AWS D1.1/01.1M2010
Table Page No.
Limits on Acceptability and Repair of Mill Induced Laminar Discontinuities in Cut Surfaces, 208
Tubular Root Opening Tolerances
Camber Tolerance for Typical Girder
Camber Tolerance for Girders without a Designed Conerete Haunch
Minimum Fillet Weld Sizes
Weld Profiles
‘Weld
sual Inspection Acceptance Criteria
UT Acceptance-Rejection Criteria (Staticlly Loaded Nontublar Connections).
UP Acceptance-Rejection Criteria (Cyclically Loaded Nontubular Connections).
Hole-Type 1Q1 Requirements
Wire IQI Requitements,
IQI Selection and Placement...
‘Testing Angle
Mechanical Property Requirements for Studs
Minimum Fillet Weld Size for Small Diameter Studs...
Equivalent Fillet Weld Leg Size Factors for Skewed Joints...
Intermediate Stiffeners on Both Sides of Web.
[No Intermediate Stilfeners.
Intermediate Stiffeners on One Side Only of Web. nnn ssn
Intermediate Stiffness on Both Sides of Web, Interior Girders.. . 306
Intermediate Stiffness on One Side Only of Web, Fascia Girders 307
Intermediate Stitfness on One Side Only of Web, Interior Girders . nnn 308;
Intermediate Stiffness on Both Sides of Web, Fascia Girders... soo 309
No Intermediate Stiffeners, Interior or Fascia Girders..
Susceptibility Index Grouping as Function of Hydrogen Level “HY” and Composition Parameter P., 324
‘Minimum Preheat and Interpass Temperatures for Three Levels of Restraint... : 324
Acceptance-Rejection Criteria 7 son . nnn B84
Commentary
C21 Survey of Diameter/Thickness and Flat Width/Thickness Limits for Tubes.
C22 Suggested Design Factors
2.3 Values of ID
2.4 Structural Stee! Plates
Structural Stee! Pipe and Tubular Shapes.
2.6 Structural Steel Shapes...
C27 Classification Matrix for Applications.
C28 CVN Testing Conditions.
C31 Typical Current Ranges for GMAW-S on Steel
CAL CVN Test Values: .
C42 HAZ CVN Test Values
UF Acceptance Cotes ot 2a [50 ma Welding Using 270" Probe 500
C81 Guide to Welding Suitability . Son “S17
C82 _ Relationship Between Plate Thickness and Bur Radius... 517