Professional Documents
Culture Documents
IPECS EMG80 Quick Start Guide 2
IPECS EMG80 Quick Start Guide 2
iPECS eMG80
Install wizard
IP connection to the eMG80
• Configure system parameters through the LAN port of the KSU
Install wizard
Step 1
• Enter default web admin ID(admin) and Password (1234)
Default web admin ID (admin) and Password (1234)
Install wizard
Step 2
• Set nation code
To change the NATION Code on eMG80:
1. Set the KSU MPB SW1 Dip Switch Pole 2 to the On position,
2. Enter the NATION code
3. Press the reset button on the KSU, power the system Off and On
4. After initialization, move Dip-switch 1 pole 2 to the OFF position
Install wizard
Step 3
• Set system (MPB) IP address
Install wizard
Step 4
• Set Station number
Install wizard
Step 5
• Set numbering plan for CO access, attendant call, pickup, hunt group
! Access CO in first CO Group : Dial code to access the 1st available CO Line in any accessible group.
! Attendant Call : Dial code to call an Attendant.
! Group Call Pick-Up : Dial code to activate Group Call Pick-up.
! Station Group Pilot number : Assign the pilot number on each Station Group eg 620 – 659
NOTE: This will conflict with Camp On code 621 in PGM 106, so change the Camp on feature code
Install wizard
Step 6
• Set ring assignment
101 107
0
Install wizard
Step 7
• Set web admin ID and password default ID/Password should not be used
- Up to 50 users ID and password can be registered.
- Up to 10 users can login to a system simultaneously.
Press Save to store the entered information.
Install wizard
Step 8
• Enter system admin using saved ID and password in step 7
Multi language
Support dual language (English and Local)
When logging to the iPECS eMG80 the web admin language may be in Korean
To change the web admin language
Log into the iPECS eMG80
Click on change Language tab on the right hand side, then select English