Professional Documents
Culture Documents
Service 200P7ES/00
Service 200P7EG/00
200P7EB/00
Service 200P7EB/27
200P7EB/75
200P7EB/93
200P7MG/00
Horizontal frequencies
30-98KHz
TABLE OF CONTENTS
SAFETY NOTICE
ANY PERSON ATTEMPTING TO SERVICE THIS CHASSIS MUST FAMILIARIZE HIMSELF WITH THE CHASSIS
AND BE AWARE OF THE NECESSARY SAFETY PRECAUTIONS TO BE USED WHEN SERVICING ELECTRONIC
EQUIPMENT CONTAINING HIGH VOLTAGES.
CAUTION: USE A SEPARATE ISOLATION TRANSFORMER FOR THIS UNIT WHEN SERVICING.
Published by BCU Monitors Printed in Suzhou Copyright reserved Subject to modification F Jun. 08 2006 GB 3138 106 10500
WARNING
FOR PRODUCTS CONTAINING LASER :
Critical components having special safety
characteristics are identified with a by the Ref. No. DANGER- Invisible laser radiation when open.
in the parts list and enclosed within a broken line* AVOID DIRECT EXPOSURE TO BEAM.
(where several critical components are grouped in one
area) along with the safety symbol on the CAUTION- Use of controls or adjustments or
schematics or exploded views. performance of procedures other than
those specified herein may result in
Use of substitute replacement parts which do not have hazardous radiation exposure.
the same specified safety characteristics may create
shock, fire, or other hazards. CAUTION- The use of optical instruments with this
product will increase eye hazard.
Under no circumstances should the original design be
modified or altered without written permission from
Philips. Philips assumes no liability, express or implied,
arising out of any unauthorized modification of design.
Servicer assumes all liability.
* Broken Line
ELECTRICAL SPECIFICATION The input signals can be applied in two different modes :
1. General 1).VESA Analog
1.1. Product description Input signal : Video, Hsync., Vsync
The Hudson7 20.1" TFT flat panel monitor is specified as a Video : 0.7 Vp-p, input impedance, 75 ohm @DC
display peripheral with Analog video signal input, Digital video
Sync. : Separate sync TTL level , input impedance 5k ohms
input ,input 20.1" TFT LCD display.
Horizontal scan range is 30 - 98 K Hz and refresh range is Hor. sync Positive/Negative
56 - 85 Hz. This scan range allows it to display resolution up to Ver. sync Positive/Negative
1600*1200 non-interlaced at75 Hz refresh rate. The image can 2). Input DVI Digital
be adjust through OSD control, these adjustments can be stored
Input signal : Four channel TMDS signals
on an board memory including 34 preset modes
and 13 factory preset modes. 1.3.6 Input connectors (1) Input analog D-sub connector pin assignment
All optical characteristics (including WHITE-D, Brightness, and so PIN No. SIGNAL
on) are determined according to panel specification after warming
up approximate 30 minutes that brightness stability is optimal, and 1 Red
follow strictly after panel specification. 2 Green/ SOG
3 Blue
1.2 Destination : US*.CA*. Z9
1.3. Basic data 4 Sense (GND)
1.3.1 LCD panel : LPL 5 Cable detect (GND)
Type NR. : LM201U04 (LG.PHILIPS)
6 Red GND
Outside dimensions : 432.0(w)*331.5(h)*25(d) (Typ) mm
Pitch ( mm ) : 0.255 (per one triad) x 0.-255mm 7 Green GND
Color pixel arrangement : RGB vertical stripes 8 Blue GND
Display surface : low reflection, antiglare with hard coating
Color depth : 16777216 colors (8 bits) 9 DDC +5V
Backlight : Six CCFL' s 10 GND
Active area(WxH) : 408x306mm (20.1 " diagonal) 11 Sense (GND)
View angle : Horizontal & Vertical 178 degree (Typ)
Contrast ratio : 700:1 (Typ) ; 400:1 (Min) 12 Bi-directional data
White luminance: Panel original color >250nits (min), 300 nits (Typ.) 13 H/H+V sync
14 V-sync
LCD panel : AUO
Type NR. : M201UN02 (AUO) 15 Data clock
Outside dimensions : 432.0(w)*331.4(h)*23.1(d) (Typ) mm
(2) Input DVI-I connector pin assignment
Pitch ( mm ) : 0.255 (per one triad) x 0.-255mm
Note the mark " * " for DVI-I to Dsub only
Color pixel arrangement : RGB vertical stripes
Display surface : low reflection, antiglare with hard coating
Color depth : 16777216 colors (8 bits)
Backlight : Six CCFL' s
Active area(WxH) : 408x306mm (20.1 " diagonal)
View angle : Horizontal & Vertical 170 degree (Typ)
Contrast ratio : 700:1 (Typ) ; 400:1 (Min)
White luminance: Panel original color >200nits (min), 250 nits (Typ.)
1.3.2. Power supply Pin No. Description
Main voltage : AC 90 - 135 Vrms and 170 - 264 Vrms, 50/60±2 Hz 1 TMDS data2-
Power cord length : 1.8M
2 TMDS data2+
Power cord type : 3 lead with earth plug
Power indicator : LED (ON: blue, Standby: amber, NEW MODE: 3 TMDS data2 shield
flashing blue twice per second before user adjust and save it.). 4 NC
Auto power saving : EPA, Nutek, VESA DPMS
5 NC
Mode HSYNC VSYNC Video Pwr-cons. Indication Rec. time
6 DDC clock
Power-On On On active < 60 W Blue LED Without USB
7 DDC data
Power-On On On active < 70 W Blue LED With USB
8 * Analog V-sync
Off Off On blanked < 2W Amber LED <3s
9 TMDS data1-
Off On Off blanked <2W Amber LED <3s 10 TMDS data1+
Off Off Off blanked <2W Amber LED <3s 11 TMDS data1 shield
DC Power N/A < 1W LED Off 12 NC
Off
13 NC
1.3.3. Horizontal scan : 30 - 98 KHz 14 +5V
1.3.4. Vertical scan : 56 - 85 Hz
1.3.5. Input signals 15 Ground(return for +5V and H/V-sync)
1.Signal input level 16 Hot plug detect
Video : 0.7 Vp-p Linear / 75 ohms
Sync : H/H+V, V TTL level, composite sync, sync on green 17 TMDS data0-
Impedance 18 TMDS data0+
Video : Terminated with 75 ohms
19 TMDS data0 shield
Sync : Terminated with 2K2 ohms
20 NC
21 NC
22 TMDS clock shield
23 TMDS clock+
24 TMDS clock-
C1 * Analog R
C2 * Analog G
C3 * Analog B
C4 * Analog H-sync
C5 * Analog GND (Analog R, G, B return)
Signal interface
- 15Pins, D-sub male with DDC2B Pin assignments
29Pins, DVI-I male with DDC2B Pin assignments
Sync polarity :
-Hori.sync positive/negative
-Vert.sync positive/negative
6 7 1 4 2
c
1 To switch monitor's power On and Off
2 To access OSD menu
3 To adjust the OSD
4 To adjust brightness of the display
5 To adjust the OSD
6 AUTO Automatically adjust the horizontal position,
vertical position, phase and clock setting Connect the cables to the back of your computer by following these
Hotkey for switching between SmartImage enhancement modes
steps:
Rear View
4 (1) Connect USB upstream port on monitor and the USB port on PC
with a USB cable.
(2) The USB downstream port is now ready for any USB device to
plug in
Connect to PC
Connect the power cord and DVI cable to the back of the monitor firmly.
Below is an overall view of the structure of the On-Screen Display. You can use this as a reference when you want to work
your way around the different adjustments later on.
Brightness&Contrast Brightness
Contrast
Back
Reset No
Yes
Brightness&Contrast Brightness
Contrast
Back
Back
Phase/Clock Phase
Clock
Back
OSD Setting Horizontal
Vertical
Back
Back
Reset No
Yes
Brightness&Contrast Brightness
Contrast
Back
Back
Phase/Clock Phase
Clock
Back
OSD Setting Horizontal
Vertical
Back
Back
Reset No
Yes
All units that are returned for service or repair must pass the 3. Equipments and Connection
original manufactures safety tests. Safety testing requires both
Hipot and Ground Continuity testing. 3.1. Equipments
For example :
HI-POT TEST INSTRUCTION - ChenHwa 9032 PROGRAMMABLE AUTO SAFETY
1.Application requirements TESTER
- ChenHwa 510B Digital Grounding Continuity Tester
- ChenHwa 901 (AC Hi-pot test), 902 (AC, DC Hi-pot test)
1.1 All mains operated products must pass the Hi-Pot test as
Withstanding Tester
described in this instruction.
1.2 This test must be performed again after the covers have 3.2. Connection
been refitted following the repair, inspection or modification * Turn on the power switch of monitor before Hipot and
of the product. Ground Continuity testing.
2. Test method
Clip
2.1 Connecting conditions
ATTENTION SIGNAL
Bring up:
AGING...
To Lock/Unlock OSD FUNCTION(User Mode)
The OSD function can be locked by pressing"OK"button for more
than 10 seconds, the screen shows following windows for 3 seconds.
Everytime when you press"AUTO" or "OK" button, this message app-
ears on the screen automatically. After 15 seconds, bring up:
ATTENTION SIGNAL
AGING...
ATTENTION SIGNAL
NO VIDEO INPUT
This screen appears if there is no video signal input. Please check that
the signal is properly connected to the video card of PC and make sure
PC is on
ATTENTION SIGNAL
5 3
6 7 1 4 2
Philips' Flat Panel Monitors Pixel Defect Policy Black Dot Defects
Philips strives to deliver the highest quality products. We use some of Black dot defects appear as pixels or subpixels that are always dark or
the industry's most advanced manufacturing processes and practice "off".
stringent quality control. However, pixel or subpixel defects on the TFT These are the types of black dot defects:
LCD panels used in flat panel monitors are sometimes unavoidable.
No manufacturer can guarantee that all panels will be free from pixel
defects, but Philips guarantees that any monitor with an unacceptable
number of defects will be repaired or replaced under warranty.
This notice explains the different types of pixel defects and defines
acceptable defect levels for each type. In order to qualify for repair or One dark subpixel
replacement under warranty, the number of pixel defects on a TFT LCD
panel must exceed these acceptable levels.
For example, no more than 0.0004% of the subpixels on a 15" XGA
monitor may be defective. Furthermore, Philips sets even higher quality
standards for certain types or combinations of pixel defects that are
more noticeable than others. This policy is valid worldwide . Two or three adjacent dark subpixels
Proximity of Pixel Defects
Because pixel and subpixels defects of the same type that are nearby
one another may be more noticeable, Philips also specifies tolerances
for the proximity of pixel defects.
Pixel Defect Tolerances
In order to qualify for repair or replacement due to pixel defects during
the warranty period, a TFT LCD panel in a Philips flat panel monitor
must have pixel or subpixel defects exceeding the tolerances listed in
the following tables.
