Engine Control System (6WF1) 14-217
‘Sep ‘ation Valve(s) Yes No.
Use the scan tool to inspect EGR magnetic valve +
operation.
1. Connect the scan tool
2. Tum the starter switch ON. At this time, the
‘engine does nol start
3. Operate the scan tool and clear the DTC.
® | 4. Remove the air pine from the EGR valve and ~
air oyinder.
5. Use the scan tool to perform an actuator test
to check magnetic valve operation. (Refer to
“Breakdown Diagnosis using the scan too")
Is EGR magnetic valve 1 working normally? Goto Step 10 Goto Step 9
1. Replace the ECM.
IMPORTANT:
‘Aft replacing the ECM, perform the folowing
9 | tems of programming -
+ Qadjustment data
+ Injector 1D code
Is the action complete? Goto Step 10 =
Recheck the DTC,
4. Connect all hamesses,
2. Clear the DTC.
3. Tum the starter switch OFF, wait for mare than
uJ 418 seconds, then tum the switch ON and start -
the engin.
4. Check the DTC.
Was DTC P0441 detected? Goto Step 3 Goto Step 11
‘Use the scan tool 10 check @ other DTC are
11 | detected. _
Goto appiicabie
‘Are other DTCs detected? ore Very repair
EGR magnetic valve