HEIGHT FROM GROUND IN FEET
G crove. TMS250C
Carrier mounted hydraulic crane /85% Domestic
A -_ WORLDWIDE COMPANY 33 ft. - 80 ft. full power boom
WORKING RANGE DIAGRAM
(BOOM DEFLECTION NOT SHOWN)
t ~ H+++ eee
: pea
E
» ~ : E
: H eel
<— on orun
‘OPERATING RADIUS FROM AXIS OF ROTATION IN FEETDOMESTIC 85% LIFTING CAPACITIES (POUNDS)
ON OUTRIGGERS FULLY EXTENDED
MAIN BOOM - 360°
if reo or wT
rads
i Main Boom terath in Feet
SE
To | 7.088. | 52.0007 | 50007
(6a) | os) | (70)
‘ote () oom aes area degrees
{1M operating coe. Two fort ode depend on
[dls ler iM mal rns.
[iene voor-ange (ean for rated Boor eth (0 oud °
lexan boom eng ee at 0 boom ang ro 233) BO] assay oor crser
MAIN BOOM - OVER REAR
ore
SDs Ls = ~s pe >e >a] #
whee pape i
ee ares
SS pee pra same
Te | 200 | #23900", 0007 | 40.200" 36 G00, | SF 000
e (54) | 69.5) | (64) (675) | (70.5) 72.5)
Sor} Ser oe poe ae ee
20 (a2) | (50) | (565) | (61) J (45) | (67.5)
[ae ane [ea a
za | seneadetae ee |
ee ee pe
» (24.5) | (38.5) | 147) 152.5) J (57)
coriarn
lof |e
or | 30
fe (285) | (37.5)
7 (13) (29)
TL 6770
4 (185)
e
5 tl pee
eet eae
“ 4 sees act
é a at .N6-829-007634 & 007587
[lesrorboor nat eet at O° boom ange ire 638) aNOTES FOR
LIFTING CAPACITIES
‘WARNING: THIS CHART IS ONLY A GUIDE. The Notes below
are for illustration only and should not be relied upon to
‘operate the crane. The individual crane’s load chart,
‘operating instructions and other instruction plates must be
read and understood prior to operating the crane.
1. All rated loads have been tested to and meet minimum requirements
of SAE J1063 OCT8O - Cantilevered Boom Crane Structures - Method
of Tes, and do not exceed 85% of the tipping load on outrigger as
determined by SAE J765 OCT 80 Crane Stability Tet Code.
2. Capacities given do not include the weight of hookblocks, stings,
auliary lifing equipment and load handling devices. Their weights
MUST be added tothe load to be lifted. When more than minimum
required reeving is used, the additional rope weight shall be
considered part ofthe loa.
Capacities appearing above the bold line are based on structural
strength and tipping should not be relied upon as a capacity
limitation,
All capacities are for crane on firm, level surface. It may be
necessary to have structural supports under the outrigger floats or
tires to spread the load to a larger bearing surface.
5. When ether boom length or radius or both are between values listed,
the smallest load shown at either the next larger radius or boom
length shall be used
6. Tires shall be inflated to the recommended pressure before litng on
rubber.
For outrigger operation, ALL outriggers shall be fully extended with
tires raised fre of ground before raising the boom or litng loads
Cost inproencat and ngnerng pores make it ees that we reserve ert
to make specication, equipment, an pice changes witout noc. Msaons shown
may ince eptional equipment and accesories aad may not include all stand
csp.
GROVE.
Wa worldwide
Grove Worldwide - World Headquarters
1565 Buchanan Trail Bast
Shady Grove, Pennsylvania 17256
Phone: (717) 597-8121. ax: (717) 597-4062
Grove North America
P.0. Box 21, Shady Grove, Pennsylvania 17256
‘Western Hemisphere, AsiaPacitic
Phone: (717) 597-8121. Fax: (717) 597-4062
Grove Europe”
Sunderland, England SR4 61T
Europe, Atica, Middle Eas, Near East
Phone:(0191)565-6281 FAX:(0191)564-0442
Grove Europe Limited, Reglstered in England, Number 1845128, Registered
‘ofc, Crown Works, aon, Sunderland, Tyne & Wear, England SRA GT.
FORM NO LC-TMS250C 85% DOM. PAC3-347 895.5M PRINTED INUS.A
30 FT. FIXED LENGTH EXTENSION
(ON OUTRIGGERS FULLY EXTENDED- 360°)
Man [00051 or #51 | #0052 or #32 | #0053 or #53
Boom [on onrser | 1s" orFser [30° OFFSET
Angle [fad |eapaciy] Rad [Capaciy] Rad [capac
(809) Jef. try] ios) fret. fe} ts.) fret. fea} bs.)
