Professional Documents
Culture Documents
This equipment has been tested and found to comply with the limits of a Class
B digital device, pursuant to Part 15 of the FCC Rules. These limits are designed
to provide reasonable protection against harmful interference in a residential
installation. This equipment generates, uses, and can radiate radio frequency
energy and, if not installed and used in accordance with the instructions, may
cause harmful interference to radio communications. There is no guarantee
that interference will not occur in a particular installation.
The content of this user’s manual is subject to be changed without notice and
we will not be responsible for any mistakes found in this user’s manual. All the
brand and product names are trademarks of their respective companies.
Note: The package contents may be differed by area or your motherboard version.
LGA 775
Supports Hyper-Threading / Execute Disable Bit /
Intel Core2Duo / Pentium Dual-Core /
Enhanced Intel SpeedStep® / Intel Architecture-64 /
CPU Celeron Dual-Core / Celeron 4xx
Extended Memory 64 Technology / Virtualization
processor
Technology
(Maximum Watt: 65W)
Intel G31
Chipset
Intel ICH7
DIMM Slots x 2
Dual Channel Mode DDR2 memory module
Main Each DIMM supports 256MB / 512MB /
Supports DDR2 800/667
Memory 1GB / 2GB DDR2
Registered DIMM and ECC DIMM is not supported
Max Memory Capicity 4GB
CPU Fan header x1 CPU Fan power supply (with Smart Fan function)
PS/2 LAN
Mouse Line In/
Surr ound
Line Out
Mic In 1/
Bass/ Center
Since the audio chip supports High Definition Audio Specification, the function of each audio
jack can be defined by software. The input / output function of each audio jack listed above
represents the default setting. However, when connecting external microphone to the audio port,
please use the Line In (blue) and Mic In (Pink) audio jack.
JKBMS1 JCFAN1
LGA775 JATXPWR1
CPU1
J ATX PWR 2
DDR2_ A 1
DDR2_ B 1
J VGA 1
JUSB2
JUSB V1
BAT1 Intel
IDE 1
G31
JRJ45USB1
JAUDIO1
JAUDIOF1
PEX16_1
LAN
BIO S
JUSB3
JCOM2
Super
I/O
(Optional)
FDD1
Intel
PCI1 ICH7
S ATA 1
JPRNT1 JPANEL1
Codec
SATA2
JCMOS1
Special Notice:
Remove Pin Cap before installation, and make good preservation
for future use. When the CPU is removed, cover the Pin Cap on the
empty socket to ensure pin legs won’t be damaged.
Pin-Cap
Step 1: Pull the socket locking lever out from the socket and then raise
the lever up to a 90-degree angle.
Step 2-2:
Step 3: Hold the CPU down firmly, and then lower the lever to locked
position to complete the installation.
Step 4: Put the CPU Fan and heatsink assembly on the CPU and buckle it
on the retention frame. Connect the CPU FAN power cable into
the JCFAN1. This completes the installation.
1
Pin Assignment
1 Ground
2 Power
3 FAN RPM rate sense
4 Smart Fan Control
Note:
The JCFAN1 supports 4-pin head connector. When connecting with wires onto the
connector, please note that the red wire is the positive and should be connected to pin#2,
and the black wire is Ground and should be connected to GND.
DD R2_A1
DD R2_B1
1. Unlock a DIMM slot by pressing the retaining clips outward. Align a
DIMM on the slot so that the notch on the DIMM matches the break
on the Slot.
2. Insert the DIMM vertically and firmly into the slot until the retaining
chip snap back in place and the DIMM is properly seated.
B. Memory Capacity
The DRAM bus width of the memory module must be the same(x8 or
x16)
2 34
1 33
40 39
2 1
10
PEX16_1
PCI1
11
PWR_LED
On/Off
++
-
9 16
1 8
+ -
SPK RST
HLED
12
12 24
1 13
3 2
Pin Assignment
1 +12V
4 1
2 +12V
3 Ground
4 Ground
Note:
Before power on the system, please make sure that both JATXPWR1 and JATXPWR2
connectors have been plugged-in.
