Professional Documents
Culture Documents
Equation of length of belts
2) Steel is forged at _ temperature
3) Distribution of Force moment of inertia in crank
4) If a cycle between T1 and at T2 rejects heat at T2 and supplies it to another cycle which
rejects at T3, if the efficiency of both cycles is equal, the relationship between T1, T2, T3 is;
5) Centrifugal Velocity of a belt with w as weight density is:
6) If flowrate through a pump is halved, the specific speed becomes:
7) For Electrical Resistance welding, the voltage and temperature should be (high, low ki
options thi)
8) For Mohr Circle's centre to be (0,0), which of the following is true
9) Draft way is not used in ? (turbines di hui thi kuch)
10) In a rigid tank in vaccum, if air is supplied to it at constant pressure, the temperature
(increases, decreases, remains same etc)
11) Enthalpy after Evaporator is 195 kJ/kg and 65 kJ/kg Condenser, what is the specific
refrigeration.
12) Slenderness ratio is the length divided by:
13) Engine knock in diesel engines can be reduced by:
14) If Cuttoff ratio in CI engines is increased, what happens?
15) Absolute Velocity nikalni thi, simple sa tha
16) Temperature Distribution aur diffusivity given thi, rate of Transfer nikalna tha, sai yaad
ni hai
17) Fins are most efficient for: (Thin fins closely spaced)
18) Permeability in sand casting is higher in which kind of sand
19) As radius of insulation is increased, what happens to conduction and convection
coefficients
20) there a two shafts, one is solid, one is hollow. hollow shaft will have how much more
strength
21) Gear train assembly, ratio of angular speed nikalni thi, asaan sa tha
22) Aik aur gear wala sawal tha simple sa
23) Percentage elongation represents which material property?
24) Which of the following has highest Poisson ratio?
25) Temperature of a bar with thermal conductivity 10^‑5 is increased by 250 C, the stresses
produced are (E=200GPa) :
26) Maximum allowable pressure in a cylinder of 1.5 m dia and 45MPa allowable stress
27) If maximum stress is produced by torque T, the Torque upto safe limits according to
maximum principal stress theory is_
28) If radius of a sphere is increased by 1% and thickness is reduced by 1%, the percentage
change in stresses is
29) Which link should be grounded to get double crank (200,300,400,350) mm
30) Ratio of loss head of a pipe to a pipe double its diameter is:
31) Statics ka aik sawal tha simple force balance lagana tha
32) Coefficient of friction nikalna tha, simple force balance se
33) If x(t) = 3cos(0.25pi(t)), amplitude is achieved at what time?
34) Plane wall has emissivity 0.7, it is to be reduced by 75% by adding emmisive surfaces at
the end, how many surfaces should be added?
35) Turbine inlet and outlet enthalpies are 2800 kJ/kg and 1800 kJ/kg, the power in kg/kW‑
hr is?