7] 267 rosso] a2 [eso] a88 [SaT0
7 [357 [aro] ave [eso] «72 [aso
5 | aaa 49.9 | 5550 552 [4a7o
60 | 527 578 [410 | 627
370
2610
a5 1,570)
40 1,130
‘0 operating code, Refero Ut mana fornia, 6 29.076844
30 FI. FIXED LENGTH EXTENSION
(ON OUTRIGGERS FULLY EXTENDED- OVER REAR)
Wan [200ST or #51 [| #0057 or #5? | FOOSE or WSS
Or OFSeT | _tSTOFFSET_[_ 30" OFFSET
[sr [sao] sre [soo oor [700]
ar [a]
[WARNING FOR 30 FT. BOOM EXTENSION: For main boom length greater
than 62 ft. with 30 ft fixed length boom extension in working position, the
‘boom angle must not be less than 37° since loss of stability will occur
causing a tipping condition. The boom angle isnot restricted for main
‘boom length equal to or less than 62 f. This warning applies for boom
extension erection purposes also.
FORLARGEST
t OOK mLOcx AND
4-6 wmianniTwo
oc ACTIVATED.30 FT. - 54 FT. TELE. EXTENSION ON OUTRIGGERS FULLY EXTENDED - 360°
Main 30 A LENGTH a7 ENGST Saft LENGTH
Boom wears | sen] — aa a
Angle orm | rant | oraz erat | crear
(40a) [or orrset | 15" oFFstt [30° OrrseT TS" OFFSET | 30° OFFSET | O° OFFSET | 15" OFFSET
Fn] to000 [7300 | 4850 | 7700 [3080 | 3750} 6150 |) 750
67) | G28) | Gee} co) | G93 | a2) | sn | 460)
70 | 8430 | 6170 | 4450 | 6950 | «610 | 3460 | 5.340 | 3,300
sy | me | 2 | wos | ase | oz | «oo | 664)
ep ere 580 sa] sam] sae aes
(asa) | us) Gos) | Gan | is6 | 665)
oo | 250 J ano 4390 | 3360 Zao] 3.470
(27) Foes) | 627 | sas) | cen F036) | os)
rs 30807 | 2450 660
(653) | (69.2) (09)
co | 2.870 | 2.110 | 1.860 7,050
: (631) | G22) | 061, (7)
Te reo | 1200 | 1070
750) } Gee | 19)
Yo: Hf ae et swan. o7er74
operating cde Teo fo ght cade depends on LM stem
Rede Ut anal forts
30 FI. - 54 FT. TELE. EXTENSION ON OUTRIGGERS FULLY EXTENDED - OVER REAR
30 ft. LENGTH 42 ft LENGTH 54H. LENGTH
6,170 90 | 6950 | 4610 160 | 5,340 300
(x6) | (47.2) | (aos) | (aes) | 571) | oo) | 664)
300 4380, [29707]
7 56.
4,450 3,360 | 7,890 | 3.470 | 2,670
78) (667) | (736) | (665) | 052)
4370 0 480 io
(60.7) | (653) | 97) J (6s. (749)
370 | 3090 | 3100 | 2610 | 2,360 70 | 2,030
ay | 27 | ven | cea | 2s [er | eso) | 027)
3180 o | 2600 faz pf tose | 2140 tao, s
75.0) Ges) J (819) | i840) J veo 937) | 193.3) J 100) 0
Z600 | 2350] 2,040 | 2,210 f 1a50-] 1,610 | 1,820 f 1.540
(sz) | ea) | arn) | wos) J 95.) | (99.0) | 101.0) f (1058) | (1102)
7,600 1480 J 77330 to] 1180 70
(97.2)_J ort) | 035) f (107.9 | tae. | aise)
1380 | 7,190 1.110
(1027) | (105.7) (13.2)
7,100
(197.3)
Noe () Reference al ar ft 8290094088
‘operating code. Two for tpt de depen oo LM se
Ale Lt seal fr autos
* WARNING FOR 30 FT. BOOM EXTENSION: For main boom length greater than 56 ft. with 30 f tele. boom extension in
working position, the boom angle must not be less than 45° since loss of stability will occur causing a tipping condition.
‘The boom angle is aot restricted for main boom length equal to or les than 56 f.
‘* WARNING FOR 42 FT. BOOM EXTENSION: For main boom length greater than 50:
working position, the boom angle must not be less than 49° since los of stability
‘The boom angle isnot restricted for main boom length equal to or less than 50 ft.
with 42 f. tele. boom extension in
ll occur causing a tipping condition,
* WARNING FOR 54 FT. BOOM EXTENSION: For main boom length greater than 44 ft. with 54 ft, tele. boom extension ia
working position, the boom angle must not be less than $3° sinee loss of stability will occur causing a tipping condition,
‘The boom angle is not restricted for main boom length equal to oF les than 44 f.