MODEL 200P7
One lit red, green or blue subpixel 2 adjacent dark subpixels 1 or fewer
Note:
* 1 or 2 adjacent sub pixel defects = 1 dot defect
Your Philips monitor is ISO13406-2 Compliant
This page deals with problems that can be corrected by a user. If the problem still persists after you have tried these
solutions, contact Philips customer service representative.
Common Problems
AUTO button not working properly · The Auto Function is designed for use on
standard Macintosh or IBM-compatible PCs
running Microsoft Windows.
Imaging Problems
Image vibrates on the screen Check that the signal cable is properly connected to the
graphics board or PC
The screen is too bright or too dark · Adjust the contrast and brightness on Monitor
Setup. (The backlight of the LCD monitor has a
fixed life span. When the screen becomes dark
or begins to flicker, please contact your
dealer).
An after-image remains after the power has been turned · This is characteristic of liquid crystal and is not
off. caused by a malfunction or deterioration of the
liquid crystal. The after-image will disappear
after a peroid of time.
Green, red, blue, dark, and white dots remains The remaining dots are normal characteristic of the liquid
crystal used in today’s technology
For further assistance, refer to the Consumer Information Centers list and contact Philips customer service
representative
Fig.1
Fig.6
Fig.7
Fig.8
Fig.2
4.Remove back cover as Fig.9 and Fig.10
Fig.9
Fig.3
Unscrew the 2 screws and open the clicks on the sides
Fig.10
Step 3: Firmly insert the base removal tool into four-pronged clicks as Fig 4
Fig.4
Fig.12
Fig.5
Fig.11
Fig.15
6.Remove the power board and scaler board 8. Remove the control board
-unscrew the screws and disconnect the connectors as Fig.13,Fig.14 -unscrew the screws and disconnect the connector as Fig.16
Fig.16
Fig.13
Fig.14
7.Reomve the USB board
-Disconnect the connector and unscrew the screws as shown in Fig.15
Fig.1
3.If OSD menu disappears on the screen of monitor. press OK
again(anytime), then the OSD menu comes on the screen again.
4. Use to select OSD menu.
5. Use to access/confirm the selection.
Move the cursor to yellow area (see red circle on Fig.1) Fig.4
press OK button to access to factory mode.(see Fig.2)
O-CAL
Fig.6
Fig.3
Fig.7
9300°K 6500°K
x (center) 0.283 ± 0.005 0.313 ± 0.005
y (center) 0.297 ± 0.005 0.329 ± 0.005
sRGB
x(center) 0.313 ± 0.005
y(center) 0.329 ± 0.005
Configuration and procedure 3. At the submenu, type the letter of your computer's hard disk drive
followed by :EDID45 (for example, C:\EDID45, as shown in Fig. 7).
There are 3 chips contained OSD string, serial number..etc
on the circuit board, main EEPROM which storage all factory settings,OSD
string. DDC IC which storage 128byte EDID data(serial number ..etc.).
Following descirptions are the connection and procedure for Analog
/Digital and main EEPROM can be re-programmed along with
Analog/Digital IC by enable factory memory data write function on the
DDC program (EDID45.EXE).
Edid45.exe
1=Power connector
PC 2=D-SUB/DVI connector
To printer port (LTP1)
DC Power
----->
8-12 V
----->
Fig. 8
2 1
To PC
To Monitor
Printer Note 1: If the connection is improper, you will see the following error
Port
message (as shown in Fig. 9) before entering the main menu.
Meanwhile, the (read EDID) function will be disable. At this
time,
Fig. 5 please make sure all cables are connected correctly and
Step 3: Installation of EDID45.EXE
1
Note 2: During the loading, EDID45 will verify the EDID data which just
loaded from monitor before proceed any further function, once
the data structure of EDID can not be recognized, the following
error message will appear on the screen as below. Please
confirm following steps to avoid this message.
Fig. 10
Fig. 6
Re-programming Analog DDC IC Step 3: Modify DDC data (verify EDID version, week, year)
Step 1: After initialize alignment box, connecting all cables and
box as shown in Fig. 11 1. Click (new function) icon from the tool bar, bring up
Step 1 of 9 as shown in Fig. 15 .
EDID45 DDC application provides the function selection and
1=Power connector text change (select & fill out) from Step 1 to Step 9.
2=D-SUB connector
To Printerport
To Printer
To Printer port
port
PC 8~12V
DC 8~12V
DC 8~12V
DC
8~12V
DC 8~12V
DC
To Monitor
To Monitor
Monitor cable
ToD-sub/DVI
To Monitor cable
To D-sub/DVI
Monitor
D-sub/DVI cable
cable
D-sub cable
D-sub
To printer port (LTP1)
Power
Power
indicator
indicator
Power
Power
indicator
indicator
Select and fill out,
If necessary.
To PC
To Monitor
Printer
Port
Fig. 11
1. Click icon as shown in Fig. 11 from the tool bar to bring up Fig. 15
the Channels "Configuration Setup" windows as shown in Fig. 12.
Step 4: Modify DDC data (Monitor Serial No.)
1. Click Next to step7, bring up Fig. 16.
- Serial number can be filled up or be changed at this moment.
- Click Finish to exit the Step window.
Fig. 12
Fig. 13
Fig. 17
To Printer
To port
Printer port
Fig. 14
1. Click (Save) icon (or click "file"-> "save as") from the tool bar
And give a file name as shown in Fig. 18.
The file type is EDID45 file (*.ddc) which can be open in WordPad.
By using WordPad, the texts of DDC data & table (128 bytes, hex
code) can be modified. If DDC TEXTS & HEX Table are completely
correct, it can be saved as .ddc flie to re-load it into DDC IC for DDC
Data application.
Fig.20
200P7 analog
200P7 analog
Fig.18
Fig. 25
2. Click Save.
Fig.21
Step 7: Exit DDC program
Pull down the File menu and select Exit as shown in Fig. 19.
Edid45.1
33333
Fig.22
Step9:
-1. Disconnect the monitor power cord and connect it again.
Fig. 19 -2. Press the OK button to bring up the OSD main manu.
-3. Re-confirm the serial Number is updated as shown in Fig.23.
Fig.23
Power
3 indicator
To PC
To Monitor
Printer
Port
Fig.24
Step 2: Read DDC data from monitor
1. Click icon as shown in Fig. 25 from the tool bar to bring up Fig. 28
the Channels "Configuration Setup" windows as shown in Fig. 26.
Step 4: Modify DDC data (Monitor Serial No.)
1. Click Next , bring up Fig. 29. Then select Digital Signal as below
Fig. 25
Fig. 26 Fig. 29
To Printer port
Fig. 27 Fig. 30
SERIAL NO
YEAR/WEEK
BZ CODE(TY--CHUNGLI,VN--HUNGARY(SZR),
BZ--SUZHOU,DS--DONG GUAN)
BOM Code
Fig. 31
Panel Supplier CODE
2. Access Factory Mode AUO 1
- Turn off monitor. CPT 2
- [Push AUTO " " & OK " " buttons at the same time and
LPL(LG) 3
hold it ] + [Press power " " button untill comes out "Windows
screen"] => then release all button QDI 4
CMO 5
3. Click (Write EDID) icon from the tool bar to write DDC data.
BZ3A0601000001
Step 6: Save DDC data
Sometimes, you may need to save DDC data as a text file for using
in other IC chip. To save DDC data, follow the steps below: SERIAL NO
YEAR/WEEK
1. Click (Save) icon (or click "file"-> "save as") from the tool bar
And give a file name as shown in Fig. 32. SERVICE VERSION CHANGE CODE
The file type is EDID46 file (*.ddc) which can be open in WordPad.
By using WordPad, the texts of DDC data & table (128 bytes, hex BOM CODE(BILL OF MATERIAL)CODE
code) can be modified. If DDC TEXTS & HEX Table are completely
correct, it can be saved as .ddc flie to re-load it into DDC IC for DDC SITE CODE(PRODUCTION CENTER)
Data application. BZ CODE(AR-CZECH REPUBLIC
VN-HUNGARY(SZR),BZ-SUZHOU
DS-DONGGUAN)
200P7
Fig. 32
2. Click Save.
Pull down the File menu and select Exit as shown in Fig. 33.
Edid45.1
Fig. 33
THE DISPLAY DATA CHANNEL ( DDC 2B ) CONTENT INCLUDING Horizontal active pixels : 1280
(FOR HUDSON6-200P7 ANALOG) Aspect Ratio : 5:4
Refresh Rate : 60
********************************************************************** Standard Timing Identification #5
EDID log file Horizontal active pixels : 1600
********************************************************************** Aspect Ratio : 4:3
Vendor/Product Identification Refresh Rate : 60
ID Manufacturer Name : PHL Standard Timing Identification #6port
To Printer
ID Product Code : 0844 (HEX.) Horizontal active pixels : 1600
ID Serial Number : 1E240 (HEX.) Aspect Ratio
DC 8~12V : 4:3
DC 8~12V
Refresh Rate : 70
Week of Manufacture : 45 To Monitor #7
Year of Manufacture : 2005 Standard Timing Identification
D-sub/DVI cable
EDID Version, Revision Horizontal active pixels
To Monitor : 1600
Version : 1 Aspect RatioD-sub cable : 4:3
Revision : 3 RefreshPower
Rate : 75
indicator
Detailed Timing #1
Basic Display Parameters/Features
Video Input Definition : Analog Video Input Pixel Clock (MHz)
Power : 162
0.700V/0.300V (1.00Vpp) H Active (pixels)
indicator : 1600
Blank-to-Black Setup H Blanking (pixels) : 560
Separate Sync V Active (lines) : 1200
Composite Sync V Blanking (lines) : 50
Sync on Green H Sync Offset (F Porch) (pixels): 64
no Serration required H Sync Pulse Width (pixels) : 192
Maximum H Image Size : 41 V Sync Offset (F Porch) (lines) : 1
Maximum V Image Size : 31 V Sync Pulse Width (lines) : 3
Display Transfer Characteristic : 2.2 H Image Size (mm) : 408
(gamma) V Image Size (mm) : 306
Feature Support (DPMS) : Standby H Border (pixels) : 0
Suspend V Border (lines) : 0
Active Off Flags : Non-interlaced
Display Type : RGB color display : Normal Display, No stereo
Standard Default Color Space : Primary color space : Digital Separate sync.
Preferred Timing Mode : Detailed timing block 1 : Positive Vertical Sync.
Color Characteristics : Positive Horizontal Sync.
Red X coordinate : 0.638 Monitor Descriptor #2
Red Y coordinate : 0.342 Serial Number : TY 123456
Green X coordinate : 0.293 Monitor Descriptor #3
Green Y coordinate : 0.609 Monitor Name : Philips 200P
Blue X coordinate : 0.147 Monitor Descriptor #4
Blue Y coordinate : 0.068 Monitor Range Limits
White X coordinate : 0.313 Min. Vt rate Hz : 56
White Y coordinate : 0.329 Max. Vt rate Hz : 85
Established Timings Min. Horiz. rate kHz : 30
Established Timings I : 720 x 400 @70Hz (IBM,VGA) Max. Horiz. rate kHz : 98
640 x 480 @60Hz (IBM,VGA) Max. Supported Pixel : 210
640 x 480 @67Hz (Apple,Mac II) No secondary GTF timing formula supported.
