EXPERTENTIME
MODULE NO. 8
Project/ Design Problems
‘NAME.
[PREPARED BY: J.8CGrIbona
1.0 OBJECTIVES.
1.1 To design programs based on written desciiptions and requirements.
1.27 demonstrate skill in devising, progamming, execuling,
troubleshooting of programs.
running, and
2.0 TASK
Given a written set of instructions related fo an industricl process’or operation, draw:
the Function Block Diagram, Identity and select the nece:
the 1/0 wing diagram, interconnecs the components, program the PLC,
demonstrate and document the operation of the project.
STAMPING DEVICE
Description: Rectangular biOcks are stampéd in a machine. Once the START
pushbutton PBI is pressed). the workpieces fed into the-machine by cylinder 1.0
from a gravity teed magazne and is clamped in place by the same cylinder. Next it
is stamped ky cylinder 20. After stamping, cylinder 20 retracts, folowed by cyinder
1.9. Once the workpiece Is uly declamped, itis ejected by cylinder 3.0.
Device
Figure 1: Stang