Ce ty
Cy
Cee ee
Coe
ee ced
Bey
Ce eid
See
Cee om
proofing
PENETRON
|
www.penetron.com
Penetron’s waterproofing effect Is
achioved by the reaction ofthe various
chemical components contained in the
salut when combined within the
concrete mattis. The compound
penetrates deep into the capillary
tracts af the concrete by pressure of
osmosis and forms crjstas. that
completely seal the capilares and
shrinkage cracks to deve out moisture
The process works with or against the
pressure of wate. In the absence of
moisture, Peneton components ie
dormant. Should moisture racur at any
time, the chemical action anc sealing
B process repeats itself automatically
and advances even more deeply into
the concreta.Panetron chemicals will
continuously seal and reseal due to
thelr chemical nature. Crystalline
‘rowth from capillary waterproofing
has been measur as deep as nearly
11 meter fram the point of application
Penetron® is 100% compatible with
cconarete, brick, mortar, and stone
Penetron is recommended for use
in any concrete or block structure
where it is required to keap watar
in or out, Penetron should also be
applied to concrete or block
structures exposed to potential
watar or chemical attack and thus
requiring permanant waterproofing
and protection. Its applicability to
either the positive side (side
exposed to water) or the negative
side (side opposite the water)
meets all waterproofing
requirements.
Sholf life Is 12. months when
stored ina dry place, unopened
undamaged, and in original
packaging
PENETRON
* Booomes an integral prt ofthe concrete, farming a complete body
of strength and durabilty. Penetran shoud not be contused with
‘coating or membrane
* Penetates deeply and seals concrete's capilary tracts and
shvinkage cracks,
+ Can be applied fom either the postive or negative side
1 Weteproning and cherical-resistance properties remain intact
avn ifthe surface is damaged
* Completely effctve against high hydrostatic head prassure
* More effective overall and less costy than hydrolthic membrane or
clay panel ystems
+ Ease of application, labor-cost effective
* Increases concrte's compressive strength
+ Cannot come apart atthe seams, tear or puncture
* Does not require protection during backing, placement of steel or
wire mesh, and other common procedures
4 Seals cracks of up to O4mm, Does nat merely mask or bridge
hailne and shrinkage oracks
* Permits concrete to breathe, eliminating water vapor buldup and
leaving the concrete completly dry
4 Resists chemical attack (gH 3-11 constant contact; pH 2-12
periodic contact) and provides a wide range of protection from
freeze/thaw cycles, aggressive subsal waters, sea wate,
carbonates, chlorides, sufates and nitrates
Can be applied to moist or green concrete
Protects reinforcing stel
Nontoxio
Approved for potable water use
No extensive curing times (except in very hat or low-humidity
conditions)
PACKAGING:Dee
ec og
PENETRON
www.penetron.com
DIRECTIONS FOR USE:
Consumption:
Water retaining structures,
‘internal concrete wall surfaces:
‘Two coats of Penetron at 1.25 - 1.5 ib/y!
}80 ko/m?) or one coat at 2.5 ~
3 1.6 kg/m) applied with
brush or sry.
Construction slabs: Peretion at 2
Ib/y? (1.00 kg/m?) applied in one sury
oat to hardened concrete or dry
sptnked and trowel applied to fresh
coneete when this has reached inital set.
Construction joints: Penetron at 3
Indy? (1.5 kg/m?) applied in sur or dy
powder consistency imeditly prior to
Placing the next itVbay of conereta
Blinding concrete: Pension at 25
[bly (1.2 ka/m®) apo in srry or dry
powder conssteny immediatly prior to
Hlacing the overing conerete sa.
SURFACE PREPARATION:
All conerete to be veated with Peneton
integral crystalline waterproofing must be
clean and have an “open” capilery
system. Remove laitance, dit grease,
atc, by means of high pressure water
{atng, wet sandblasting or wie brushing,
Faulty conorete in the form of craks.
honeyeaihng, et, must be chased aut
treated with Petron and fled ush with
Penecrete Marta”, Sufaces must be
caretly pre-wateed ror to the
Penetron application. The conrete
surface must be damp but not wet
MIXING:
Penetron is mechanically mixed with
clean water to @ creamy consistency or
that resembling thick oll, Appraximate
mixing ratio is 2 parts water to 6 parts
Penetron powder (oy vlumie). Mix only
as much material as can be used within
20 minutes and tr mixture frequent. If
the mixture stats to set do net add more
water, simply re-stir to restore workabilty,
PENETRON
Slurry consistency: Apply Penetron in one or two coats
avcording to specification by masonry brush or appropriate power
soray equipment. When two cuats are speoied apply the second
cat while the fist ooat is stl “green”
Dry powder consistency: (far novzontal sutace ony). The
spectied eraunt of Peneton is distributed in pow frm thraugh a
sieve and trowel into the feshly placed concrete once this has
reached initial set,
Post treatment: The treated areas should be kept damp for 2
period of fve days and must be protected against direct sun, wind
and fost, by covering with poeththene sheeting dam burp or smi
Note: Do not apply Penetron at temperatures ator blow freezing
Penetron cannot be used as an additive 10 concree or plasters.
(Penetton Admix should be considered for these applications).
APPLICATION:
TECHNICAL DATA":
Aggregate state: ponder
Color: cement grey
Bulk density: approx. 65 h/y8 (838 kg/m)
“All data are averages of several tests under laboratory conditions.
In practice, climatic variations such as temperature, humidity, and
porosity of substrate may affect these values
HEALTH AND SAFETY:
Penetion contains cemet;Irating to eyes and skin, Penetron may
cause senstizaion by skin contact. Keep out of reach of children.
Avoid contact with skin and eyes. In case of contact with eyes, rinse
immadiatay with plenty of water and seek medical advice, Wear
sate goes Far ute naman ase rel to Mate Safety Data See.
KEEP OUT OF REACH OF CHILDREN,
‘WARRANTY:
(CS/Penetron Intemational Ltd. warrants that the produsts
manufactured ty it shall be free trom material defeats and wil
conform t formulation standards anc contain all components in thet
proper proportion. Should any ofthe products be proven defective,
the labity to ICS/Penetron Intrationa, Lt. sll be limited to
replacement af the material proven to be defective, ICS/Penetron
Intemational, Ld. shall inno ase be liable otherwise or for incidental
ar consequential damages. ICS/Penetron Intemational, Ld. MAKES
NO WARRANTY AS TO MERCHANTABILITY OR FITNESS FOR A
PARTICULAR PURPOSE AND THIS WARRANTY IS IN LIEU OF ALL
OTHER WARRANTIES EXPRESSED OR IMPLIED. User shall determina
the suitabity of he product for his intended use and assume all risks
and lib n connection therewith