640 x 480 @72Hz (VESA) Extension Flag : 0
640 x 480 @75Hz (VESA) Check sum : 41 (HEX.)
800 x 600 @56Hz (VESA) **********************************************************************
800 x 600 @60Hz (VESA) EDID data (128 bytes)
Established Timings II : 800 x 600 @72Hz (VESA) **********************************************************************
800 x 600 @75Hz (VESA)
832 x 624 @75Hz (Apple,Mac II) 0: 00 1: ff 2: ff 3: ff 4: ff 5: ff 6: ff 7: 00
1024 x 768 @60Hz (VESA) 8: 41 9: 0c 10: 44 11: 08 12: 40 13: e2 14: 01 15: 00
1024 x 768 @70Hz (VESA) 16: 2d 17: 0f 18: 01 19: 03 20: 1e 21: 29 22: 1f 23: 78
1024 x 768 @75Hz (VESA) 24: ee 25: 60 26: e5 27: a3 28: 57 29: 4b 30: 9c 31: 25
1280 x 1024 @75Hz (VESA) 32: 11 33: 50 34: 54 35: bf 36: ef 37: 80 38: 71 39: 4a
Manufacturer's timings : 1152 x 870 @75Hz (Apple,Mac II) 40: 71 41: 4f 42: 81 43: 40 44: 81 45: 80 46: a9 47: 40
Standard Timing Identification #1 48: a9 49: 4a 50: a9 51: 4f 52: 01 53: 01 54: 48 55: 3f
Horizontal active pixels : 1152 56: 40 57: 30 58: 62 59: b0 60: 32 61: 40 62: 40 63: c0
Aspect Ratio : 4:3 64: 13 65: 00 66: 98 67: 32 68: 11 69: 00 70: 00 71: 1e
Refresh Rate : 70 72: 00 73: 00 74: 00 75: ff 76: 00 77: 20 78: 54 79: 59
Standard Timing Identification #2 80: 20 81: 20 82: 31 83: 32 84: 33 85: 34 86: 35 87: 36
Horizontal active pixels : 1152 88: 0a 89: 20 90: 00 91: 00 92: 00 93: fc 94: 00 95: 50
Aspect Ratio : 4:3 96: 68 97: 69 98: 6c 99: 69 100: 70 101: 73 102: 20 103: 32
Refresh Rate : 75 104: 30 105: 30 106: 50 107: 0a 108: 00 109: 00 110: 00 111: fd
Standard Timing Identification #3 112: 00 113: 38 114: 55 115: 1e 116: 62 117: 15 118: 00 119: 0a
Horizontal active pixels : 1280 120: 20 121: 20 122: 20 123: 20 124: 20 125: 20 126: 00 127: 41
Aspect Ratio : 4:3
Refresh Rate : 60
To Printer port
Fig. 5
Update the firmware
Fig. 1 1. Press the load hex then select the .hex code as shown in Fig.6
Fig. 6
To printer port (LTP1)
To
Video cable
Port
ToPC
313810610396
Novatek EasyWriter 2.09
Information file(ezwriter.ini) V1.0
6. Run the Easywriter program Load File
C:\ 200P7\313811709301_141_9E83.hex
HexFile Check Sum :BAC2
Step 1 : Make a folder in your PC as shown in Fig. 3.
For example : C:\easywrite
Step 2 : Copy ISP Software Easywriter.zip into your folder
Fig. 7
as shown in Fig.3.
Step 3 : Unzip Easywriter.zip into your folder as shown in Fig. 3.
C:\ 200P7\313811709301_141_9E83.hex
NT68F632A/631A Detected
Chip erase OK
Programing Success!!!
ISP OFF.
- Auto process Finished -
Fig.8
Fig. 3
Fig.9
1.3 All voltages are to be measured or applied with respect to 6 37.500 VESA 640x480 75.000
ground, unless otherwise stated.
7 43.269 VESA 640x480 85.008
Note: don‘t use heat-sink as ground.
8 35.156 VESA 800x600 56.250
1.4 The test has to be done on a complete set including LCD
Panel in a room with temperature of 25 +/- 5 degree C. 9 37.879 VESA 800x600 60.317
10 48.077 VESA 800x600 72.188
1.5 All values mentioned in these test instruction are only
applicable of a well aligned apparatus, with correct signal. 11 46.875 VESA 800x600 75.000
1.6 The letters symbols (B) and (S) placed behind the test 12 53.674 VESA 800x600 85.061
instruction denotes
(B): carried out 100% inspection at assembly line 13 49.700 MACINTOSH 832x624 75.000
(S): carried out test by sampling 14 48.363 VESA 1024x768 60.004
1.7 The white balance (color temperature), has to be tested in
15 56.476 VESA 1024x768 70.069
subdued Lighted room.
16 60.023 VESA 1024x768 75.029
1.8 Repetitive power on/ off cycle are allowed. The image can be
displayed after 8 sec. 17 61.080 IBM XGA-2 1024x768 75.781
1.9 All optical characteristics (including WHITE-D, Brightness, and 18 68.677 VESA 1024x768 84.997
so on) are determined according to panel specification after 19 54.1 1152x864 60
warming up approximate 30 minutes that brightness stability is
optimal, and follow strictly after panel specification. 20 63.851 VESA 1152x864 70.012
2. Input signal
Signal type Item H.Freq. (KHz) Mode Resolution V.Freq. (Hz)
2.1.1 Analogue Video: 0.7 Vp-p linear, positive polarity
Sync. : TTL level, separate, positive or negative polarity 21 67.500 VESA 1152x864 75.000
Signal source: pattern generator format refer to SPEC
Reference generator : QuantumData 802G/ 802R or Chroma 2237 22 68.700 MACINTOSH 1152x870 75.000
2.1.2 Digital Video :600mVp-p TMDS Signal
2.2 Input signal mode 23 61.845 SUN WS 1152x900 66.004
(1) Factory Preset Modes (15 modes)
Item H.Freq. (KHz) Mode Resolution V.Freq. (Hz) 24 71.810 SUN WS 1152x900 76.150
1 31.469 IBM VGA 10H 640x350 70.086
25 60.000 VESA 1280x960 60.000
2 31.469 IBM VGA 3H 720x400 70.087
3.1 Setup the AC I/P at 90VAC, and 18V panel loading 0.25A, the
voltage is 18V +/- 0.9V, inverter 18V loading 1.8A, the output
voltage is 18V +/- 0.9V, 5V loading 1.2A, the DC output voltage is
5V +/-0.25VDC,
4. Display Adjustment
4.1 Access to factory mode (IIC) in auto-alignment system
The communication protocol switch to IIC .
4.2 Auto color adjustment (B)
Apply a 1280x1024/60Hz signal with Black ( 0mV) and
white ( 700 mV) pattern, set brightness control at 100%,
and contrast control at 50%.
Adjust the R. G. B offset, and gain to calibrate the color
smoothly and 64-gray level distinguishable.
Check all factory pre-setting modes.
9300°K 6500°K
x (center) 0.283 ± 0.005 0.313 ± 0.005
y (center) 0.297 ± 0.005 0.329 ± 0.005
Luminance is > 200 Nits in the center of the screen when brightness
at 100% and
contrast set to 100%.
sRGB
x(center) 0.313 ± 0.005
y(center) 0.329 ± 0.005
of the unit via a wrist wrap with resistance. Keep components and solder the component on one side. Ensure that the
and tools also at the same potential ! component is positioned correctly on the solder lands (see Fig.2A).
1. Servicing of SMDs (Surface Mounted Devices) - Next complete the soldering of the terminals of the
1.1 General cautions on handling and storage component (see Fiq. 2B).
due to the stress. Never rub or scrape chip components as directly with the soldering iron. The soldering should be
this may cause the value of the component to change. done as quickly as possible, care must be taken to avoid
Similarly, do not slide the circuit board across any surface. damage to the terminals of the SMDs themselves.
- Keep the SMD's body in contact with the printed board when
- Heat the solder (for 2-3 seconds) at each terminal of the - The soldering iron to be used (approx. 30 W ) should
chip. By means of litz wire and a slight horizontal force, preferably be equipped with a thermal control (soldering
small components can be removed with the soldering iron. temperature: 225 to 250 C).
They can also be removed with a solder sucker (see Fig. - Soldering should not be done outside the solder land.
1A) - Soldering flux (of rosin) may be used, but should not be
acidic.
- After soldering, let the SMD cool down gradually at room
temperature.
- The quantity of solder must be proportional to the size of the
solder land. If the quantity is too great, the SMD might
crack or the solder lands might be torn loose from the
printed board (see Fig. 3).
While holding the SMD with a pair of tweezers, take it off gently using the
Right
soldering iron's heat applied to each terminal (see Fig. 1 B).
- Remove the excess solder on the solder lands by means of
Fig.3 Examples
litz wire or a solder sucker (see Fig. 1C).
P
b
4. Lead-free product repair instruction
4.1 Use only lead-free Solder Alloy 0622 149 00106(1.2mm SAC305) or 0622 149
00108(1.0mm SAC305).
Remark: For lead free soldering material, please visit www.alphametals.com website for
details. This is recommended by Philips.
4.2 Use only adequate solder tools applicable for lead-free soldering-tin. The solder tool must be able to reach at least a
solder-temperature of 400 , to stabilize the adjusted temperature at the solder-tip and to exchange solder-tips for different
applications.
Small Passives/Actives to be removed with thermal tweezers
Automated system for IC and BGA repair (Microscope, Camera, Beam split optics, Computer, Programmer, Heat
controllers, Vacuum system, Laser pointer)
Solder Hand-Tool (Adjustable in temperature height, Temperature shall be held constant,
Flexible tips)
4.3 Adjust your solder tool so that a temperature around 360 -380 is reached and stabilized at the solder joint.
Heating-time of the solder-joint should not exceed ~ 4 sec. Avoid temperatures above 400 otherwise wear-out of tips will
rise drastically and flux-fluid will be destroyed.
Corrosion of Tool-Spikes can be avoided when using SAC305 and a temperature of less than 400 .
4.4 Mix of lead-free solder-tin/parts with leaded soldering-tin/parts is possible but not recommended. If not to avoid clean
carefully the solder-joint from old tin and re-solder with new tin.
