Professional Documents
Culture Documents
Total duration: 150 hours (Technical instruction) 30 hours per week covering 5 weeks
Times to Provision for the following are not listed in this document.
Course objectives and TNA definition: For the student to understand and demonstrate the level of engineering knowledge that may allow the engineer
to service, trouble shoot, rectify, replace components, and test, using the correct tooling and manual procedures and enable the student to release the
aircraft to service under his/her Part 66 license category Safely and without accident or incident in accordance with Part 66 and manual procedures. A
weekly examination will be held as detailed in this syllabus and the student achievement mark is 75% and above for each weekly stage.
1) Front cover
2) TNA weekly plan
3) Schedule of training, subparts and levels
This TNA provides hours for classroom instruction only. Each hour listed, represents 1 complete hour of instruction.
This TNA will become part of the course records held in each course folder as listed in AMET MTOE sections 1.9, 2.1, 2.2, 2.5, 2.7, 2.9, and 2.15.
Minimum Pre requisites for training under this TNA will be: A recognised Aeronautical degree, an approved apprenticeship or Category A license.
Page 1 of 23
22/12/2021
TNA Code B736C-1
DAY WEEK1 WEEK2 WEEK3 WEEK4 WEEK5
Page 2 of 23
22/12/2021
TNA Code B736C-1
1 am Introduction (1) = 2HRS Water and Waste (3) Power plant General (2) Airframe Pneumatics(2) Hydraulic power (4)
Aircraft structures & Air Conditioning General
Zone identification (2) FADEC (1) (1)
pm Ice and Rain protection (3) Engine Oil systems (3) Air conditioning (3)
Associated Manuals (3) Flight controls General (2)
2 am Indicating General (1) Windows (2) Engine Fuel & Control (4) Air conditioning (6) Electrical/Fly by Wire (2)
Indicating / recording &
Maintenance sys (5) Fire Detection (4) Flight Controls (4)
pm
Engine controls (2)
3 am Recording and Onboard Fuel (4) Engine Air (4) Pressurisation (2) Flights Controls (6)
Maintenance systems (2)
Integrated Modular system Landing Gear (4)
pm Fault reporting (2)
Oxygen (2) Engine AC Electrics (2)
Electrical Power General (2)
4 am Electrical power AC (6) Navigation (6) Engine Indicating (3) Landing Gear (6) Auto flight (6)
pm Engine Ignition (1)
Engine starting (1)
Engine exhaust Intro (1)
5 am Electrical power DC (2) Doors (4) Engine Exhaust (2) APU (6) Auto flight (3)
Equipment & Furnishings (1) Engine Pneumatic (3)
pm Electronic Emergency EQ(1) Information systems (2) Engine Fire Detection (1) Comms systems (2)
Lights (2)
Review / Phase Test Review / Phase test Review / Phase Test Review / Phase test Review/ END Phase test
REV – 01
01-08-11 Form 49
Schedule of training:
Page 3 of 23
22/12/2021
TNA Code B736C-1
SUBPART DESCRIPTION. LEVEL. ATA CHAPTER.
Airplane General 2 05
Servicing 1 12
Fuselage 3 53
Nacelles / Pylons 3 54
Page 4 of 23
22/12/2021
TNA Code B736C-1
Stabilisers 3 55
Windows 3 56
Wings 3 57
MM, IPC, SRM, WDM, FIM, MPD, MEL (SFAR 88) 1 00-00
MMEL 3 31-01
Clocks 2 31-25
Accelerometers 2 31-31
Page 5 of 23
22/12/2021
TNA Code B736C-1
TO / Landing Warning Systems 2 31-61
Page 6 of 23
22/12/2021
TNA Code B736C-1
External Power 3 24-41
Batteries 3 24-31
SPCU 3 24-30
Galleys 3 25-31
Page 7 of 23
22/12/2021
TNA Code B736C-1
ATA 25 Electronic emergency equipment (1 hr)
Page 8 of 23
22/12/2021
TNA Code B736C-1
QTY and pressurisation 3 38-10
Probes 3 30-30
Page 9 of 23
22/12/2021
TNA Code B736C-1
ATA 56 Windows (2 hrs)
Page 10 of 23
22/12/2021
TNA Code B736C-1
Pressure refuelling / De fuelling 3 28-21
ILS 2 34-31
SUBPART DESCRIPTION. LEVEL. ATA CHAPTER.
Page 11 of 23
22/12/2021
TNA Code B736C-1
Radio Altimeter 2 34-33
LRU replacements 2 23
Page 12 of 23
22/12/2021
TNA Code B736C-1
Display unit 2 46-11
Antenna’s 1 46-11
Page 13 of 23
22/12/2021
TNA Code B736C-1
Cooling and breathing 3 79-21
Page 14 of 23
22/12/2021
TNA Code B736C-1
Accessory cooling 3 75-20
Analysers 3 77-30
Page 15 of 23
22/12/2021
TNA Code B736C-1
Standby engine indication 3 77-41
Page 16 of 23
22/12/2021
TNA Code B736C-1
ATA 26 Engine and strut fire detection (1 hr)
Distribution 3 36-10
Page 17 of 23
22/12/2021
TNA Code B736C-1
Auto / Manual / Standby / Low-Hi flow inhibit 3 21-55
Page 18 of 23
22/12/2021
TNA Code B736C-1
Nose landing gear 3 32-20
Page 19 of 23
22/12/2021
TNA Code B736C-1
APU engine and accessories 3 49-21
Page 20 of 23
22/12/2021
TNA Code B736C-1
Fluid Temperature indication 3 29-32
Page 21 of 23
22/12/2021
TNA Code B736C-1
Flap systems 3 27-51
Page 22 of 23
22/12/2021
TNA Code B736C-1
Rudder position indicating 3 27-28
Page 23 of 23
22/12/2021