Professional Documents
Culture Documents
Create A 3D Printed Arm Cast
Create A 3D Printed Arm Cast
Florian
Bommier
Content 01 Create surfaces from organic shapes
4
choose
part .PAR file
5
Run the
geometry
inspector
6
Manual identify
region
7
Tips: draw only
the edge of the
area
8
select BSpline
choose the tol according to
scan quality
select multiple
areas by holding
Ctrl
9
10
Use contour to draw curves on
a designated surface
11
select first the surface. draw
the curve as a loop
12
13
choose Trim to
cut the surface
with the curve
14
select the
surface, then
the curve
15
select the
outside surface
to delete it
16
use offset to create a parallel surface,
away from the mesh.
input the offset distance
17
02
/surfaces & solids/
Use Thicken to
create a solid from a
random surface
19
Define the thickness
20
Use contour to draw curves on
a designated surface
21
select the edge surface
22
Draw a curve
point by point
23
24
draw the oposit curves
on every edges
25
Use BluSurf to create a
surface loft
26
select 2nd curve
select 1st curve make sure to don't
twist the surface
27
28
Edit the surfaces
with Extend
29
30
Use Thicken to
create a solid from a
random surface
31
32
in Sycn. select
surfaces to delete
33
03
/Edit Solids with
Sychronous design/
Visually create the
middle plane
35
Use View Clip to
display a section
36
Design the elements
on the middle plane
37
Extrude from the
sketch
38
Use CAD tool to
change the design
39
Create a tool that
separate the solid in 2
parts
40
With surface stiched
create a single
surface to be the tool
41
Split to cut the solid
with the tool
42
Selecct the solid, the
tool and keep both
sides
43
Vo i l à !