13
Pin Assignment
1 +5V (fused)
2 +5V (fused)
3 USB-
4 USB-
5 USB+
6 USB+
7 Ground
8 Ground
9 1 9 Key
10 NC
10 2
Pin Assignment
1 Mic Left in
2 Ground
3 Mic Right in
4 GPIO
10 9 5 Right line in
6 Jack Sense
7 Front Sense
8 Key
2 1
9 Left line in
10 Jack Sense
14
1
3
Pin 2-3 Close:
1 Clear CMOS data.
Pin Assignment
1 Ground
2 TX+
3 TX-
4 Ground
5 RX-
6 RX+
7 Ground
SATA1
SATA2
7 4 1
15
1
Pin 1-2 close
1
3
1
Pin 2-3 close
Pin Assignment
1 Carrier detect
2 Received data
3 Transmitted data
4 Data terminal ready
5 Signal ground
6 Data set ready
7 Request to send
2 10 8 Clear to send
9 Ring indicator
10 Key
1 9
16
1 25
17
You will see the following window after you insert the CD
The setup guide will auto detect your motherboard and operating system.
Note:
If this window didn’t show up after you insert the Driver CD, please use file browser to
locate and execute the file SETUP.EXE under your optical drive.
A. Driver Installation
To install the driver, please click on the Driver icon. The setup guide will
list the compatible driver for your motherboard and operating system.
Click on each device driver to launch the installation program.
B. Software Installation
To install the software, please click on the Software icon. The setup guide
will list the software available for your system, click on each software title
to launch the installation program.
C. Manual
Aside from the paperback manual, we also provide manual in the Driver
CD. Click on the Manual icon to browse for available manual.
Note:
You will need Acrobat Reader to open the manual file. Please download the latest version
of Acrobat Reader software from
http://www.adobe.com/products/acrobat/readstep2.html
18
Launching Software
After the installation process, you will see the software icon “eHOT Line” /
“BIOS Update” appears on the desktop. Double-click the icon to launch the
utility.
eHot-Line (Optional)
eHot-Line is a convenient utility that helps you to contact with our
Tech-Support system. This utility will collect the system information which is
useful for analyzing the problem you may have encountered, and then send
these information to our tech-support department to help you fix the problem.
Before you use this utility, please set Outlook Express as your default e-mail client application program.
represents important
*informa ti on that you
This bl ock will show
must provide. Wi thout
this information, you may
the i nformation which *Describe conditi on
of your system.
would be collected in
not be able to send out the mail .
the mail.
If you want to save this information to a .txt file, click “Save As…” and then you
will see a saving dialog appears asking you to enter file name.
We will not share customer’s data with any other third parties,
so please feel free to provide your system information while using
eHot-Line service.
If you are not using Outlook Express as your default e-mail client
application, you may need to save the system information to a .txt file
and send the file to our tech support with other e-mail application.
Go to the following web
http://www.biostar.com.tw/app/en-us/about/contact.php for getting
our contact information.
20
BIOS Update
BIOS Update is a convenient utility which allows you to update your
motherboard BIOS under Windows system.
Update BIOS
with a BIOS file
<Backup BIOS>
21
<Update BIOS>
Before doing this, please download the proper BIOS file from the website.
For AWARD BIOS, update BIOS procedure
should be run with Clear CMOS function, so
please check on Clear CMOS first.
While the system boots up and the full screen logo shows, press <Delete>
key to enter BIOS setup.
In the BIOS setup, use the Load Optimized Defaults function and then Save and
Exit Setup to exit BIOS setup. BIOS Update is completed.
22
Automatically download and update the latest BIOS via internet; make sure
that the computer is connected to the internet before using this function.
The programming procedure may take minutes, please do not make any
operation during the programming process.
While the system boots up and the full screen logo shows, press <Delete>
key to enter BIOS setup.
In the BIOS setup, use the Load Optimized Defaults function and then Save and
Exit Setup to exit BIOS setup. Online Update is completed.
