BENCHMARK
GPmark™ DETAIL Xmark™ DETAIL
|
\|
ZB
(
See Note 2
NOTES:
1. Lead tolerance:
a. For 2 inches +0.006 inch. re Nin.
uiside Dia,
b, Recut threads if str
2. Either benchmark type is applicable but not both.
4. CPmark: 0.125 is new condition, shall be 0.062 min, after refacing.
b. Xinark: 0.063 is new condition. After refacing « visible step
on the benchmark shall remain on the primary shoulder.
Rethreading is required i there is no visible benchmark
3. At Ouiside Diameter less than 4,000, Bevel Diameter is void
and 1/32" x 45° becomes effective
4, Minimum 0.0. based on wall thickness at counterbore. Larger 0.0
may be required for specific grade performance.
5. Surface finish requirement only applies during refacing operation
6. Area of the connection where piting is not permitted in the thread roots
LP 0.08:
( See Note 2 /
\ Bevel co. ‘SHOULDER (EXTERNAL SEAL)
- 0.125,
ich exceeds 0.006 inch in 2 inches. See Note 4
|-—— 3.896 #008
(0X CONNECTION LENGTH)
DETAIL _B
1.844 Mi,
Pit Free Zone |— [~ See Detail B
See Note 6
SECONDARY
WUKE-UP SHOULDER
Fy (INTERNAL MECHANICAL STOP)
2531 Ref. Dia
17/32" Max, x 45° Ref
Breck Edge Thread taper 2.000 per
4 Threads per inch
See Note 3
alg] jggsee ‘ DIMENSIONS wTHOUT)
g/2| jaa Grant Prideco) yo cewces axe GPOS™ 31. Box
Lek? gIN@Y woes... | FOR REFERENCE | FIELD INSPECTION DIMENSIONS
By. alajclata|2|e INFORMATION ONLY
s/ BL [BS aisis mr oc |
- 2 ieee TM Pit bee Ar aT
Date: ke | [dela peas sina Moe 1 LEO? 1 Toft [05