1-242 _ Engine Control System (6WF1)
‘Sep ‘ation Valve(s) Yes No.
Inspect the engine coolant temperature sensor.
Refer to DTC P0023 to inspect the pats, and repair
5 | orteplace the affected parts where faults are found. =
was the action compte? Goto Step 6 =
‘Check the operation of injector
4. Connect the scan too
2. Start the engine.
3. Using the scan tool, perform test on the
injector.
+f the fuel injection from the injector is
inuifcien (stopped)
Use the “Each injector inaction stop” test
A to stop the injector in each cylinder one
by one. Itis normal for the engine sound
to change when a cylinders stopped
+ there is too much fuel injected from the
Injoctor
Use the "Each injector injection stop” test
to stop the injector in each cylinder one
by one. Its normal for the engine sound
to change when a cylinder is stopped.
[Are the injectors operating normally? Goto Step 8 Goto Step7
1. Replace the faulty injectors.
IMPORTANT:
7. | After replacing the injector, camry out programming -
for the injector 1 code.
Was the action complete? Goto Step 8 =
"Adjust the idling revolutions one more time
Was idling revolutions adjusted? Goto Step 11 Goto Step 9
1. Replace the ECM.
IMPORTANT:
‘After replacing the ECM, camy out the
9 | programming for the following items. -
+ Qadjusiment data
+ Injector 10 code
Was the action complete? Goto Step 10
‘Adjust the idling revolutions one more time
Was ling revolutions acjusted” Goto Step 11 Goto Step2
‘After repairing the vehicle, verify the repairs.
Was the action compte? Verity rep