You are on page 1of 3

TRILENE HF10TQ Page 1 from 3

PT. TRI POLYTA INDONESIA Tbk

MATERIAL SAFETY DATA SHEET


SECTION 1: PRODUCT AND COMPANY IDENTIFICATION
Product Name : TRILENE HF10TQ
Chemical Name : POLYPROPYLENE HOMOPOLYMER
Manufacturer : PT. TRI POLYTA INDONESIA Tbk
Address : JL. RAYA ANYER KM.123 CIWANDAN - CILEGON - WEST JAVA - INDONESIA
Phone : 62 - 254 601066
Fax : 62 - 254 601081

Acute Health Fire Reactivity Hazard Rating:


0 1 0 Least = 0 High = 3
Slight = 1 Extreme = 4
Moderate = 2

SECTION 2 : PRODUCT INGREDIENT


No. Composition CAS - Number Percent
1 POLYPROPYLENE HOMOPOLYMER 9003-07-0 > 99
2 MINOR ADDITIVES - <1
* The information presented in this MSDS is applicable to all above grades.

SECTION 3 : HEALTH INFORMATION


The health effects below are based upon component health effects consistent with requirement under
OSHA Hazard Communication ( 29 CFR 1910.1200 )

Eye Contact : Product fines can cause mechanical irritation


Skin Contact : Product is unlikely to cause irritation
Inhalation : Product fines may cause mechanical irritation
Ingestion : Product is practically non-toxic
Signs and Symptoms : Irritation as note above
Aggravated medical condition : Preexisting eye and respiratory disorders may be aggravated by exposure
to product fines

SECTION 4 : OCCUPATION EXPOSURES LIMITS


OSHA NO. PEL/TWA
ACGIH PEL/CEILING
OTHER TLV/TWA
TLV/STEL
* No OSHA / PEL or / ACGIH / TLV has been established

SECTION 5 : EMERGENCY AND FIRST AID PROCEDURES


Eye Contact : Flush eyes with water if irritation occurs
Skin Contact : If skin contact with molten product occurs, treat as for thermal burn
Inhalation : Not ordinarily required
Ingestion : Not ordinarily required
Note to Physician : If irritation to fines persists, get medical attention
TRILENE HF10TQ Page 2 from 3

SECTION 6 : SUPPLEMENT INFORMATION


None Identified

SECTION 7 : PHYSICAL DATA


Boiling Point ( DEG C ) : Not Applicable
Melting Point ( DEG C ) : 163 O C
Evaporation Rat (N-Butyl Acetate=1) : Not Applicable
Specific Gravity ( H20 = 1 ) : 0.905
Solubility ( IN WATER ) : Insoluble
Vapor Pressure ( MM HG ) : Not Applicable
Vapor Density ( AIR = 1 ) : Not Applicable
Appearance and Odor : Solid, Essentially odorless pellet.

SECTION 8 : FIRE AND EXPLOSION HAZARD

Flash Point : 350 O C


Flammable limits / % volume in air : Lower: Not applicable Upper: Not applicable
Extinguishing Media : Use water fog, foam, dry chemical or CO2
Special fire fighting procedures and
precaution : Material will not burn unless preheated. Do not enter confined fire space
without full bunker gear ( helmet with face shield, bunker coats, gloves and
rubber boots ) including a positive pressure niosh approved self-contained
breathing apparatus cool fire exposed containers with water.
Unusual fire and explosion hazards : Treat as a solid that can burn, molded parts generally burn slowly with
a low smoke density and flaming drips under certain condition can burn with
a high smoke density.

SECTION 9 : REACTIVITY
Stability : Stable
Hazardous Polymerization : Will not occur
Condition and material to avoid : Strong oxidizing agents
Hazardous Decomposition products : Thermal decomposition products are highly dependent on the combustion
condition. A complex mixture of airbone solid. Liquid particulates and gases
will evolved when this material undergoes pyrolisis or combustion. Carbon
monoxide and unidentified organic compounds may be formed upon
combustion.

SECTION 10 : EMPLOYEE PROTECTION


Respiratory Protection : Not ordinarily required
Protective Clothing : Not ordinarily required

SECTION 11 : ENVIRONMENTAL PROTECTION


Spill or Leak procedures : Shovel and sweep up or industrial vacuum cleaner, avoid generating dust
clouds. Put into containers for reclaiming or disposal
Waste Disposal : Place in an appropriate disposal facility in compliance with local
regulation.
Environmental Hazard : Not applicable
TRILENE HF10TQ Page 3 from 3

SECTION 12 : SPECIAL PRECAUTIONS


Treat as a solid that can burns. Store away from oxidizing materials, in a cool dry place with adequate ventilation.
Bond and ground transfer equipment.

SECTION 13 : TRANSPORTATION REQUIREMENTS


Department of transportation classification : Not hazardous by D.O.T regulation

SECTION 14 : OTHER REGULATORY CONTROLS


The component of this product are listed on the EPA/TSCA Inventory of chemical substance. The information
contained herein is based on the data available to us and is believed to be correct. However Tri Polyta makes no
warranty, expressed or implied regarding the accuracy of there data or the result to obtained from the use.
Thereof Tri Polyta assumes no responsibility for injury from the use of the product described herein.

*******************************************************************************************
END OF MSDS
*******************************************************************************************

Date Prepared :
Date revision : 10 Maret 2005
Revision : TPI M - MSD - 0002 - 1

You might also like