AC IN
Power Board
LCD Panel
No power
(power indicator off)
NG
Check 12V/5V/3.3V Bad power board
OK
NG
Bad Scaler Board Check Scaler Board
OK
NG
Power Board Bad Power Board
OK
OK
OK
OK
OK
Check
Power Board
OK
OK
OK Control Board
OK
OK
OK
Board
1
1 14
11
11
1 29
1
2 30
1
1 8
Connector
Connector
Connector
Connector
AC-DC Power supply
Inverter and
DC-DC converter Connector
30 pin wafer
Scalar(LVDS interface)
Dual input
(200mm x 150mm) (132 mm x 140mm)
Connector
Connector
AC DVI D_SUB
input
To Printer port
DC 8~12V
DC 8~12V
To Monitor
D-sub/DVI cable
To Monitor
D-sub cable
Power
indicator
Power
indicator
To Printer port
1053
313815864501
1050 CONTROL ASSY(200P7)
932222908682
Exploded View
1051 313815864491
SCALER ASSY(200P7)
90 313815865831
313815138031 1053 1052
USB ASSY(200P7)
AC BRACKET
313815864501
CONTROL ASSY(200P7)
4
313815760791
SUPER ERGO BASE ASSY
GENERAL PRODUCT SPECIFICATION 200P7 LCD 59
Go to cover page
. CE ENVIRONMENTAL POLICY
. SOG SUPPORT
. TCO 03 / TCO 95
CONTENTS
1.0 Foreword
2.0 Product profile
2.1 LCD
2.2 Scanning frequencies
2.3 Video dot rate
2.4 Power input
2.5 Power consumption
2.6 Dimensions
2.7 Weight
2.8 Functions
2.9 Ambient temperature
2.10 Regulatory compliance
7.0 Reliability
7.1 Mean time between failures
8.0 Quality assurance requirements
8.1 Acceptance test
9.0 Serviceability
1.0 FOREWORD
This specification describes a 20.1" UXGA multi-scan color TFT
LCD monitor with max. resolution up to 1600*1200/ 75 Hz non-interlaced.
All optical characteristics (including WHITE-D, Brightness, and so on) are
determined according to panel specification after warming up approximate
30 minutes that brightness stability is optimal, and follow strictly after panel
specification.
Sync. : Separate sync TTL level , input impedance 2.2k ohm terminate
Hsync Positive/Negative
Vsync Positive/Negative
Composite sync TTL level, input impedance 5k ohm terminate
(Positive/Negative)
Sync on green video 0.3 Vp-p Negative (Video 0.7 Vp-p Positive)
2) DVI_A: analog R/G/B separate inputs, H/V sync separated, Composite (H+V) TTL level, SOG
sync
3.2 Interface
pin assignment :
The input signals are applied to the display through DVI-D cable.
Length : 1.8 M +100/- 0 mm (fixed)
Connector type : DVI-D male with DDC2B pin assignments
White connector thumb-operated jack screws
pin assignment :
20 NC
21 NC
22 TMDS clock shield
23 TMDS clock+
24 TMDS clock-
C1 * Analog R
C2 * Analog G
C3 * Analog B
C4 * Analog H-sync
C5 * Analog GND (Analog R, G, B return)
All display adjustments will be performed by using an On Screen Display (OSD) in conjunction with
controls on the front of the monitor. The specification of OSD window is as below:
Philips SmarImage feature enriches your photo and video experience with preset modes ideal for your favorite
applications: Office Work, Internet, Image Viewing, and Video Playback. The SmartImage engine optimizes luminance,
contrast gap, color boost, sharpness, and text enhancement for photos and skin tone for videos.
Expect using key to scroll down, you can also press buttons to choose and press " ok " to confirm selection
and close the SmartImage OSD.
1. Internet: Select this mode for Internet application, especially web browsing. The screen is mixed by text and
picture.
2. Image Viewing: Select this mode for image viewing application, especially in slid show. The screen is
dominated by picture.
3. Video Playback: Select this mode for video application, like Microsoft Media Player or Real Player. The screen
is dominated by video.
4. Custom: Select this mode for you to adjust the rate of luminance, contrast gap, color boost, sharpness, and
text enhancement by yourself.
MODE NO. 5 6 7 8
RESOLUTION 800 x 600 800 x 600 800 x 600 1024 x 768
MODE NO. 9 10 11 12
RESOLUTION 1024 x 768 1152 x 870 1280 x 1024 1280 x 1024
MODE NO. 13 14 15
RESOLUTION 1600 x 1200 1600 x 1200 1600 x 1200
Remark : Mode 14:/ 15 1600 * 1200 70 Hz and 75Hz only supported by analog signal , DVI can’t support these mode.
(3) Warm up: more than 30 minutes after power on with signal supplied.
4.2 Resolution
Factory preset modes ( 15 modes )
Item H.Freq. Mode Resolution V.Freq. Item H.Freq. Mode Resolution V.Freq.
(KHz) (Hz) (KHz) (Hz)
1 31.469 IBM VGA 10H 640x350 70.086 9 60.023 VESA 1024x768 75.029
3 31.469 IBM VGA 12H 640x480 59.940 11 63.981 VESA 1280x102 60.020
4
Remark : Mode 14:/ 15 1600 * 1200 70 Hz and 75Hz only supported by analog signal , DVI can t support these mode.
4.3 Brightness : >=200 nits (at panel color temperature, at center of the screen, set contrast
and brightness at maximum. )
Set contrast at 100% and turn the brightness to get average above 200 nits
at centre of the screen.
Apply the Fig 1, it should comply with the following formula:
B_min
X 100% >65%
B_max
There are three factory preset white color 9300K, 6500K, sRGB.
5.1 Controls
Front side:
- OSD function key (OK)
- UP
- DOWN
- POWER
- LIGHT FRAME
- RIGHT
- LEFT
- AUTO
Rear:
- D-SUB
- DVI-I
- Power cord socket
Operating
- Temperature : 0 to 35 degree C
- Humidity : 80% max
- Altitude : 0-3658m
- Air pressure : 600-1100 mBAR
Storage
- Temperature : -30 to 60 degree C
- Humidity : 85% max ( < 40 )
- Altitude : 0-12192m
- Air pressure : 300-1100 mBAR
Note: recommend at 5 to 35°C, Humidity less than 60 %
6.4.1 EMI
EMI : C-tick, CE(Europe), FCC(USA), IC(Canada), VCCI(Japan), BSMI
7.0 Reliability
9.0 Serviceability
The serviceability of this monitor should fulfill the
requirements which are prescribed in UAW-0346 and must
be checked with the check list UAT-0361.
L/2 L L/10
W/10
1 2 3
4 5 6 W
W/2
7 8 9
1/2
YA
1/2
1/3
1/2
1/3
YB
1/2
1/3
SEPARATE SYNC.
VIDEO
C D E
HORIZONTAL
B
A
VIDEO
Q R S
VERTICAL
P
O
COMPOSITE SYNC.
VIDEO
C D E
HORIZONTAL
B
A
VIDEO
Q R S
VERTICAL
P
O
HORIZONTAL
C D E
B
A
VERTICAL
B S P Q R
O
Model:200P7ES/00(LPL PANEL)
1955 243812800196 SWI TACT H=5 GY 160G SKHHAM B 2401 202203100205 ELCAP SM RVS 25V 47U PM20 R
Mechanical Parts
1956 243812800196 SWI TACT H=5 GY 160G SKHHAM B 2402 223878615649 CER2 0603 X7R 16V 100N PM10 R
0004 313815760791 SUPER ERGO BASE ASSY
1957 243812800196 SWI TACT H=5 GY 160G SKHHAM B 2403 823827736009 CHIP 4.7UF 25V X7R 1206
0030 313815760851 FRONT BEZEL ASSY
1960 243812800196 SWI TACT H=5 GY 160G SKHHAM B 2404 223878615649 CER2 0603 X7R 16V 100N PM10 R
0031 313815417351 BEZEL
1961 242202518898 CON H 8P M 2.00 63368 B 2405 823827736009 CHIP 4.7UF 25V X7R 1206
0032 313815417341 BEZEL -DECO
4444 313810610499 CD ROM - SERVICE MANUAL 2406 223878615649 CER2 0603 X7R 16V 100N PM10 R
0033 313815417361 CONTROL KNOB
4444 313810610500 SERVICE MANUAL 2407 823827736009 CHIP 4.7UF 25V X7R 1206
0034 313815417711 OSD INSULATE PLATE
8061 823827732017 CBLE 024 14/480/8+6-018-16 A28 2408 223878615649 CER2 0603 X7R 16V 100N PM10 R
0040 313815760861 BACK COVER ASSY
8171 823827732016 CBLE-921 11/70/11-021 AWG26 2409 823827736009 CHIP 4.7UF 25V X7R 1206
0041 313815417381 BACK COVER
PCB ASSY 2410 223878615649 CER2 0603 X7R 16V 100N PM10 R
0042 313815417371 MIDDLE COVER
0051 313815138011 METAL FRAME 1051 313815864491 SCALER ASSY(200P7) 2411 823827736009 CHIP 4.7UF 25V X7R 1206
0080 313815760881 METAL COVER ASSY 2412 223878615649 CER2 0603 X7R 16V 100N PM10 R
0081 313815138021 METAL COVER 2201 223878615649 CER2 0603 X7R 16V 100N PM10 R 2413 202203100205 ELCAP SM RVS 25V 47U PM20 R
