‘
000%%)| INSERT INPUT/OUTPUT PINS TO
ASTE! REFLOW JIG
Training Module No.: TM-A40_ Effectivity Date : August 10, 1998
Revision No.: 00 Page 1 of 2
SUMMARY
Section TOPIC MENTOR. TIME
1__[ Insert input / Output Pins to Reflow Ji Process Engineer_| 15 min.
896. DAG,
imas TER ‘cory!
Prepared By rif a Penta Approved By : t MicuaOK INSERT INPUT/OUTPUT PINS TO
ASTEC REFLOW JIG
‘Training Module No.: TM-A40 Effectivity Date : August 10, 1998
Revision No.: 00 Page 2 of2
PROCESS : INSERT INPUT/OUTPUT PINS TO REFLOW JIG
LINE: AMR ASSEMBLY
‘TOOLS/EQUIPMENT NEEDED:
4.0 Reflow jig
2.0 Tweezer
3.0 Slide conveyor
PROCEDURE:
1.0 Double check first the part number of the pins to be used. It should be the same
with the part number specified on the visual aid. Otherwise, inform immediately line leader
or Supervisor of the discrepancy.
2.0 Insert 1/0 pins to the reflow jig pin holes. The pins should slide freely into the hole.
3.0 Place reflow jig on the slide conveyor.
Figure 1. Input/output pins inserted on the reflow ji.
CHECKPOINTS:
1.0 Pins should be inserted freely on the reflow jig. Otherwise, it is considered bent and must be
replaced with a new one. Segregate bent pins by placing it a container labeled with * bent
pins’
SAFETY:
1.0 Always wear your groundstrap and lint free gloves
HOUSEKEEPING:
1.0 Always clean and arrange work area before and after working.
Prepared By rnagliro Approved By nae ua