You are on page 1of 6

����� �

������������������������������������

��������
����������
��������������������

����� ������������������������������

����������������
��������������������������������������������
������������������������������������������
����������������������������������������������
����������������������������������������������
The ORMAT® ENERGY CONVERTER (OEC) can be fuelled from the gas pipeline; is virtually
maintenance-free; can be located anywhere along the line to produce an optimum pipeline-to-soil potential;
and can be adjusted to produce increasing amounts of power to meet the changing cathodic protection
requirements resulting from changes in soil resistivity and pipeline surface exposure. The OEC is the most
flexible system available and the most cost effective.
Sentinels of the north are the 62 remote gate valves that protect the Trans-Alaska pipeline in case of
accidental damage. The valves are controlled from operation control center in Valdez. Power from
operation is provided by ORMAT® Energy Converters, fuelled by propane, which have accomplished over
30 years of continuous highly reliable operation.

����������� ����������
®
Thousands of ORMAT ENERGY CONVERTERS have been • Ultra-High Reliability
installed in 58 countries throughout the world since 1965 and • Virtually Maintenance-Free
have accumulated more than 200 million operating hours. • Twenty-Year Life
This field experience has demonstrated a 95% probability that the • No Overhauls Required
• Lowest Life Cycle Cost
mean time between failures (MTBF) for the ORMAT® Energy • Fuelled from Gas Pipeline
Converter fuelled by gas approaches 200,000 hours. With the • Fully Autonomous
supply of clean gas and proper annual preventive maintenance, • Better Pipeline Protecting
the OEC units can be expected to operate and have operated over • Reserve Power for Future
the full 30 year life without requiring emergency repairs. Requirements

������������������������������������������������������������������������
������������������������������
The most widely used method of cathodic As shown in Fig. 2, one section of a pipeline may
protection is by impressing an electrical current be anodic to another cathodic section of the
between the pipeline and an anode which is same pipeline and thus gives up metal ions via
buried in the ground near the pipeline to be the moist soil which acts like an electrolyte.
protected. The buried anode then is consumed Eventually, the anodic section will corrode as the
or corroded instead of the pipeline. This
metal ions are attracted to the cathodic section
impressed current protects the pipeline by
neutralizing the natural corrosion cycle which of the pipe.
occurs whenever two dissimilar metals are
placed in an electrolyte. (Fig. 1).

�������������� ��������������
OEC
GROUND LEVEL

GROUND LEVEL

PIPE (CATHODE)

PIPE

PROTECTIVE
CURRENT

ANODIC CATHODIC
ANODE AREA GALVANIC AREA
CURRENT

Fig. 1 Fig. 2

For satisfactory protection the pipeline-to-soil potential must be more negative then -0.85
volts when measured between the pipeline and an electrode placed above the pipeline.
Pipeline-to-soil potentials greater then -2 volts tend to cause separation of the coating from the
pipeline.

Ideally, the pipeline would have an evenly distributed pipeline-to-soil potential of between 1 to 2 volts;
however, this is not feasible since it would require an infinite number of power sources along the line.
The commonly accepted practice has been to use widely spaced power sources and provide some
overprotection in the immediate vicinity at the point of power application, while allowing the
pipeline-to-soil potential to decrease on either side of the location of the power source.

This often results in a protection curve with under protection at the extreme ends of the curve. The
condition deteriorates with time since larger amounts of current (requiring higher voltages) must be
impressed on the pipeline to compensate for increases in pipeline surface exposure caused by aging
of the coating. The net result is that the pipeline-to-soil potentials at the point of power application
often subject the coating to destructively high potentials.

Before the introduction of ORMAT® Energy Converters with their Cathodic Protection Voltage
Conversion Module (CPVCM), cathodic protection sites were often selected on the basis of
commercial power availability or access of the remote site to permit frequent preventive
maintenance and/or emergency repairs as required by continuously running and inherently
unreliable diesel generators.

