Chassis Electrical
TOYOTA seh0s
August 31, 2011
Clamp Release Interlock
(Standard Lever Units)
SERVICE INFORMATION BULLETIN a TOUTS SS, BrOLeIUTS 32,
7FGCU35-70 and 7FGU35-80
‘Subject: Clamp Release Interlock (Standard Lever Units) Page 1 of 4
MODEL APPLICATION:
7FBEU15-20, 7FBEHU18, 8FBCU20-32, 8FBCHU25, 7FBCU15-55
8FGCU15-32, 8FGU15-32, 7FGCU35-70 and 7FGU35-80
GENERAL INFORMATION:
Starting with October 2010, new units with standard hydraulic levers may be equipped with a Clamp
Release Interlock Circuit. ANSI 856.1 states that all units with clamp attachment or roll attachments
must have a 2nd release method (2 moves to open the attachment) to prevent accidental opening
Please refer to product bulletins 19-10 and 24-10.
Toyota Designed Circuit for ANSI B56.1
CRI
SWITCH
=
Y
3A
Ap
SOLENOID
VALVE(Subject: Clamp Release Interlock (Standard Lever Units)
Page 2 of 4
Switch and Wiring Installation
Clamp release switch
Wire routing through boot and lever
connects to relay circuit.
Switch assembly and wiring as routed
by the factory.‘Subject: Clamp Release Interlock (Standard Lever Units) Page 3 of 4
Solenoid and Hydraulic Hose Connections
Hose Connection at Oil Control Valve |— | Hose to Attachment Spacer Plate
_-4 Specific).
Solenoids 12, 36 and
48 volts (Voltage
Hose from
valve
Fitting‘Subject: Clamp Release Interlock (Standard Lever Units) Page 4 of 4
Power and Ground Wire Connections
CONNECT A WIRE(+) TO Pat
CONNECT W WIRE(-)TO Ni
UNDER CONTACTOR PANEL