Toyota Corolla Repair Manual: Diagnostic trouble code chart
Toyota Corolla Repair Manual / Diagnostics / Sfi system / Diagnostic trouble code chart
Hint : as for the vehicle for mexico, refer to repair manual 2003 corolla (pub. No. Rm938u). Parameters listed in the chart may not be exactly the same as your readings due to the type of instrument or other factors. If a malfunction code is displayed during the dtc check in the check mode, check the circuit for the codes listed in the table below. For details of each code, refer to the ’’’’ under the respective ’’dtc no.’’ In the dtc chart. *1: ” ○” ... Mil is illuminated, ”—” ... Mil is not illuminated. *2: Mil is illuminated or blinks *3: this dtc is indicate a malfunction related to primary circuit.
Oxygen / af sensor heater monitor
Preconditions The monitor will not run unless: mil is off drive pattern connect the obd ii scan tool to the dlc3 to check monitor status and preconditions. & ... Fail–safe chart If any of the following codes is recorded, the ecm enters the fail–safe mode. Check for intermittent problems Hand–held tester only: by putting the vehicle’s ecm in the check mode, the 1 trip d ...