�����������������������������������������������������������������������������������������������������
�������������������������������������������������������������������������������������������������������
���������������������������������������������������������������������������������������������������
�������������������������������������������������������������������������������������
������������������
The ORMAT® ENERGY CONVERTER (OEC), a Closed Cycle Vapor Turbogenerator (CCVT), is a fully
integrated and tested power system developed for remote applications. Basically a self-contained power
package - consisting of a combustion system, a vapor generator, a turboalternator, an air cooled
condenser, a rectifier, alarms and controls housed in a shelter - it will supply 200 to 4,000 Watts of filtered
DC power on a continuous 24 hour per day basis for periods up to 30 years with virtually no maintenance
or repairs.
The Ormat concept utilizes a hermetically sealed Rankine cycle generating set which contains only one
smoothly rotating part - the shaft on which the turbine wheel brushless alternator rotor and return feed
pump are mounted. The turboalternator shaft is supported by working fluid film bearings which eliminate
any metal-to-metal contact, resulting in years of trouble-free operation.
One of its most original features is that it can be run with different heat sources, since the fluid cycle is
closed and requires only the application of external heat; any heat source may be used: natural gas,
liquefied petroleum gas, kerosene, jet fuel, and diesel fuel.

����������������
The burner heats the organic
�������
liquid in the vapor generator -
some of it vaporizes and
expands through a turbine wheel
thereby producing shaft power to ���������
drive the alternator. The vapor
������
then passes imto a condenser ����� ����������
where it is cooled and is ������
condensed back into the liquid �����������
state where it is pumped back ������������
into vapor generator, cooling the ��������
alternator on its way, and �����
lubricating the bearings. The
cycle continues as long as heat
is applied to the vapor �������������� ����������
generator. Because the
��������
liquid/vapor stainless steel
envelope is sealed, none of the ����������� ���������
����������
organic fluid is lost in the
process. Furthermore, the working ���������������
fluid is totally immune to climatic ������������
conditions outside the sealed
envelope. ����������
���������
The turboalternator produces
three phase AC power which is �����
rectified and filtered.
�������������
The DC output is regulated in
accordance with varying load by ��������������
�������������
automatically controlling the
����������
amount of fuel supplied to the ���������
burner. ������������������
������������������� ����������
The CPVCM converts the fixed
output voltage of the OEC to an
adjustable voltage as required for ����������������� ����
�������
the specific cathodic protection �����������
�����
application. The system is
equipped with safety controls to ���������������
protect it against any
abnormalities including ������
overheating. Furthermore,
because of low ope-rating
pressures and temperatures,
personnel safety is assured.
����������������
������������������
��������������������
���� ������� ������� ���������� ��� ���� �������� ������
������� ������ ��� ��������� ���� ����� ����������� ���
������������� ������ �������� ���� ��� ���� ��������� ����������
������� ���� ������� ����� ��������� ��� ����� ���� ���������
� � � � � � � � �� ��������������������������������������������������
������������ ����������������������������������������������
�������� ������� �������� ���� ������� ����� ����
������������������������������������������������
���� ����������������� ������� ��������� ���
������ ������ ������ ����� �������� ������� ����
����� ������������� ����� ��� ����� ��� ��� ���
�������� ������� ���� ����� �� �������
������������������������������������������
����� �� �������� ������� �������� ����������
��������
���� ������� ������� ���������� ��� ����
����������������������������������������������
��������� ����������� ��� ���� ���������
����� ���� ����� ��������� ����������� ������� ������
����������������������������

��
����� �������
�����������
������������������
�����������������
�����������
�����������
��������
�������
��������
���������
����������
��������
��������
���������������
�����������
����������������������������������������
1975 1983-2005

��������������������������������������� ���������������������������������

�������������
������������� ������������������������������������������
���������������� ���������������������������������������������������������������������������������
����������������������������������������������������������������������������������������
�����������������������������������������������������������������������������

�������������������������������������������
�������������������������������������������������������������������������������������������
��������������������������������������������������������������������������
������������������������������������������������������������������
�������������������������������� ����������������������������������������������������������������������������������������������
������������������ ����������������������������������������������������������������������
�������������������������������
��������������� ���������������������������������������������
��������������������������������������������

1987 1976

����������������������� �����������������������������

���������������������������������������
�����


���������������������������������������������������������������������������������������������
�������������������������������������������������������������������������������������������������������������������

You might also like