Professional Documents
Culture Documents
Sikasil® Auto
Multipurpose automotive adhesive sealant
Sikasil Auto 1 / 2
®
Cure Mechanism Removal
®
Sikasil Auto cures by reaction Uncured, excess Sikasil® Auto may Legal Notes
with atmospheric moisture. The be removed with Sika® Remover- The information, and, in particular, the
reaction thus starts at the surface 208 or another suitable solvent. recommendations relating to the appli-
and proceeds to the core of the Cured sealant can only be trimmed cation and end-use of Sika products,
away or scraped off mechanically. are given in good faith based on Sika's
joint. The curing speed depends on
Hands and exposed skin should be current knowledge and experience of
the relative humidity and the ® the products when properly stored,
temperature. At low temperatures washed immediately using Sika handled and applied under normal
the water content of the air is lower Handclean towels or a suitable conditions in accordance with Sika's
and the curing reaction proceeds industrial hand cleaner and water. recommendations. In practice, the
more slowly. Do not use solvents! differences in materials, substrates and
actual site conditions are such that no
Overpainting warranty in respect of merchantability
Application Limits Sikasil® Auto cannot be or of fitness for a particular purpose,
®
Sikasil Auto is not recommended overpainted. If a similar but nor any liability arising out of any legal
for use on pre-stressed overpaintable product is required, relationship whatsoever, can be in-
polycarbonate or other plastic ®
consider using Sikaflex -Auto+. ferred either from this information, or
surfaces that are prone to stress from any written recommendations, or
cracking. Further Information from any other advice offered. The user
The above information is offered of the product must test the product’s
Copies of the following publications suitability for the intended application
for general guidance only. Advice are available on request: and purpose. Sika reserves the right to
on specific applications will be - Safety Data Sheet change the properties of its products.
given on request. The proprietary rights of third parties
must be observed. All orders are ac-
Packaging Information
Method of Application cepted subject to our current terms of
Tube 75 g sale and delivery. Users must always
Surface preparation
refer to the most recent issue of the
Surfaces must be clean, dry and local Product Data Sheet for the pro-
free from oil, grease and dust. Value Bases
duct concerned, copies of which will be
Sika® Remover-208 or another All technical data stated in this
supplied on request.
suitable solvent may be used for Product Data Sheet are based on
cleaning. laboratory tests. Actual measured
data may vary due to
Application circumstances beyond our control.
To minimise smearing of surfaces
with excess sealant, masking tape Health and Safety Information
can first be applied to surrounding For information and advice
surfaces. regarding transportation, handling,
Cut the nozzle to the desired bead storage and disposal of chemical
size then apply a continuous bead products, users shall refer to the
as required. For bonding, apply actual Safety Data Sheets
bead to only one surface. For containing physical, ecological,
sealing, push the sealant into the toxicological and other safety-
joint as it is being applied to ensure related data.
good wet out onto the surface.
Assemble parts and/or tool off any
excess sealant before it skins over
then immediately remove any
masking tape.
For more information, please
contact the Technical Service
Department of Sika Industry.
Sikasil Auto 2 / 2
®