All the information and content above about the T-Series software are subject to be
changed without notice. For better performance, the software is being continuously
updated. The information and pictures described above are for your reference only.
The actual information and settings on board may be slightly different from this manual.
23
After confirmed, please follow steps below to relief the CPU protection
function.
1. Remove the power cord from power supply for seconds.
2. Wait for seconds.
3. Plug in the power cord and boot up the system.
Or you can:
1. Clear the CMOS data.
(See “Close CMOS Header: JCMOS1” section)
2. Wait for seconds.
3. Power on the system again.
24
BIO-Flasher
BIO-Flasher is a BIOS flashing utility providing you an easy and simple way to
update your BIOS via USB pen drive or floppy disk.
The BIO-Flasher is built in the BIOS chip. To enter the utility, press <F12>
during the Power-On Self Tests (POST) procedure while booting up.
2. Then, save the BIOS file into a USB pen drive or a floppy disk.
3. Insert the USB pen drive or the floppy disk that contains the BIOS file to the
USB port or the floppy disk drive.
6. After the update process, the utility will ask you to reboot the system.
Press <Y> to proceed. BIOS update completes.
z This utility only allows storage device with FAT32/16 format and single
partition.
z Shutting down or resetting the system while updating the BIOS will lead to
system boot failure.
25
26
4.5 TROUBLESHOOTING
Probable Solution
1. No power to the system at all 1. Make sure power cable is
Power light don’t illuminate, fan securely plugged in.
inside power supply does not turn 2. Replace cable.
on. 3. Contact technical support.
2. Indicator light on keyboard does
not turn on.
System inoperative. Keyboard lights Using even pressure on both ends of
are on, power indicator lights are lit, the DIMM, press down firmly until the
and hard drive is spinning. module snaps into place.
System does not boot from hard disk 1. Check cable running from disk to
drive, can be booted from optical drive. disk controller board. Make sure
both ends are securely plugged
in; check the drive type in the
standard CMOS setup.
2. Backing up the hard drive is
extremely important. All hard
disks are capable of breaking
down at any time.
System only boots from optical drive. 1. Back up data and applications
Hard disk can be read and applications files.
can be used but booting from hard disk 2. Reformat the hard drive.
is impossible. Re-install applications and data
using backup disks.
Screen message says “Invalid Review system’s equipment. Make sure
Configuration” or “CMOS Failure.” correct information is in setup.
Cannot boot system after installing 1. Set master/slave jumpers
second hard drive. correctly.
2. Run SETUP program and select
correct drive types. Call the drive
manufacturers for compatibility
with other drives.
27
LGA 775
Unterstützt Hyper-Threading / Execute Disable Bit /
Intel Core2Duo / Pentium Dual-Core /
Enhanced Intel SpeedStep® / Intel Architecture-64 /
CPU Celeron Dual-Core / Celeron 4xx
Extended Memory 64 Technology / Virtualization
Prozessoren
Technology
(Maximales Watt: 65W)
Intel G31
Chipsatz
Intel ICH7
HD
Unterstützt High-Definition Audio
Audio-Unters ALC662
5.1-Kanal-Audioausgabe
tützung
28
PCI-Steckplatz x1
Steckplätze
PCI Express x16 Steckplatz x1
"CMOS löschen"-Sockel x1
Stromanschluss (24-polig) x1
Stromanschluss (4-polig) x1
