Professional Documents
Culture Documents
Photovoltaic Energy Future of The Industrial Development
Photovoltaic Energy Future of The Industrial Development
Abstract
Due to the importance and the high level of consumption of energy due to the
world technology evolution, the promotion of renewable energy is one of the
priorities in the actual industries. In The present paper the authors demonstrate
attempts to demonstrate that photovoltaics could be the future of the industrial
development of the African Continent. The photovoltaic effect of certain
semiconducting materials promotes the production of electrical power, the
exhaustible energy resources generate environmental problems inherent in
their modes of operation. Africa, enjoying virtually its entire continental very
good coefficient of sunshine, its industrial development can be effective by
controlling production of photovoltaic techniques.
Introduction
As the importance of energy consumption increase in a rate, conventional source of
energy tend to decrease in a very high rate due to the fact that the consumption of the
resources is very high than the synthesis of the considered fuel.so the main solution
found to this is to switch to non-conventional energy resources. In its main objective
the present paper as an objective to give light to different searcher around the world
about the about the high potentiality of the African continent for the solar energy
generation. The intention is not to make a very large masterful communication, very
high scientific and academic significance but rather to arouse curiosity researchers
deepen within the subject to make available the technical information makers that can
98 François Ntambwe Kadinda
allow them to remain very attentive to the evolution and development of photovoltaics
in Africa particularly and the world in general.
Indeed, there exists at the level of education, I would say at the laboratory level, a
very large project called "Desertec" by the Union for the Mediterranean (UfM) which
provides for the construction of huge solar thermal power plants in the Sahara .
This ambitious project plans for a 100 GW solar energy production for the year
2050, in the following objectives:
To supply much of the SUB-SAHARAN AFRICA,
To import part of this "clean electricity" in Europe,
To achieve very significant reduction targets in greenhouse gas emissions set
by the European Union.
It remains to be seen whether the relatively long distance will not stop the
voracious appetite of Europeans investors in renewable energies.
Note that since the late 19th century, in general, the energy consumption has
become increasingly important and only increase if an exponential evolution. This
consumption is dictated by the ever increasing need for development because energy
is essentially a human development factor of the generator.
So the energy resources used may be conventional resources (non-renewable) or
non-conventional resources (renewable) and can be:
Exhaustible if the refresh rate is lower than that of consumption,
Non exhaustible in the opposite case.
Exhaustible resources are mainly fossil fuels, derived from, Carbon products (peat,
lignite, coal, anthracite, petroleum and natural gas) or nuclear fission (uranium).
Among renewable resources include primarily: hydropower, solar energy, biomass
energy, wind energy, geothermal energy and tidal energy.
Exhaustible resources inevitably generate environmental problems whereas
renewable resources are said to own because their operation does not create any
ecological or environmental problem.
Among the clean energy, solar power brings hope for the development of the
African continent because it is the only continent relatively very well covered by the
sun as shown in the world map of sunshine hours per day.
The situation of excessive cost is comparable to that of mobile phones in the late
1980s because at that time, the cell phone which had seen the day was inaccessible to
the vast majority of the population, except for some wealthy people could acquire it.
Within 5 to 10 years later, he has become accessible by virtually all segments of the
population. Today, even relatively poor people in developing countries know how to
get dirt cheap mobile phone.
We could therefore predict that in a decade, two decades at most, photovoltaics
could see a great expansion. This assertion is supported by the DESERTEC project
which we referred above. It may, in addition, hope to drastically reduce the excessive
cost of photovoltaic equipment by supporting locally manufacture certain components
such as the photovoltaic module itself bearing quartz. As we have reported, we will
present the state of consumption and the evolution of the use of energy in several
African countries.
Photovoltaic Energy: Future of The Industrial Development of The African et. al. 99
Table 1: Annual energy consumption per person in the world and Continent
consumption rate compared to the world consumption
of debt that they cannot decently consider foreign funding because they could not
repay their loans. Photovoltaic energy could be one of the best tracks to be exploited
for electricity generation in a continent where in rural areas, only one in ten has a
connection to the electricity network if network there, which is far be the case
everywhere ...
The equipment photovoltaic panels could be very beneficial one hand to supply the
majority of photovoltaic remote populations who have no access to anything, and
secondly, to develop the industrial sector, in the case of the majority of African
countries, there have been no significant progress since the massive independence to
the 1960s in some cases a relatively large delay in development is growing.
E. Global Context
Since the 1990s, photovoltaic energy has experienced very strong growth due to the
willingness of some states of the developed countries to take into account the
106 François Ntambwe Kadinda
A photovoltaic dynamic is now, for already almost fifteen years to see more, to
create all over the world. The enthusiasm and commitment of some governments,
technological maturity and lower production costs that are generally associated with
108 François Ntambwe Kadinda
the development of an activity, suggests that more and more countries will prefer the
photovoltaic solution.
Conclusion
Due to the fast depletion of fossil fuel in the world due to the high rate of use, the
actual industrial searchers tend to maximise and optimise the use of renewable energy
in the world.
As in its objective, the present paper shows the potential of solar energy in Africa,
for an industrial use as seen that 47% of the continent AFRICAN receives sunshine
than 2100 kWh / m2 while the rest of the world harvest that from 1500 to 1900 kWh /
m2. As seen in the fig 1 we can observe the intensity gradient of the solar shine in the
world and observe that the average sunlight period in hour is maximum in the zone of
Sahara and Kalahari deserts.
We can conclude that the African continent is very attractivefor the solar energy
extraction, so with an average of 6 hours per days the extraction can go at amaximum
value of 12600 kw /m2 for theSahara and the Kalahari desertsareas. But as per the
question asked, in the title the research remain open and need to be pushed on the
attractive region for different searchers in the world.
References
[1] B. Khan, Non conventional energy ressources, New Delhi: Tata Mc
GRAW Hill, 2009.
[2] F. B. ,. B. A. ZERGA, Optimisation du rendement d une cellule solaire NP
au silicium monochristalin, 1998.
[3] D. U. SAUER, Electrochemical storage for photovoltaics, Freiburg
Germany: Fraunhofer Institut for solar energy systems ISE, 2004.
[4] R. MUKUND, Wind and solar Power system, New York: CRC Press LLC,
1999.
[5] A. Sarr, Simulation du systeme Hybrides photovoltaique, canada: PDH
Thesis, 1998.
[6] M. D.TURCOTTE, Photovoltaic hybrid system siing and simulation tools,
Canada: PV HORIZON, 2001.
[7] Z. A, “Optimisation du rendement d une cellule Solaire NP au silicium
monochristalin,” in Physique energetique, 1998, pp. 95-100.