‘This warning applies for boom extension erection purposes also.LINE PULLS AND REEVING INFORMATION WEIGHT REDUCTIONS FOR
LOAD HANDLING DEVICES
PERSE
bo Coes LINE PULLS: "30 ft, BOOM EXTENSION,
Tana |e tenn sco] ma am
MAIN & AUX Rotation Resistant 8.496 bs, Faces so
Min. Breaking Str 45,400 bs ion RT ROUT |
— sad om
waneaage [omer mY Saas
Min, Breaking St. 41,200 Is. Tao
1/2" (13 mm) 18x19 Class or 35x7_
Gree Rotation Resistant 5,840 is, pa nT RSET RT] TE
Min. Breaking Str. 29,200 Ibs. OOKBLOCKS and HEADACHE BALLS
ian =
eee ae
estate on | oe
Aton ee
AREA OF OPERATION “+Refer to rating plate for actual weight
center oF
Soiaisee
Septee
Sue
SE, Ging
See
6-829-005671
‘ZERO DEGREE BOOM ANGLE CHARTS - 360°
Lifting Capaci
‘on Outriggers - 360 degrees at Zero Degree Boom Angle
Main Boom Length in Feet
Angle [33 38 a 50 36 62 6B 7a
00 | 8720 310 S40 [4,460 f 3.410 | 2,480 | 1,810
(33.2) | (39.2) | (45.2) | (51.2) Bf (57.2) | (63. (69.2)
(Reference Rai are in Feet
80.
370
(75.2)
6.29-000656,
Lifting Capacities on Outriggers - Over Rear at Zero Degree Boom Angle
Main Boom Length in Feet
Angle_ [3
3 38 a 30, 36 o oo 7
a 18720 | 6910 460, | 3,600 | 2880 | 2.280
= £083 | 33.2) | 39.2) (51.2) | (57.2) J (63.2) | (69.2)
() Reference Rai are in Feet.
1,770,
(75.2)
29. 009657TMS250C
Carrier-Mounted Hydraulic Crane SpecificationsSuperstruciure specifications
Boom 32 ft. to 80 ft, (0.8m-24.4m) three section MYDRAULIC SYSTEM
Trapevoidal full power boom. Telescoping is Pumps. One, 3-section gear punip driven aff transmission
mechanically synchronized with single lever contra, PTO with manual pump disconnect. Combined
Telescopic sections slide on adjustable and capacity 112.5 GEM (426 LPM).
replaceable Nvicron wear pads. Valves Precision four way double acting control valves, 3
Maocitnum Tig Height: 85 fl (25.9m) individual valve banks pecmit simultaneous control of
Swingaway 30 ft. (9.4m) lattice swingaway boom extension multiple erane functions.
Extension stows alongside base boom section whea not in use, Filter Suction line type, fall flow with by-pass protection and
voffsettable at 0°, 15° or 30°. filter by-pass indicator, replaceable cartridge, 7/17/22
Maximum Tip Height: 114 4. (34.7m), micron filration rating,
‘Optional 30 ft. to 34 f. (9.1m- 6.5m J telescopic Latice Reservoir R6 pallons (326 1) with spin-on breather filter,
Telescopic ‘swingaway extension with offset links, offsettable external sight gauge, clean oul access, stray mounted
Swingaway arf°, 15° or 30°. Siows alongside base boom when to frame.
Gil Cooler Full flow, fin and tuhe, oil to air.
137 fl. (418m). HOIST SPECIFICATIONS:
Boom Nose jounted on heavy duty tapered Power up and down, equal speed, planetary reduction
ith removable pin-type rope guards. ‘with integral automatic brake and clectroaic hoist
‘Optional removzhle auxiliary hoom nese with drum rotation indicater.
removable pin wpe rope guard.
Beom Elevation ‘One double acting hydraulic cylinder with integral Grove Main Hoist H0158-20 and
holding valve provides clevation from -4° to “Aux. Hoist HOL5SB-20
Load Mement Standard load moment and anti-two block system with Make/Model Main Auxiliary
& Anti-Two audiv-vistial warning and control lever lockout. These Maximum Bottom layer 298 FPM 161 FPM
Block System systems provide electronic display of boom 2ngle, single line (lm/min) (49m/nin)
length, radius, tip height, relative load mement, speed intermediate 352 FPM 190 FEM
maximum permissible load, load indication and laver (L07mymin) (S8mvmin)
warning of impending two-block condition. Top layer 379 FPM 205 FEM
Cab Full vision, all stecl fabricated with acoustical lining (L16n/min} (62nvmin}
and tinved safety glass throughoul. Dash panel Maximum Bottom layer 8,496 Ibs, 4.496 Ibs.