0082 313815417391 INSULATE PLATE 2202 223878615649 CER2 0603 X7R 16V 100N PM10 R 2414 223878615649 CER2 0603 X7R 16V 100N PM10 R
0090 313815138031 AC BRACKET 2203 223886715331 CER1 0603 NP0 50V 330P PM5 R 2415 823827736009 CHIP 4.7UF 25V X7R 1206
0126 313815568851 RATING LABEL 2204 223886715331 CER1 0603 NP0 50V 330P PM5 R 2416 223878615649 CER2 0603 X7R 16V 100N PM10 R
0452 313815641501 CUSHION - BOTTOM 2205 223878615649 CER2 0603 X7R 16V 100N PM10 R 2417 223878615649 CER2 0603 X7R 16V 100N PM10 R
1056 823827732018 CBLE 130 30/120/30 334033AWG28 2206 223878615645 CER2 0603 X7R 16V 47N PM10 R 2419 223878615649 CER2 0603 X7R 16V 100N PM10 R
1057 313815865811 METAL FRAME+WIRE ASSY 2207 223878615645 CER2 0603 X7R 16V 47N PM10 R 2420 823827736009 CHIP 4.7UF 25V X7R 1206
2208 223878615645 CER2 0603 X7R 16V 47N PM10 R 2421 823827736009 CHIP 4.7UF 25V X7R 1206
LCD PANEL 2209 223878615645 CER2 0603 X7R 16V 47N PM10 R 2422 223878615649 CER2 0603 X7R 16V 100N PM10 R
1050 932222908682 TFT-LCD LM201U04-SL02 (LGPH) B 2210 223878615645 CER2 0603 X7R 16V 47N PM10 R 2423 823827736009 CHIP 4.7UF 25V X7R 1206
2211 223886715221 CER1 0603 NP0 50V 220P PM5 R 2424 223878615649 CER2 0603 X7R 16V 100N PM10 R
Packing 2212 223886715339 CER1 0603 NP0 50V 33P PM5 R 2425 223878615649 CER2 0603 X7R 16V 100N PM10 R
0129 313810632613 PE BAG 2213 223878615645 CER2 0603 X7R 16V 47N PM10 R 2426 223878615649 CER2 0603 X7R 16V 100N PM10 R
0450 313815641481 CARTON 2214 223878615649 CER2 0603 X7R 16V 100N PM10 R 2427 223878615649 CER2 0603 X7R 16V 100N PM10 R
0451 313815641491 CUSHION - TOP 2215 223886715331 CER1 0603 NP0 50V 330P PM5 R 2428 223878615649 CER2 0603 X7R 16V 100N PM10 R
0453 313815621491 P.E. BAG 2216 223886715331 CER1 0603 NP0 50V 330P PM5 R 2429 223878615649 CER2 0603 X7R 16V 100N PM10 R
0508 313815641481 CARTON 2217 223886715339 CER1 0603 NP0 50V 33P PM5 R 2430 223878615649 CER2 0603 X7R 16V 100N PM10 R
0508 313815641481 CARTON 2218 223886715221 CER1 0603 NP0 50V 220P PM5 R 2431 223878615649 CER2 0603 X7R 16V 100N PM10 R
Accessory 2219 223878615649 CER2 0603 X7R 16V 100N PM10 R 2432 823827736009 CHIP 4.7UF 25V X7R 1206
0602 313811709291 E-D.F.U. 2220 223886715568 CER1 0603 NP0 50V 5P6 PM0P5 R 2433 823827736009 CHIP 4.7UF 25V X7R 1206
1060 313819871431 CORD SUB-D 15/1M8/15 D-SUB BK 2221 223878615645 CER2 0603 X7R 16V 47N PM10 R 2434 223878615649 CER2 0603 X7R 16V 100N PM10 R
1061 313818870471 MAINSCORD IEC 10A 1M8 DET BK 2222 223858615623 CER2 0603 X7R 50V 1N PM10 R 2435 223878615649 CER2 0603 X7R 16V 100N PM10 R
1064 313819871471 CORD DVI 18+1/1M8/DVI 18+1 BK 2223 223886715568 CER1 0603 NP0 50V 5P6 PM0P5 R 2436 823827736009 CHIP 4.7UF 25V X7R 1206
PCB ASSY 2224 223878615645 CER2 0603 X7R 16V 47N PM10 R 2437 223878615649 CER2 0603 X7R 16V 100N PM10 R
1051 313815864491 SCALER ASSY(200P7) 2225 223878615645 CER2 0603 X7R 16V 47N PM10 R 2438 223878615649 CER2 0603 X7R 16V 100N PM10 R
1052 313815865831 USB ASSY(200P7) 2226 223886715568 CER1 0603 NP0 50V 5P6 PM0P5 R 2439 223878615649 CER2 0603 X7R 16V 100N PM10 R
1053 313815864501 CONTROL ASSY(200P7) 2227 223878615645 CER2 0603 X7R 16V 47N PM10 R 2440 223878615649 CER2 0603 X7R 16V 100N PM10 R
1055 313815866501 POWER ASSY 2228 223878615645 CER2 0603 X7R 16V 47N PM10 R 2441 223878615649 CER2 0603 X7R 16V 100N PM10 R
Miscellanea 2229 223878615649 CER2 0603 X7R 16V 100N PM10 R 2442 223878615649 CER2 0603 X7R 16V 100N PM10 R
0138 313815555711 HI-POT LABEL 2236 223878615649 CER2 0603 X7R 16V 100N PM10 R 2443 223878615649 CER2 0603 X7R 16V 100N PM10 R
0141 313815524211 QUICK SETUP GUIDE 2240 223858615623 CER2 0603 X7R 50V 1N PM10 R 2444 223878615649 CER2 0603 X7R 16V 100N PM10 R
0163 313810164871 EYELET HOLES 1.9 2241 223878615645 CER2 0603 X7R 16V 47N PM10 R 2445 223878615649 CER2 0603 X7R 16V 100N PM10 R
0174 313815161031 HEAT SINK 2302 223878615649 CER2 0603 X7R 16V 100N PM10 R 2446 223878615649 CER2 0603 X7R 16V 100N PM10 R
0185 313815133751 HEAT SINK 2303 202203100429 ELCAP SM RVL 16V 22U PM20 R 2447 223886715339 CER1 0603 NP0 50V 33P PM5 R
0280 313800991971 PROCESS BOX 2304 223878615649 CER2 0603 X7R 16V 100N PM10 R 2448 223886715339 CER1 0603 NP0 50V 33P PM5 R
0280 313800991971 PROCESS BOX 2305 223878615649 CER2 0603 X7R 16V 100N PM10 R 2451 223878615649 CER2 0603 X7R 16V 100N PM10 R
0290 313800992071 PROCESS BOX 2306 223878615649 CER2 0603 X7R 16V 100N PM10 R 2452 223878615649 CER2 0603 X7R 16V 100N PM10 R
0290 313800992071 PROCESS BOX 2307 223878615649 CER2 0603 X7R 16V 100N PM10 R 2453 223878615649 CER2 0603 X7R 16V 100N PM10 R
0291 313815568861 LABEL 2308 223878615649 CER2 0603 X7R 16V 100N PM10 R 2454 223858615636 CER2 0603 X7R 50V 10N PM10 R
0292 313815568861 LABEL 2309 223878615649 CER2 0603 X7R 16V 100N PM10 R 2455 823827736009 CHIP 4.7UF 25V X7R 1206
0615 313811709301 HEX CODE OF F/W(NO MATL REQ) 2310 223878615649 CER2 0603 X7R 16V 100N PM10 R 2456 823827736009 CHIP 4.7UF 25V X7R 1206
1098 243803100435 SOC IC V 8P F 2.54 DIL L 2311 223878615649 CER2 0603 X7R 16V 100N PM10 R 2457 223878615649 CER2 0603 X7R 16V 100N PM10 R
1099 243803100437 SOC IC V 44P F 1.27 PLCC B 2312 202203100429 ELCAP SM RVL 16V 22U PM20 R 2501 223891619849 CER2 0603 Y5V 25V 100N P8020 R
1101 823827733001 SOC POW H 3P M AC 2313 223878615649 CER2 0603 X7R 16V 100N PM10 R 2502 223891619849 CER2 0603 Y5V 25V 100N P8020 R
1103 242208610239 FUSE 5X20 HT 3A15 250V IEC B 2314 223878615649 CER2 0603 X7R 16V 100N PM10 R 2503 202203100205 ELCAP SM RVS 25V 47U PM20 R
1175 242208600678 FUSE RAD LT 5A 250V IEC A 2315 223878615649 CER2 0603 X7R 16V 100N PM10 R 2504 223878615649 CER2 0603 X7R 16V 100N PM10 R
1191 313815865781 DIODE ASSY 2316 223878615649 CER2 0603 X7R 16V 100N PM10 R 2505 223878615649 CER2 0603 X7R 16V 100N PM10 R
1192 313815867061 MOS ASSY(7102) 2317 223878615649 CER2 0603 X7R 16V 100N PM10 R 2506 202203100205 ELCAP SM RVS 25V 47U PM20 R
1201 242203300522 SOC DVI H 29P F 1.91DVI-I Y 2318 223878615649 CER2 0603 X7R 16V 100N PM10 R 2510 223878615649 CER2 0603 X7R 16V 100N PM10 R
1202 242202518065 SOC SUBD H 15P F BU 900 Y 2319 223878615649 CER2 0603 X7R 16V 100N PM10 R 2511 223878615649 CER2 0603 X7R 16V 100N PM10 R
1351 243854300079 RES XTL SM 12MHZ 32P SMD-49 R 2320 223878615649 CER2 0603 X7R 16V 100N PM10 R 2515 223878615649 CER2 0603 X7R 16V 100N PM10 R
1401 243854300093 RES XTL SM 14M3181 18P SMD49 R 2321 223878615649 CER2 0603 X7R 16V 100N PM10 R 2516 223878615649 CER2 0603 X7R 16V 100N PM10 R
1501 242202518826 CON V 14P M 2.00 63394 B 2322 223878615649 CER2 0603 X7R 16V 100N PM10 R 2517 223878615649 CER2 0603 X7R 16V 100N PM10 R
1602 242202518818 CON V 6P M 2.00 63386 B 2323 223878615649 CER2 0603 X7R 16V 100N PM10 R 2518 223878615649 CER2 0603 X7R 16V 100N PM10 R
1608 313818879141 CBLE RING TERM/50/FAST AWG18 2324 223878615649 CER2 0603 X7R 16V 100N PM10 R 2519 223878615649 CER2 0603 X7R 16V 100N PM10 R
1609 313818874422 CBLE RING TERM/100/FAST AWG18 2325 223878615649 CER2 0603 X7R 16V 100N PM10 R 2520 223878615645 CER2 0603 X7R 16V 47N PM10 R
1610 243854300085 RES XTL SM 24MHZ 20P SMD-49 R 2326 223878615649 CER2 0603 X7R 16V 100N PM10 R 2521 202203100205 ELCAP SM RVS 25V 47U PM20 R
1651 242202518953 SOC USB V 4P F 2.0/2.5 5401 Y 2327 223878615649 CER2 0603 X7R 16V 100N PM10 R 2522 223878615649 CER2 0603 X7R 16V 100N PM10 R
1652 242202518955 SOC USB V 4P F 2.5 5411 Y 2328 223878615649 CER2 0603 X7R 16V 100N PM10 R 2523 223891619849 CER2 0603 Y5V 25V 100N P8020 R
