Professional Documents
Culture Documents
9-10,
Semarang 50185, Jawa Tengah – Indonesia
Tel. 62-24-7626833, Fax. 62-24-7617203
E-mail Address : marketing.srg@indociptawisesa.com
The information on the Chemical Safety Data Sheet is given to the best of our ability based on the present state of our knowledge on
hazards, properties and handling of this product under the recommended conditions of use. We recommend the user to test the product for
the purpose required. Any use of this product or method of application which is not described in the Technical Data Sheet is the
responsibility of the user. The information contained herein is subject to change without further notice.
1
Kawasan Industri Candi, Jl. Gatot Subroto Blok 19 Kav.9-10,
Semarang 50185, Jawa Tengah – Indonesia
Tel. 62-24-7626833, Fax. 62-24-7617203
E-mail Address : marketing.srg@indociptawisesa.com
4. HAZARDS IDENTIFICATION
Flammable
Harmful is inhaled.
May cause allergic respiratory reaction.
May cause lung damage.
General Information :
In all cases of doubt or when symptoms persist, seek medical advice. In case of unconsciousness
give nothing by mouth, place in unconscious position and seek medical advice.
Following Inhalation :
Move victim to fresh air. Put victim at rest and keep warm. In case of irregular breathing or
respiratory arrest provide artificial respiration.
After Ingestion :
If swallowed, rinse mouth with water (only the person is conscious). Consult physician immediately.
Keep victim calm. Do not induce vomiting.
The information on the Chemical Safety Data Sheet is given to the best of our ability based on the present state of our knowledge on
hazards, properties and handling of this product under the recommended conditions of use. We recommend the user to test the product for
the purpose required. Any use of this product or method of application which is not described in the Technical Data Sheet is the
responsibility of the user. The information contained herein is subject to change without further notice.
2
Kawasan Industri Candi, Jl. Gatot Subroto Blok 19 Kav.9-10,
Semarang 50185, Jawa Tengah – Indonesia
Tel. 62-24-7626833, Fax. 62-24-7617203
E-mail Address : marketing.srg@indociptawisesa.com
Additional Information :
Cool closed containers that are near the source of the fire. Do not allow water used to extinguish
fire to enter drains, ground or waterways. Treat run off as hazardous.
Handling :
Only use in a well exhausted spray booth and avoid inhalation of vapour by maintaining adequate
ventilation. Avoid contact with skin and eye.
Special Hazards :
Avoid heat, flame, sparks and contact with oxidizing agent. Equipment should be earthed. Spray
booths should be kept clean. Used rags mag spontaneously combust if not stored in water.
Provide good ventilation. This can be achieved with local or room suction. If this should not be
sufficient to keep aerosol and solvent vapour concentration below the exposure limit values, a
suitable respiratory protection must be used.
The information on the Chemical Safety Data Sheet is given to the best of our ability based on the present state of our knowledge on
hazards, properties and handling of this product under the recommended conditions of use. We recommend the user to test the product for
the purpose required. Any use of this product or method of application which is not described in the Technical Data Sheet is the
responsibility of the user. The information contained herein is subject to change without further notice.
3
Kawasan Industri Candi, Jl. Gatot Subroto Blok 19 Kav.9-10,
Semarang 50185, Jawa Tengah – Indonesia
Tel. 62-24-7626833, Fax. 62-24-7617203
E-mail Address : marketing.srg@indociptawisesa.com
Eye Protection :
Wear closely fitting protective glasses in case of splashes.
Skin Protection :
Wear antistatic clothing of natural fibers (.le. cotton) or heat resistant synthetic fibers.
Preventive Measures :
After contact clean skin thoroughly with water and soap oder use appropriate cleanser.
Acute Oral Toxicity : LD50 : 4.130 – 5.110 mg/kg ( Rat, Male / Female ).
Acute Inhalation Toxicity : LC50 : 60 ppm ( 480 mg/m3 ).
RD50 : 2.12 ppm, vapor, 3h ( Rat, male ).
Acute Dermal Toxicity : LD50 : > 9.400 mg/kg ( Rabbit, male / Female ).
The information on the Chemical Safety Data Sheet is given to the best of our ability based on the present state of our knowledge on
hazards, properties and handling of this product under the recommended conditions of use. We recommend the user to test the product for
the purpose required. Any use of this product or method of application which is not described in the Technical Data Sheet is the
responsibility of the user. The information contained herein is subject to change without further notice.
4
Kawasan Industri Candi, Jl. Gatot Subroto Blok 19 Kav.9-10,
Semarang 50185, Jawa Tengah – Indonesia
Tel. 62-24-7626833, Fax. 62-24-7617203
E-mail Address : marketing.srg@indociptawisesa.com
Product can be stored in steel drums / pails and transported by land and other forms of
transportation.
Risk Phrases :
R 10 Flammable
R 20/21/22 Harmful by inhalation, in contact with skin and if
swallowed.
R 36/38 Irritating to eye and skin.
Safety Phrases :
S 24/25 Avoid contact with skin and eyes.
S 26 In case of contact with eyes, rinse immediately with
plenty of water and seek medical advice.
S 36/37 Wear suitable protective clothing and gloves.
S 51 Use only in well ventilated areas.
S 62 If swallowed do not induce voviting : seek medical
advice immediately.
The information on the Chemical Safety Data Sheet is given to the best of our ability based on the present state of our knowledge on
hazards, properties and handling of this product under the recommended conditions of use. We recommend the user to test the product for
the purpose required. Any use of this product or method of application which is not described in the Technical Data Sheet is the
responsibility of the user. The information contained herein is subject to change without further notice.
5
Kawasan Industri Candi, Jl. Gatot Subroto Blok 19 Kav.9-10,
Semarang 50185, Jawa Tengah – Indonesia
Tel. 62-24-7626833, Fax. 62-24-7617203
E-mail Address : marketing.srg@indociptawisesa.com
Further remarks :
The information supplied on this safety data sheet complies with our current level of knowledge as
well as with national and EU regulations. Without written approval, the product must not be used for
purposes different from those mentioned in chapter 1. It is always the user’s duty to take any
necessary measures for meeting the requirements laid down by local rules and regulations. The
details in this safety data sheet describe the safety requirements of our product and are not to be
regarded as guaranteed attributes of the product.
The information on the Chemical Safety Data Sheet is given to the best of our ability based on the present state of our knowledge on
hazards, properties and handling of this product under the recommended conditions of use. We recommend the user to test the product for
the purpose required. Any use of this product or method of application which is not described in the Technical Data Sheet is the
responsibility of the user. The information contained herein is subject to change without further notice.
6