incorporates gauges for all engine functions. Other single line (3854 kg} (3854 kp)
standard features include: hinged skylight, stiding bet pull Intermediate 7,194 Ibs, 7,194 Ibs,
side door and sliding right side window, electric layer (3263 kp) (3263 kg)
windshield wash/wipe, circulating air fan, heater, Top layer 6,681 Ibs. 6,081 Ibs,
swing born, fire exttaguisher, scat helt, *Optional (A031 kg) (3031 kp)
jiems: electric. skylight wiper and air conditioning. Maximum 8,496 Ths, 8.496 Ibs,
Swing Roller bearing swing circle with $60°continnous permissible (3854 ky) (3854 kg)
rotation, Grove planetary “glide-swing” with foot line pull
actuated disc brake, spring applied hydraulically w/5:1 strength factor 5/8 in (1.6mm) 18x19 class wire rope
released park brake and 360° position positive Maximum 450 ft. of 58" dia. rope
‘turntable lock, Combination controls provided for rope (137m of Lamm)
and or foal operation. Swing speed 3.6 RPM. stowage Note: 450 ft. (137m) length of wire rope supplied with basic
Counterweight Fixed position pinned to turniable, (Weight varies unit,
depending on hoist configuration).
“Denotes optional equipmentCarrier specifications
Frame High strength alloy steel all welded box-type
construction with integral outrigger housings and
fronv/rear lifting, towing and tie down lugs.
Outrigger Hydraulic single stage double box telescopic beam and.
System jack outriggers with integral holding valves. All steel
fabricated quick release type outrigger floats 24 in.
(610mm) diameter. Maximum outrigger pad load
95.213 Ibs. (25,044 ky), Mandand fifth front stabilizer
for 360° duties.
Located in the superstructure cab, Push button
controls requiring two-handed operation,
Crane level indicator (sight bubble} adjacent to
controls.
OOTAS.3 Cummins six cylinder turbocharged water
cooled diesel. 210 hp (157 kw) (Gross) @ 2400
RPM, Maximum net torque G05 ft. Ibs. (84 ke/nn) @
1300 RPM,
Outrigger
Controls
ging
Fuel Tank (1) 60 gallons (227 Ly
Capacity
Electrical Four 12-volt - maintenance free batteries,
System 24 voll starting,
Drive ox
Steering Front axle steering, rack and pinion desiga with
hydraulic assist.
Transmission Manual with 13 speeds forward, 3 reverse.
Axles Front: 1 steer, beam type
Rear: 2.83 drive axles with inter-ale
differential locks.
Suspension Front axle (1) spring mounted, Rear astes (2) solid
mount tandem with equalizing beam and solid steel
saddles
Tires Front: 425/05R22,5
Rear: 00x20-12PR
Opti Rear: 10.00x20-12PR
Brakes Full air on all wheels. Air dryer provided to preclude
moisture accumulation. Spring sel emergency brake
on both rear axles with cmergency release.
Lights Full lighting including head, tail, braking, reversing,
fog, directional and hazard warning lights.
Cab ‘One man design, all steel fabricated with acoustical
Lining and tinted safety glass throughout, Deluxe fabric
covered fully acljustable seat. Complete deiving
controls and engine instrumentation including
tachometer, speedometer, voltmeter, water temp., oil
pressure, fuel level, air pressure gauge with AV
warning. Other standard items include hot water
heater/defroster, electric windshield wash/wipe, fire
extinguisher, seat belt and door and window locks.
Maximum 5) 52 MPH (83,7 kph)
BASIC STANDARD MACHINE
Gross Vehicle Front: 16,762 Ibs. (7,603 kg)
‘Weight & Axle Rewr Tandem: — 33,982 Ibs. (15 414 hy)
Loads OFM: 50,744 Ibs. (23,017 kp)
Miscellaneous Dual rear view mirrors, hookblock tiedawn sling,
‘Standard electronic back-up alarm, air cleaner service
Equipment indicator, fuel/water separator and ether cold start
aid. Sling box.
jo Immersion engine block Theater, engine Tow oil
Equipment pressure/bigh water temperature audio visual warning
and tire inflation kit.
“renotes aptioaal equipment.Dimensions
(3491)
TAILSWING:
if
40° 5 7/16"
(12330)
+ von)
fe Srey 7 Lisi ae ~ 51/8"
V8" (319) | WO Ga) JL | Gaa
pu } —_
Ts
é 3385) L. 10°3" 710" 16 Bie fF (200)
(2888) 4
5115/16 Pay 14) gsasy "38
(1811) (9957) = ROTATION
¢ Workdwide - World Headquarters
Rast
CUCL
aed ea
Deru aris
fa] ) ro oem eR wc hee Oe ee ee rd
rent LG
ST Ue
Do
Peet a hbo a oo Soe Ma