1653 242202518957 SOC USB V 8P F 2.0/2.5 5402 R 2329 223878615649 CER2 0603 X7R 16V 100N PM10 R 2524 823827736009 CHIP 4.7UF 25V X7R 1206
1654 242202518953 SOC USB V 4P F 2.0/2.5 5401 Y 2330 223858615636 CER2 0603 X7R 50V 10N PM10 R 2525 823827736009 CHIP 4.7UF 25V X7R 1206
1701 242202518804 CON V 30P M 1.25 SM 60948 R 2332 823827736009 CHIP 4.7UF 25V X7R 1206 2526 223878615649 CER2 0603 X7R 16V 100N PM10 R
1703 242254000017 RES CER SM 60MHZ CSTCW*X51 R 2333 823827736009 CHIP 4.7UF 25V X7R 1206 2527 223878615649 CER2 0603 X7R 16V 100N PM10 R
1705 242202518816 CON V 4P M 2.00 63384 B 2334 223878615649 CER2 0603 X7R 16V 100N PM10 R 2528 223878615649 CER2 0603 X7R 16V 100N PM10 R
1803 313818877341 CON BM H 2P M 3.5 61196 2351 223878615649 CER2 0603 X7R 16V 100N PM10 R
2529 823827736009 CHIP 4.7UF 25V X7R 1206
1806 313818877341 CON BM H 2P M 3.5 61196 2353 223886715229 CER1 0603 NP0 50V 22P PM5 R
2530 223878615649 CER2 0603 X7R 16V 100N PM10 R
1807 313818877621 CON BM H 9P F 4MM 8MM 64024 2354 223886715229 CER1 0603 NP0 50V 22P PM5 R
2531 823827736009 CHIP 4.7UF 25V X7R 1206
1808 313818877621 CON BM H 9P F 4MM 8MM 64024 2355 223886715101 CER1 0603 NP0 50V 100P PM5 R
2538 223878615645 CER2 0603 X7R 16V 47N PM10 R
1951 243812800196 SWI TACT H=5 GY 160G SKHHAM B 2356 223878615649 CER2 0603 X7R 16V 100N PM10 R
2539 223878615645 CER2 0603 X7R 16V 47N PM10 R
1952 243812800196 SWI TACT H=5 GY 160G SKHHAM B 2358 223886715101 CER1 0603 NP0 50V 100P PM5 R
2701 223878615649 CER2 0603 X7R 16V 100N PM10 R
1953 243812800196 SWI TACT H=5 GY 160G SKHHAM B 2359 823827736009 CHIP 4.7UF 25V X7R 1206
2702 223878615649 CER2 0603 X7R 16V 100N PM10 R
1954 243812800196 SWI TACT H=5 GY 160G SKHHAM B 2360 223878615649 CER2 0603 X7R 16V 100N PM10 R
2703 223878615649 CER2 0603 X7R 16V 100N PM10 R
2361 223886715101 CER1 0603 NP0 50V 100P PM5 R
Go to cover page
2704 223878615649 CER2 0603 X7R 16V 100N PM10 R 3252 212211805638 RST SM 0603 RC0603 33R PM5 R 3523 232270260103 RST SM 0603 RC21 10K PM5 R
2705 223878615649 CER2 0603 X7R 16V 100N PM10 R 3253 212211805964 RST SM 0603 RC0603 75R PM1 R 3524 212211805683 RST SM 0603 RC0603 100K PM5 R
2706 223878615649 CER2 0603 X7R 16V 100N PM10 R 3254 212211805641 RST SM 0603 RC0603 68R PM5 R 3525 232270260103 RST SM 0603 RC21 10K PM5 R
2707 223878615649 CER2 0603 X7R 16V 100N PM10 R 3255 212211805656 RST SM 0603 RC0603 1K PM5 R 3526 232270260103 RST SM 0603 RC21 10K PM5 R
2708 223891619849 CER2 0603 Y5V 25V 100N P8020 R 3256 232270260103 RST SM 0603 RC21 10K PM5 R 3527 232270260101 RST SM 0603 RC21 100R PM5 R
2709 823827736009 CHIP 4.7UF 25V X7R 1206 3258 232270260223 RST SM 0603 RC21 22K PM5 R 3528 232270260101 RST SM 0603 RC21 100R PM5 R
2710 223878615649 CER2 0603 X7R 16V 100N PM10 R 3259 232270260223 RST SM 0603 RC21 22K PM5 R 3532 232270260103 RST SM 0603 RC21 10K PM5 R
2711 223878615649 CER2 0603 X7R 16V 100N PM10 R 3301 212211805656 RST SM 0603 RC0603 1K PM5 R 3533 232270260103 RST SM 0603 RC21 10K PM5 R
2712 823827736009 CHIP 4.7UF 25V X7R 1206 3302 212211805656 RST SM 0603 RC0603 1K PM5 R 3534 232270260103 RST SM 0603 RC21 10K PM5 R
2713 823827736009 CHIP 4.7UF 25V X7R 1206 3303 232270260151 RST SM 0603 RC21 150R PM5 R 3535 232270260103 RST SM 0603 RC21 10K PM5 R
2714 202203100205 ELCAP SM RVS 25V 47U PM20 R 3304 212211805637 RST SM 0603 RC0603 22R PM5 R 3701 212211805689 RST SM 0603 RC0603 1M PM5 R
2715 223878615649 CER2 0603 X7R 16V 100N PM10 R 3305 212211805637 RST SM 0603 RC0603 22R PM5 R 3702 232270260479 RST SM 0603 RC21 47R PM5 R
2716 223878615649 CER2 0603 X7R 16V 100N PM10 R 3306 212211805637 RST SM 0603 RC0603 22R PM5 R 3703 232270260101 RST SM 0603 RC21 100R PM5 R
2717 223878615649 CER2 0603 X7R 16V 100N PM10 R 3307 212211805637 RST SM 0603 RC0603 22R PM5 R 3704 232270260479 RST SM 0603 RC21 47R PM5 R
2718 223878615649 CER2 0603 X7R 16V 100N PM10 R 3308 212211805637 RST SM 0603 RC0603 22R PM5 R 3705 232270260103 RST SM 0603 RC21 10K PM5 R
2719 223878615649 CER2 0603 X7R 16V 100N PM10 R 3309 212211805637 RST SM 0603 RC0603 22R PM5 R 3706 232270260101 RST SM 0603 RC21 100R PM5 R
2720 223878615649 CER2 0603 X7R 16V 100N PM10 R 3310 212211805637 RST SM 0603 RC0603 22R PM5 R 3707 232270260103 RST SM 0603 RC21 10K PM5 R
2721 223878615649 CER2 0603 X7R 16V 100N PM10 R 3311 212211805637 RST SM 0603 RC0603 22R PM5 R 3708 232270260101 RST SM 0603 RC21 100R PM5 R
2722 223878615649 CER2 0603 X7R 16V 100N PM10 R 3312 212211805637 RST SM 0603 RC0603 22R PM5 R 3710 232270260101 RST SM 0603 RC21 100R PM5 R
2723 223878615649 CER2 0603 X7R 16V 100N PM10 R 3313 212211805637 RST SM 0603 RC0603 22R PM5 R 3713 232270260103 RST SM 0603 RC21 10K PM5 R
2724 823827736009 CHIP 4.7UF 25V X7R 1206 3314 235003510229 RST NETW SM ARV24 4X 22R PM5 R 3714 232270260103 RST SM 0603 RC21 10K PM5 R
2725 202203100205 ELCAP SM RVS 25V 47U PM20 R 3315 235003510229 RST NETW SM ARV24 4X 22R PM5 R 3715 232270260101 RST SM 0603 RC21 100R PM5 R
2726 223878615649 CER2 0603 X7R 16V 100N PM10 R 3316 235003510229 RST NETW SM ARV24 4X 22R PM5 R 3716 232270260101 RST SM 0603 RC21 100R PM5 R
2727 223878615649 CER2 0603 X7R 16V 100N PM10 R 3317 235003510229 RST NETW SM ARV24 4X 22R PM5 R 3717 232270260101 RST SM 0603 RC21 100R PM5 R
2728 223878615649 CER2 0603 X7R 16V 100N PM10 R 3318 235003510229 RST NETW SM ARV24 4X 22R PM5 R 3718 232270260101 RST SM 0603 RC21 100R PM5 R
2729 223878615649 CER2 0603 X7R 16V 100N PM10 R 3319 235003510229 RST NETW SM ARV24 4X 22R PM5 R 3719 232270260101 RST SM 0603 RC21 100R PM5 R
2730 223878615649 CER2 0603 X7R 16V 100N PM10 R 3320 235003510229 RST NETW SM ARV24 4X 22R PM5 R 3720 232270260101 RST SM 0603 RC21 100R PM5 R
2731 823827736009 CHIP 4.7UF 25V X7R 1206 3321 235003510229 RST NETW SM ARV24 4X 22R PM5 R 3721 212211805665 RST SM 0603 RC0603 4K7 PM5 R
2732 202203100205 ELCAP SM RVS 25V 47U PM20 R 3322 212211805637 RST SM 0603 RC0603 22R PM5 R 3722 232270260101 RST SM 0603 RC21 100R PM5 R
2733 223878615649 CER2 0603 X7R 16V 100N PM10 R 3323 212211805637 RST SM 0603 RC0603 22R PM5 R 3723 212211805665 RST SM 0603 RC0603 4K7 PM5 R
2734 223878615649 CER2 0603 X7R 16V 100N PM10 R 3351 212211805689 RST SM 0603 RC0603 1M PM5 R 3724 232270260101 RST SM 0603 RC21 100R PM5 R
2737 223878615649 CER2 0603 X7R 16V 100N PM10 R 3352 232270260101 RST SM 0603 RC21 100R PM5 R 3725 232270260103 RST SM 0603 RC21 10K PM5 R
2738 202203100173 ELCAP EB 25V S 470U PM20 B 3354 232270260101 RST SM 0603 RC21 100R PM5 R 3726 232270260103 RST SM 0603 RC21 10K PM5 R
2739 223891619849 CER2 0603 Y5V 25V 100N P8020 R 3358 232270260103 RST SM 0603 RC21 10K PM5 R 3727 212211805665 RST SM 0603 RC0603 4K7 PM5 R
2740 223858015614 CER2 0805 X7R 50V 220P PM10 R 3359 232270260101 RST SM 0603 RC21 100R PM5 R 3728 232270260101 RST SM 0603 RC21 100R PM5 R
2741 223858015641 CER2 0805 X7R 50V 22N PM10 R 3360 232270260103 RST SM 0603 RC21 10K PM5 R 3730 232270260473 RST SM 0603 RC21 47K PM5 R
2742 223878615649 CER2 0603 X7R 16V 100N PM10 R 3361 232270260103 RST SM 0603 RC21 10K PM5 R 3731 232270260103 RST SM 0603 RC21 10K PM5 R
2743 223878615649 CER2 0603 X7R 16V 100N PM10 R 3364 232270260103 RST SM 0603 RC21 10K PM5 R 3732 212211805665 RST SM 0603 RC0603 4K7 PM5 R
2744 223878615649 CER2 0603 X7R 16V 100N PM10 R 3365 232270260103 RST SM 0603 RC21 10K PM5 R 3733 232270260103 RST SM 0603 RC21 10K PM5 R