PS/2-Tastatur x1
PS/2-Maus x1
Rückseiten-E VGA-Anschluss x1
/A LAN-Anschluss x1
USB-Anschluss x4
Audioanschluss x3
29
FRENCH
SPEC
Intel G31
Chipset
Intel ICH7
Mémoire Chaque DIMM prend en charge des DDR2 Prend en charge la DDR2 800/667
principale de 256Mo / 512Mo / 1Go / 2Go Les DIMM à registres et DIMM avec code correcteurs
Prise en
Prise en charge de l'audio haute définition
charge ALC662
Sortie audio à 5.1 voies
audio HD
Fente PCI x1
Fentes
Fente PCI Express x16 x1
30
Connecteur Audio du panneau avant x1 Prend en charge la fonction audio du panneau avant
Connecteur d'alimentation x1
(24 broches)
Connecteur d'alimentation x1
(4 broches)
Clavier PS/2 x1
Souris PS/2 x1
E/S du
Port VGA x1
panneau
Port LAN x1
arrière
Port USB x4
Fiche audio x3
Dimensions
170 mm (l) X 225 mm (H)
de la carte
31
ITALIAN
SPECIFICA
LGA 775
Supporto di Hyper-Threading / Execute Disable
Processore Intel Core2Duo /Pentium
Bit / Enhanced Intel SpeedStep® / Architettura
CPU Dual-Core / Celeron Dual-Core /
Intel 64 / Tecnologia Extended Memory 64 /
Celeron 4xx
Tecnologia V irtualization
(Watt massimo: 65W)
Intel G31
Chipset
Intel ICH7
Alloggio PCI x1
Alloggi
Alloggio PCI Express x16 x1
32
Connettore alimentazione x1
(24 pin)
Connettore alimentazione x1
(4 pin)
Tastiera PS/2 x1
Mouse PS/2 x1
I/O
Porta VGA x1
pannello
Porta LAN x1
posteriore
Porta USB x4
Connettore audio x3
i scheda (altezza)
33
SPANISH
Especificación
principal 512MB / 1GB / 2GB No admite DIMM registrados o DIMM compatibles con
Ranura PCI X1
Ranuras
Ranura PCI Express x16 X1
Conectores Conector disco flexible X1 Cada conector soporta 2 unidades de disco flexible
34
Conector de alimentación X1
(24 patillas)
Conector de alimentación X1
(4 patillas)
Teclado PS/2 X1
Ratón PS/2 X1
Panel
Puerto VGA X1
trasero de
Puerto de red local X1
E/S
Puerto USB X4
Conector de sonido X3
Tamaño de
170 mm. (A) X 225 Mm. (H)
la placa
Soporte de
Biostar se reserva el derecho de añadir o retirar el
sistema Windows 2000 / XP / VISTA 32/ VISTA 64
soporte de cualquier SO con o sin aviso previo.
operativo
35
PORTUGUESE
ESPECIFICAÇÕES
LGA 775
Suporta as tecnologias Hyper-Threading / Execute
Processador Intel Core2Duo /Pentium
CPU Disable Bit / Enhanced Intel SpeedStep® / Intel
Dual-Core / Celeron Dual-Core / Celeron
Arquitecture -64 / Extended Memory 64 / Virtualization
4xx (Watt máximo: 95W)
Intel G31
Chipset
Intel ICH7
ITE 8712F
Iniciativas para controlo do ambiente
Proporciona as funcionalidades mais
Especificaçã Monitorização do hardware
utilizadas em termos da especificação
o Super I/O Controlador/Monitor da velocidade da ventoinha
Super I/O.
Função "Smart Guardian" da ITE
Interface LPC (Low Pin Count).
Placa
GMA 3100 Memória de vídeo máxima partilhada: 256 MB
gráfica
Suporte
definição
Ranhura PCI x1
Ranhuras
Ranhura PCI Express x16 x1
36
Conector de alimentação x1
(24 pinos)
Conector de alimentação x1
(4 pinos)
Teclado PS/2 x1
Tomada de áudio x3
Tamanho
170 mm (L) X 225 mm (A)
da placa
operativos Windows 2000 / XP / VISTA 32/ VISTA 64 suporte para qualquer sistema operativo com ou sem
37
POLISH
SPEC
Intel G31
Chipset
Intel ICH7
Gniazdo PCI x1
Gniazda
Gniazdo PCI Express x16 x1
38
Klawiatura PS/2 x1
Mysz PS/2 x1
Port USB x4
Gniazdo audio x3
Wymiary
170 mm (S) X 225 mm (W)
płyty
Obsluga
Biostar zastrzega sobie prawo dodawania lub
systemu
Windows 2000 / XP / VISTA 32/ VISTA 64 odwoływania obsługi dowolnego systemu
operacyjne
operacyjnego bez powiadomienia.
