AWS D1.1/01.1M:2010
Page No.
7.7 Production Control onsen 284
7.8 Fabrication and Verification Inspection Requirements senna 285
7.9 Manufacturers’ Stud Base Qualification Requirements 285
8. Strengthening and Repairing Existing Structures. 291
Sc - “
8.2. Base Metal
83 Design for Suengthening and Repair
84 Fatigue Life Enhancement
8.5. Workmanship and Technique
8.6 Quality.
Annexes
Annex A (Normative) Etfective Throat.
Annex B_(Normative)—Effective Throats of Fillet Welds in Skewed T-Joins.
Annex D_ (Normative) —Flainess of Girder Webs—Statially Loaded Structures,
Annex E_(Normative}—Flatness of Girder Webs—Cyelically Loaded Structures
Annex F (Normative) Temperature-Moisture Content Charts
Annex G_(Normative)-Manufactrers’ Stud Base Qualification Requirements.
‘Annex H (Normative) Qualification and Calibration of UT Units with Other Approved Reference Blocks.
‘Annex I (Normative}—Guideline on Alternative Methods for Determining Prebeat
Annex J (Normative}~Symnbols for Tubular Connection Weld Design
‘Annex K_ (informative) —Terms and Defnito
Annex L. (Informative}—Guide for Specification Writers
Annex M.(informative)—UT Equipment Qualification and Inspection Forms.
Annex N_ (Informative) Sample Welding Forms
‘Annex-O (Informative)—Guidelines forthe Preparation of Technical Inquiries fo the Structural Welding
Commitee sen ss soni 6S
Annex P_(Loformative)—Local Dihedral Angle: 367
Annex Q (formative) —Contents of Prequalified WPS. 373
Annex R- (Informative) —Safe Practices 375
Annex $_(nformative}—UT Examination of Welds by Alternative Techniques. 379
Annex T (nformative)—Ovalizing Parameter Alpha 395
Annex U (nformative)—List of Reference Documents st son 397
Annex V (formative) —Filler Metal Strength Properties . a 399
Commentary socom ' 4
Foreword, a sn . sven ATS
Index . 327
List of AWS Documents on Structural Welding.. 939