2745 223878615649 CER2 0603 X7R 16V 100N PM10 R 3366 232270260103 RST SM 0603 RC21 10K PM5 R 4301 232270296001 RST SM 0603 JUMP. MAX 0R05 R
3367 232270260103 RST SM 0603 RC21 10K PM5 R 4302 232270296001 RST SM 0603 JUMP. MAX 0R05 R
3201 232270260103 RST SM 0603 RC21 10K PM5 R 3368 232270260101 RST SM 0603 RC21 100R PM5 R 4303 232270296001 RST SM 0603 JUMP. MAX 0R05 R
3202 212211805656 RST SM 0603 RC0603 1K PM5 R 3369 232270260101 RST SM 0603 RC21 100R PM5 R 4304 232270296001 RST SM 0603 JUMP. MAX 0R05 R
3203 212211805656 RST SM 0603 RC0603 1K PM5 R 3370 232270260103 RST SM 0603 RC21 10K PM5 R 4503 232270296001 RST SM 0603 JUMP. MAX 0R05 R
3207 232270260103 RST SM 0603 RC21 10K PM5 R 3371 232270260103 RST SM 0603 RC21 10K PM5 R 4508 232270296001 RST SM 0603 JUMP. MAX 0R05 R
3208 232270260103 RST SM 0603 RC21 10K PM5 R 3372 232270260103 RST SM 0603 RC21 10K PM5 R 4510 232270296001 RST SM 0603 JUMP. MAX 0R05 R
3209 232270260103 RST SM 0603 RC21 10K PM5 R 3373 232270260101 RST SM 0603 RC21 100R PM5 R 4703 232273091002 RST SM 0805 JUMP. MAX 0R05 R
3210 232270260223 RST SM 0603 RC21 22K PM5 R 3374 232270260101 RST SM 0603 RC21 100R PM5 R 4708 232270296001 RST SM 0603 JUMP. MAX 0R05 R
3211 232270260101 RST SM 0603 RC21 100R PM5 R 3375 232270260101 RST SM 0603 RC21 100R PM5 R 4709 232270296001 RST SM 0603 JUMP. MAX 0R05 R
3212 232270260101 RST SM 0603 RC21 100R PM5 R 3376 232270260101 RST SM 0603 RC21 100R PM5 R 4710 232270296001 RST SM 0603 JUMP. MAX 0R05 R
3213 232270260101 RST SM 0603 RC21 100R PM5 R 3378 232270260101 RST SM 0603 RC21 100R PM5 R 4711 232270296001 RST SM 0603 JUMP. MAX 0R05 R
3214 232270260101 RST SM 0603 RC21 100R PM5 R 3379 232270260101 RST SM 0603 RC21 100R PM5 R 4712 232270296001 RST SM 0603 JUMP. MAX 0R05 R
3215 232270260101 RST SM 0603 RC21 100R PM5 R 3380 232270260101 RST SM 0603 RC21 100R PM5 R
3216 212211805641 RST SM 0603 RC0603 68R PM5 R 3382 232270260103 RST SM 0603 RC21 10K PM5 R 5201 242254945582 IND FXD 0805 EMI 100MHZ 300R R
3217 212211805964 RST SM 0603 RC0603 75R PM1 R 3401 232270463901 RST SM 0603 RC22H 390R PM1 R 5202 242254945582 IND FXD 0805 EMI 100MHZ 300R R
3218 212211805641 RST SM 0603 RC0603 68R PM5 R 3402 232270260101 RST SM 0603 RC21 100R PM5 R 5203 242254945582 IND FXD 0805 EMI 100MHZ 300R R
3219 212211805964 RST SM 0603 RC0603 75R PM1 R 3403 212211805637 RST SM 0603 RC0603 22R PM5 R 5204 242254945582 IND FXD 0805 EMI 100MHZ 300R R
3220 212211805964 RST SM 0603 RC0603 75R PM1 R 3405 232270260103 RST SM 0603 RC21 10K PM5 R 5205 242254900595 IND FXD 0603 EMI 100MHZ 10R R
3221 212211805641 RST SM 0603 RC0603 68R PM5 R 3408 212211805637 RST SM 0603 RC0603 22R PM5 R 5206 242254900595 IND FXD 0603 EMI 100MHZ 10R R
3222 212211805661 RST SM 0603 RC0603 2K2 PM5 R 3409 212211805637 RST SM 0603 RC0603 22R PM5 R 5207 242254900595 IND FXD 0603 EMI 100MHZ 10R R
3223 212211805638 RST SM 0603 RC0603 33R PM5 R 3410 212211805637 RST SM 0603 RC0603 22R PM5 R 5301 242254945582 IND FXD 0805 EMI 100MHZ 300R R
3224 212211805638 RST SM 0603 RC0603 33R PM5 R 3411 212211805637 RST SM 0603 RC0603 22R PM5 R 5302 242254945582 IND FXD 0805 EMI 100MHZ 300R R
3225 212211805638 RST SM 0603 RC0603 33R PM5 R 3412 232270260229 RST SM 0603 RC21 22R PM5 R 5351 242254945582 IND FXD 0805 EMI 100MHZ 300R R
3226 232270260471 RST SM 0603 RC21 470R PM5 R 3413 212211805656 RST SM 0603 RC0603 1K PM5 R 5401 242254945582 IND FXD 0805 EMI 100MHZ 300R R
3227 232270260101 RST SM 0603 RC21 100R PM5 R 3414 212211805656 RST SM 0603 RC0603 1K PM5 R 5402 242254945582 IND FXD 0805 EMI 100MHZ 300R R
3228 212211805661 RST SM 0603 RC0603 2K2 PM5 R 3416 232270260101 RST SM 0603 RC21 100R PM5 R 5403 242254945582 IND FXD 0805 EMI 100MHZ 300R R
3229 232270260103 RST SM 0603 RC21 10K PM5 R 3501 232270260479 RST SM 0603 RC21 47R PM5 R 5404 242254945582 IND FXD 0805 EMI 100MHZ 300R R
3230 232270260103 RST SM 0603 RC21 10K PM5 R 3502 232270260479 RST SM 0603 RC21 47R PM5 R 5405 242254945582 IND FXD 0805 EMI 100MHZ 300R R
3231 212211805641 RST SM 0603 RC0603 68R PM5 R 3503 232270260479 RST SM 0603 RC21 47R PM5 R 5406 242254945582 IND FXD 0805 EMI 100MHZ 300R R
3233 232270260103 RST SM 0603 RC21 10K PM5 R 3504 232270260103 RST SM 0603 RC21 10K PM5 R 5407 242254945582 IND FXD 0805 EMI 100MHZ 300R R
3234 232270260223 RST SM 0603 RC21 22K PM5 R 3506 232270260101 RST SM 0603 RC21 100R PM5 R 5409 242254945582 IND FXD 0805 EMI 100MHZ 300R R
3235 232270260101 RST SM 0603 RC21 100R PM5 R 3507 232270260101 RST SM 0603 RC21 100R PM5 R 5410 242254945582 IND FXD 0805 EMI 100MHZ 300R R
3236 232270260101 RST SM 0603 RC21 100R PM5 R 3508 232270260101 RST SM 0603 RC21 100R PM5 R 5411 242254945582 IND FXD 0805 EMI 100MHZ 300R R
3237 232270260101 RST SM 0603 RC21 100R PM5 R 3509 232270260221 RST SM 0603 RC21 220R PM5 R 5412 242254945582 IND FXD 0805 EMI 100MHZ 300R R
3238 232270260101 RST SM 0603 RC21 100R PM5 R 3510 232270260103 RST SM 0603 RC21 10K PM5 R 5414 242254945582 IND FXD 0805 EMI 100MHZ 300R R
3239 232270260101 RST SM 0603 RC21 100R PM5 R 3511 232270260101 RST SM 0603 RC21 100R PM5 R 5501 242254945579 IND FXD 1206 EMI 100MHZ 100R R
3240 232270260101 RST SM 0603 RC21 100R PM5 R 3512 232270260103 RST SM 0603 RC21 10K PM5 R 5502 242254945579 IND FXD 1206 EMI 100MHZ 100R R
3241 212211805661 RST SM 0603 RC0603 2K2 PM5 R 3514 232270260103 RST SM 0603 RC21 10K PM5 R 5701 242254945579 IND FXD 1206 EMI 100MHZ 100R R
3242 212211805661 RST SM 0603 RC0603 2K2 PM5 R 3515 232270260103 RST SM 0603 RC21 10K PM5 R 5702 242254945579 IND FXD 1206 EMI 100MHZ 100R R
3243 212211805964 RST SM 0603 RC0603 75R PM1 R 3516 232270260103 RST SM 0603 RC21 10K PM5 R 5703 242254945579 IND FXD 1206 EMI 100MHZ 100R R
3244 212211805638 RST SM 0603 RC0603 33R PM5 R 3517 212211805683 RST SM 0603 RC0603 100K PM5 R 5704 242254945579 IND FXD 1206 EMI 100MHZ 100R R
3247 232270260471 RST SM 0603 RC21 470R PM5 R 3518 232270260103 RST SM 0603 RC21 10K PM5 R 5705 242254945579 IND FXD 1206 EMI 100MHZ 100R R
3248 212211805964 RST SM 0603 RC0603 75R PM1 R 3519 232270260103 RST SM 0603 RC21 10K PM5 R 5706 242254945579 IND FXD 1206 EMI 100MHZ 100R R
3249 212211805638 RST SM 0603 RC0603 33R PM5 R 3520 232270260103 RST SM 0603 RC21 10K PM5 R 5707 242254945579 IND FXD 1206 EMI 100MHZ 100R R
3251 212211805641 RST SM 0603 RC0603 68R PM5 R 3521 212211805683 RST SM 0603 RC0603 100K PM5 R
3522 232270260103 RST SM 0603 RC21 10K PM5 R
5708 242254945579 IND FXD 1206 EMI 100MHZ 100R R 3634 232270260202 RST SM 0603 RC21 2K PM5 R 2808 223891015649 CER2 0805 X7R 25V 100N PM10 R
5710 242254945579 IND FXD 1206 EMI 100MHZ 100R R 3681 212211805672 RST SM 0603 RC0603 15K PM5 R 2809 202203100068 ELCAP GL 25V S 470U PM20 B
5711 242254945579 IND FXD 1206 EMI 100MHZ 100R R 3682 212211805683 RST SM 0603 RC0603 100K PM5 R 2811 202203100068 ELCAP GL 25V S 470U PM20 B
5712 313818875691 COI CHOKE 35UH 82M OHM DR10X8 3683 212211805672 RST SM 0603 RC0603 15K PM5 R 2812 223858015645 CER2 0805 X7R 50V 47N PM10 R
3685 212211805672 RST SM 0603 RC0603 15K PM5 R 2813 223886115471 CER1 0805 NP0 50V 470P PM5 R
6201 933913910115 DIO SIG SM BAS32L (PHSE) R 3687 212211805672 RST SM 0603 RC0603 15K PM5 R 2814 223858015635 CER2 0805 X7R 50V 8N2 PM10 R
6202 933913910115 DIO SIG SM BAS32L (PHSE) R 3689 212211805672 RST SM 0603 RC0603 15K PM5 R 2815 223858015645 CER2 0805 X7R 50V 47N PM10 R