go
39
RUSSIAN
СПЕЦ
CPU LGA 775 Поддержка технологий Hyper-Threading / Execute
(центральн Процессор Intel Core2Duo /Pentium Disable Bit / Enhanced Intel SpeedStep® / Intel
ый Dual-Core / Celeron Dual-Core / Celeron Architecture-64 / Extended Memory 64 Technology /
процессор) 4xx (Максимальный ватт: 95W) технологии виртуализация
FSB 800 / 1066 / 1333 МГц
Набор Intel G31
микросхем Intel ICH7
Слоты DDR2 DIMM x 2 Модуль памяти с двухканальным режимом DDR2
Основная Каждый модуль DIMM поддерживает Поддержка DDR2 800/667
память 256 МБ / 512МБ / 1ГБ / 2ГБ DDR2 Не поддерживает зарегистрированные модули
Максимальная ёмкость памяти 4ГБ DIMM and ECC DIMM
Максимальная совместно используемая видео
Графика GMA 3100
память составляет 256 МБ
ITE 8712F
Инициативы по охране окружающей среды,
Обеспечивает наиболее используемые
Аппаратный монитор
действующие функциональные
Super I/O Регулятор скорости вентилятора/ монитор
возможности Super I/O.
Функция ITE "Smart Guardian" (Интеллектуальная
Интерфейс с низким количеством
защита)
выводов
Встроенное устройство управления Режим "хозяина" шины Ultra DMA 33 / 66 / 100
IDE
встроенными интерфейсами устройств Поддержка режима PIO 0~4,
Встроенное последовательное скорость передачи данных до 3.0 гигабит/с.
SATA
устройство управления ATA Соответствие спецификации SATA версия 2.0.
Локальная Автоматическое согласование 10 / 100 Мб/с
Realtek RTL 8102EL
сеть Частичная / полная дуплексная способность
Звуковая
поддержка Звуковая поддержка High-Definition
ALC662
жесткого 5.1канальный звуковой выход
диска
Слот PCI x1
Слоты
Слот PCI Express x16 x1
Встроенны Каждый разъём поддерживает 2 накопителя на
Разъём НГМД x1
й разъём гибких магнитных дисках
Разъём Порт подключения Каждый разъём поддерживает 1 Порт подключения
принтера x1 принтера
Последовательный порт
(опционно) x1
40
41
ARABIC
اﻟﻤﻮاﺻﻔﺎت
LGA 775
Hyper-Threading / Execute Disable Bit /ﺗﺪﻋﻢ ﺗﻘﻨﻴﺎت
Intel Core2Duo /Pentium Dual-Coreﻣﻌﺎﻟﺠﺎت
