Professional Documents
Culture Documents
-03
1. Brief Back ground :-
Safety Valve is a one type of valve that automatically actuates when the pressure
of inlet side of the valve increases to a predetermined pressure, to open the valve and
discharge the fluid (steam or gas). We have taken up this design based on the earlier
hydraulically (by using steam or gas). The basic spring loaded safety valve has been
developed to meet the need for a simple, reliable, system actuated device to provide
overpressure protection.
The advantages of Ball valve are,
Good lifetime also of wear parts
Most reliable type if properly sized and operated
Versatile — can be used in many services
High efficiency
Maintenance friendly design….. Etc.
2. Main work objective:-
The main objective of the full lift safety valve is when the pressure or temperature
exceeds preset limits it will open. The spring pressure, once set, is fixed and sealed by
a Surveyor. When the steam exceeds this pressure the valve is opened and the spring
compressed. By using this method the cost will be very high and also laborious
maintenance. To overcome this method, we were introduced full lift safety valve so as
to run the equipment safely even at elevated condition.
3. Design Model :-Design of valve and its component .
4. Analysis of full lift safety valve.i.e
Stress,strain and displacement of tip and shaft.
Impact of shaft on valve housing and spool.
Skill Sets: Design & Analysis of the model by using various software