000D6 | cw-so00aF | cw-s0000F | cw-s000aK | cw-3000DK
Voltages acz20-240v | Aci00~120v | aczz0-240v | acioo-rz0v | acz20~24ov | AC100~120¥
Frequency __ So/60Hz
Current 0.458 O.9A 0.458 ood | 04a 08a,
Cooling sowie sowie
aaa at
Inlet and Ours mensions Insige dimensions Inside inensions
outlet hola vom rassconnector anrmspecdyconector Ces
Max pumping lift oN! 00m
NW 95K9 12Ko
ew a 5K
Dimensions AP 27 37cm
| Packing dimensions 59*28°¢7em(LW'H)SIMPIE TROUBLESHOOTING
FAILURE FAULT CAUSE APPROACH
Powercordis not plugcedin place | Plug the power cord in place
Machine turned on bul uneleotriffed
Replace the fuse inside the power iniorface |
Buse bumntout tthichis inthe back of machine
Flow alarm (pznel ed light) with water
pivedirectly connect ta the outlet, inet, Water levelin water tank is too low | Feed water and check the pipe leakage
there is no water flow
Waterlovel in watertankistoalow | Feed water and check the pipe leakage
Chiller of poor ventitation To improve the ventilation
Ultra-high temperature
Excessive heat load Reduce the heal lazé or louse ether mod's
Anormal boot, buttha fan does natwork | Thewaiertemperaiure below 20% | Anormal phenomenon,no processing
Water drop in electae circuit Natural drying or drying off cap
‘Switch on with alarming after adding
water or changing water
To replace or repair water pumps,
Damaged pumps dry transfer Ho eee of eee Wala
Siow outfall drainage ‘The injection ports not open Open the injection port
PACKING LIST
1. Machine pe ls
2. User manual Ipc. lliny
3. Power cord 1pc.
4. Connection hose Ipc.
5.Sealed hoop 2pes.
6.An alarm signal output plug.
7. Spare fuse for 250V/2A Ipc.
(Held in the spare fuseholder of power socket)
sensory or metal capabilities, or lack of experience and knowledge, unless they have been
given supervision or instruction, children being supervised not to play with the appliance.
4 CAUTION: the appliance is not to be used by children or persons with reduced physicalSGA CAeseaRed
GUANGZHOU TEYU ELECTROMECHANICAL CO., LTD
SOUL: OM Th BSR Te AA FSS ES HT OS OE
‘Add: Fifth Floor, No.3 Nanhuaxi Industrial Estate, Daganwei Street, GongyeRoad, Haizhu District, Guangzhou, China
Tel: +86-20-89301885 89301886 Fax; +86-20-84309967 NRA: 400-600-2093
Email: winsontamg@teyu.com.cn http://www.teyu.com.cn