Enhanced Intel SpeedStep® / Intel Architecture-64 / وﺣﺪة اﻟﻤﻌﺎﻟﺠﺔ
/ Celeron Dual-Core /
Extended Memory 64 Technology / Virtualization اﻟﻤﺮآﺰیﺔ
ﺑﺘﺮدد یﺼﻞ إﻟﻰ Celeron 4xx
Technology
)و: 95ﻗﺼ ﻮى واط(
Intel G31
ﻣﺠﻤﻮﻋﺔ اﻟﺸﺮاﺋﺢ
Intel ICH7
ﻣﻴﺠﺎ ﺑﺎیﺖ256أﻗﺼﻰ ﺳﻌﺔ ﻟﺬاآﺮة اﻟﻔﻴﺪیﻮ اﻟﻤﺸﺘﺮآﺔ GMA 3100 ﺑﻄﺎﻗﺔ اﻟﺮﺳﻮﻣﺎت
42
یﺪﻋﻢ ﻣﺤﺮآﻴﻦ ﻟﻸﻗﺮاص اﻟﻤﺮﻥﺔ ﻋﺪد 1 ﻣﻨﻔﺬ ﻣﺤﺮك أﻗﺮاص ﻣﺮﻥﺔ
یﺪﻋﻢ ﺗﺠﻬﻴﺰات اﻟﻠﻮﺣﺔ اﻷﻣﺎﻣﻴﺔ ﻋﺪد 1 ﻣﻨﻔﺬ اﻟﻠﻮﺣﺔ اﻷﻣﺎﻣﻴﺔ اﻝﻤﻨﺎﻓﺬ ﻋﻠﻰ ﺳﻄﺢ
یﺪﻋﻢ وﻇﻴﻔﺔ اﻟﺼﻮت ﺑﺎﻟﻠﻮﺣﺔ اﻷﻣﺎﻣﻴﺔ ﻋﺪد 1 ﻣﻨﻔﺬ اﻟﺼﻮت اﻷﻣﺎﻣﻲ اﻝﻠﻮﺣﺔ
Smart Fanﻟﺘﻮﺹﻴﻞ اﻟﻄﺎﻗﺔ ﻟﻤﺮوﺣﺔ وﺣﺪة اﻟﻤﻌﺎﻟﺠﺔ ﻣﻊ وﻇﻴﻔﺔ ﻋﺪد 1 وﺹﻠﺔ ﻣﺮوﺣﺔ وﺣﺪة اﻟﻤﻌﺎﻟﺠﺔ اﻟﻤﺮآﺰیﺔ
43
JAPANESE
仕様
LGA 775
Hyper-Threading / Execute Disable Bit / Enhanced Intel
Intel Core2Duo / Pentium Dual-Core /
SpeedStep® / Intel Architecture-64 / Extended
CPU Celeron Dual-Core / Celeron 4xx
Memory 64 Technology / Virtualization Technologyをサ
processor
ポートします
(最高のワット: 95W)
Intel G31
チップセット
Intel ICH7
DDR2 DIMMスロット x 2
デュアル チャンネルモードDDR2メモリモジュール
各DIMMは 256MB / 512MB / 1GB / 2GB
メインメモリ DDR2 800/667をサポート
DDR2をサポート
登録済みDIMMとECC DIMMはサポートされません
最大メモリ容量4GB
グラフィック
GMA 3100 最大の共有ビデオメモリは256MBです
ス
低ピンカウントインターフェイス ITEの「スマートガーディアン」機能
最高3.0 Gb/秒のデータ転送速度
SATA 統合シリアルATAコントローラ
SATAバージョン2.0仕様に準拠。
10 / 100 Mb/秒のオートネゴシエーション
LAN Realtek RTL 8102EL
半/全二重機能
HDオーディ ハイデフィニションオーディオのサポート
ALC662
オのサポート 5.1 チャンネルオーディオアウト
44
PCIスロット x1
スロット
PCI Express x16スロット x1
フロッピーコネクタ x1 各コネクタは2つのフロッピードライブをサポートします
プリンタポートコネクタ x1 各コネクタは1つのプリンタポートをサポートします
シリアルポート (任意) x1
IDEコネクタ x1 各コネクタは2つのIDEデバイスをサポートします
SATAコネクタ x4 各コネクタは1つのSATAデバイスをサポートします
フロントパネルコネクタ x1 フロントパネル機能をサポートします
オンボードコ
フロントオーディオコネクタ x1 フロントパネルオーディオ機能をサポートします
ネクタ
CPUファンヘッダ x1 CPUファン電源装置(スマートファン機能を搭載)
CMOSクリアヘッダ x1
各コネクタは2つのフロントパネルUSBポートをサポートし
USBコネクタ x1
ます
電源コネクタ(24ピン) x1
電源コネクタ(4ピン) x1
PS/2キーボード x1
PS/2マウス x1
背面パネル VGAポート x1
I/O LANポート x1
USBポート x4
オーディオジャック x3
Biostarは事前のサポートなしにOSサポートを追加または削
OSサポート Windows 2000 / XP / VISTA 32/ VISTA 64
除する権利を留保します。
2008/10/22
45