Professional Documents
Culture Documents
Viledon Plug-On Gasket: Installation Instruction
Viledon Plug-On Gasket: Installation Instruction
02-IA-180-October-2015-EN
The gasket is kept in place by the clamping effect of the rubber lips,
adhesive or special fixing agents are not required.
®
The Viledon plug-on gasket is weatherproof and thermally stable within
a range from approx. - 40°C to + 100°C and also extremely long-lasting.
Chemically stable against alcohols, lyes and weak acids. Not stable
against concentrated acids, chlorocarbons, aromatic hydrocarbons, oil
and fuel.
Highly flexible – silicone-free.
Installation instruction
Replaces all previous issues of this data sheet. Viledon® is a registered and protected trademark of Carl Freudenberg KG.
Begin assembly in the middle of one side – not in a corner! Form the corners
completely and
Fit the gasket onto the mounting frame with the hollow compartment press firmly.
facing inwards.
Form the corners completely, without overstretching the gasket.
Continue fitting the gasket until you reach the starting point.
Check the correct position of the gasket before cutting to length.
Cut the gasket to length with a right-angled cut, leaving an over length
of
approx. 5 mm, and join the two ends together.