6203 933913910115 DIO SIG SM BAS32L (PHSE) R 3691 212211805672 RST SM 0603 RC0603 15K PM5 R 2816 223878019858 CER2 0805 Y5V 16V 470N P8020 R
6204 933913910115 DIO SIG SM BAS32L (PHSE) R 3692 212211805672 RST SM 0603 RC0603 15K PM5 R 2817 222278115663 CER2 1206 X7R 16V 1U PM10 R
6401 932220675682 DIO REC M100AL-5301-E3 (VISH)B 3693 212211805672 RST SM 0603 RC0603 15K PM5 R 2818 222278115663 CER2 1206 X7R 16V 1U PM10 R
6402 932220675682 DIO REC M100AL-5301-E3 (VISH)B 4631 232270296001 RST SM 0603 JUMP. MAX 0R05 R 2819 222278115663 CER2 1206 X7R 16V 1U PM10 R
6403 933957760673 DIO REC SB140-E3 A (VISH) A 2820 222278115663 CER2 1206 X7R 16V 1U PM10 R
6502 932220675682 DIO REC M100AL-5301-E3 (VISH)B 5601 242254900126 IND FXD 0805 EMI 100MHZ 120R R 2821 222278115663 CER2 1206 X7R 16V 1U PM10 R
6503 932220675682 DIO REC M100AL-5301-E3 (VISH)B 5602 242254900126 IND FXD 0805 EMI 100MHZ 120R R 2822 222278115663 CER2 1206 X7R 16V 1U PM10 R
6504 932220675682 DIO REC M100AL-5301-E3 (VISH)B 5603 242254900126 IND FXD 0805 EMI 100MHZ 120R R 2823 202055890659 CER2 DC SL 3KV S 12P PM5 B
6701 932221745685 DIO REC SM SSA34-E3 (VISH) R 5621 242254900126 IND FXD 0805 EMI 100MHZ 120R R 2824 223858015641 CER2 0805 X7R 50V 22N PM10 R
5622 242254900126 IND FXD 0805 EMI 100MHZ 120R R 2825 222278019763 CER2 0805 Y5V 16V 1U PM20 R
7201 932220624668 IC SM M24C02-WMN6P (ST00) R 5634 313818875771 COI CHOKE 35UH 82M OHM DR10X8 2826 202055890659 CER2 DC SL 3KV S 12P PM5 B
7202 932220624668 IC SM M24C02-WMN6P (ST00) R 5651 242254900126 IND FXD 0805 EMI 100MHZ 120R R 2827 223858015641 CER2 0805 X7R 50V 22N PM10 R
7301 932222292671 IC SM K4D263238G-VC36 (SMGK) Y 5653 242254900126 IND FXD 0805 EMI 100MHZ 120R R 2828 222278019763 CER2 0805 Y5V 16V 1U PM20 R
7302 932216732668 IC SM LD1117S25 (ST00) R 5655 242254900126 IND FXD 0805 EMI 100MHZ 120R R 2829 202055890659 CER2 DC SL 3KV S 12P PM5 B
7351 313815865791 CPU ASSY 5657 242254900126 IND FXD 0805 EMI 100MHZ 120R R 2830 223858015641 CER2 0805 X7R 50V 22N PM10 R
7351 932222343682 IC SM NT68F631ALG (NOVA) L 5659 242254900126 IND FXD 0805 EMI 100MHZ 120R R 2831 222278019763 CER2 0805 Y5V 16V 1U PM20 R
7353 313815865801 EEPROM ASSY-LPL 2832 202055890659 CER2 DC SL 3KV S 12P PM5 B
7353 932218650682 IC AT24C16A-10PU-2.7 (ATME) L 6634 932221745685 DIO REC SM SSA34-E3 (VISH) R 2833 223858015641 CER2 0805 X7R 50V 22N PM10 R
7401 823827716351 SCALER IC 6635 932221745685 DIO REC SM SSA34-E3 (VISH) R 2834 222278019763 CER2 0805 Y5V 16V 1U PM20 R
7403 932220099685 IC SM LD1117AS18 (ST00) R 6662 933913910115 DIO SIG SM BAS32L (PHSE) R 2835 202055890659 CER2 DC SL 3KV S 12P PM5 B
7404 932216732668 IC SM LD1117S25 (ST00) R 2836 223858015641 CER2 0805 X7R 50V 22N PM10 R
7405 932214794668 IC SM LM1117MP-3.3 (NSC0) R 7622 932217440685 TRA SIG SM KRC102S (KEC0) R 2837 222278019763 CER2 0805 Y5V 16V 1U PM20 R
7501 932202312685 TRA SIG SM BC857C (RHM0) R 7625 932216638668 FET POW SM SI5441DC-E3 (VISH)R 2838 202055890659 CER2 DC SL 3KV S 12P PM5 B
7502 932202312685 TRA SIG SM BC857C (RHM0) R 7631 932222352668 IC SM TPS54357PWP (TI00) R 2839 223858015641 CER2 0805 X7R 50V 22N PM10 R
7503 932217440685 TRA SIG SM KRC102S (KEC0) R 7651 932222162671 IC SM CY7C65640-LFXC (CYPR) Y 2840 222278019763 CER2 0805 Y5V 16V 1U PM20 R
7504 932216638668 FET POW SM SI5441DC-E3 (VISH)R 7671 932222269668 IC SM TPS2062DG4 (TI00) R 2841 222278115663 CER2 1206 X7R 16V 1U PM10 R
7505 932214794668 IC SM LM1117MP-3.3 (NSC0) R 7675 932222269668 IC SM TPS2062DG4 (TI00) R 2842 222278115663 CER2 1206 X7R 16V 1U PM10 R
7506 932202312685 TRA SIG SM BC857C (RHM0) R 2844 223858015638 CER2 0805 X7R 50V 15N PM10 R
7507 932214794668 IC SM LM1117MP-3.3 (NSC0) R 1053 313815864501 CONTROL ASSY(200P7) 2845 222278019763 CER2 0805 Y5V 16V 1U PM20 R
7509 932217440685 TRA SIG SM KRC102S (KEC0) R 2846 223878019858 CER2 0805 Y5V 16V 470N P8020 R
7510 932216638668 FET POW SM SI5441DC-E3 (VISH)R 2951 223858615636 CER2 0603 X7R 50V 10N PM10 R
7511 932217440685 TRA SIG SM KRC102S (KEC0) R 2952 223858615636 CER2 0603 X7R 50V 10N PM10 R 3101 212261200059 NTC DC SCK-104 S 10R PM15 B
7512 932216638668 FET POW SM SI5441DC-E3 (VISH)R 2953 223858615636 CER2 0603 X7R 50V 10N PM10 R 3102 232271161474 RST SM 1206 RC01 470K PM5 R
7701 932223092671 IC SM PACIFIC3-N3(O2) (TOSJ) Y 3103 232271161824 RST SM 1206 RC01 820K PM5 R
7703 932214794668 IC SM LM1117MP-3.3 (NSC0) R 3952 232270260473 RST SM 0603 RC21 47K PM5 R 3104 232271161474 RST SM 1206 RC01 470K PM5 R
7705 932223257668 IC SM AT25F512AN-10SU-2.7(ATME 3953 232270260103 RST SM 0603 RC21 10K PM5 R 3105 213811205009 RST SM 0805 RC0805 1K PM1 R
7707 932216732668 IC SM LD1117S25 (ST00) R 3954 212211805656 RST SM 0603 RC0603 1K PM5 R 3106 232271161108 RST SM 1206 RC01 1R PM5 R
7708 932219076668 IC SM L5972D (ST00) R 3955 232270260473 RST SM 0603 RC21 47K PM5 R 3107 212211000315 RST MFLM MF1/2WS A 10R PM1 A
3956 232270260103 RST SM 0603 RC21 10K PM5 R 3109 232273061123 RST SM 0805 RC11 12K PM5 R
1052 313815865831 USB ASSY(200P7)
3957 212211805656 RST SM 0603 RC0603 1K PM5 R 3110 213811201103 RST SM 0805 RC05 10K PM5 R
3111 212211000403 RST MFLM MF1/2WS A 56K PM1 A
2601 223878615649 CER2 0603 X7R 16V 100N PM10 R
6951 932214603682 LED VS L-3WYGW (KIEL) B 3112 213811201473 RST SM 0805 RC05 47K PM5 R
2603 202203100179 ELCAP SM HV 25V 10U PM20 R
6952 932219382682 LED VS L-3WSYKPBW (KIEL) B 3113 213811201473 RST SM 0805 RC05 47K PM5 R
2604 223858619812 CER2 0603 Y5V 50V 100N P8020 R
3114 213811201472 RST SM 0805 RC05 4K7 PM5 R
2621 223878615649 CER2 0603 X7R 16V 100N PM10 R
1055 313815866501 POWER ASSY 3115 213811273472 RST CRB CFR-25 A 4K7 PM5 A
2623 223858615636 CER2 0603 X7R 50V 10N PM10 R
3116 231291512204 RST MFLM MBB0207 A 220K PM1 A
2625 222224119876 CER2 1206 Y5V 10V 10U P8020 R
2101 203830100314 CAP MPP 275V S 220N PM10 B 3117 212010593631 RST MOX 1W RSS S 0R22 PM5 B
2631 202202000963 ELCAP SM LV 25V 100U PM20 R
2102 202055490158 CERSAF CD 250V S 2N2 PM20 B 3119 212255000184 VDR DC 1MA/510V S MAX 845V R
2633 223878615649 CER2 0603 X7R 16V 100N PM10 R
2103 202055490158 CERSAF CD 250V S 2N2 PM20 B 3120 231291512204 RST MFLM MBB0207 A 220K PM1 A
2634 202202000963 ELCAP SM LV 25V 100U PM20 R
2106 202203100051 ELCAP RGA 450V S 120U PM20 B 3122 213811201471 RST SM 0805 RC05 470R PM5 R
2635 223878615643 CER2 0603 X7R 16V 33N PM10 R
2107 223858015641 CER2 0805 X7R 50V 22N PM10 R 3128 232271161109 RST SM 1206 RC01 10R PM5 R
2636 222278015663 CER2 0805 X7R 16V 1U PM10 R
2108 222291019856 CER2 0805 Y5V 25V 330N P8020 R 3132 213811201473 RST SM 0805 RC05 47K PM5 R
2651 202001293803 ELCAP SM RV2 16V 100U PM20 R
2109 225260108026 CER2 DC X7R 1KV S 1N PM10 A 3133 213811201683 RST SM 0805 RC05 68K PM5 R
2652 223878615649 CER2 0603 X7R 16V 100N PM10 R
2110 222291019863 CER2 0805 Y5V 25V 1U P8020 R 3141 232271161109 RST SM 1206 RC01 10R PM5 R
2655 202001293803 ELCAP SM RV2 16V 100U PM20 R
2112 203803527304 ELCAP KM 25V S 100U PM20 A 3142 232271161109 RST SM 1206 RC01 10R PM5 R
2656 223878615649 CER2 0603 X7R 16V 100N PM10 R
2113 203803513704 ELCAP RGA 100V S 22U PM20 A 3144 213811201103 RST SM 0805 RC05 10K PM5 R
2661 202001293803 ELCAP SM RV2 16V 100U PM20 R
2125 202055490158 CERSAF CD 250V S 2N2 PM20 B 3145 232271161109 RST SM 1206 RC01 10R PM5 R
2662 223878615649 CER2 0603 X7R 16V 100N PM10 R
2141 225260108026 CER2 DC X7R 1KV S 1N PM10 A 3146 232271161109 RST SM 1206 RC01 10R PM5 R
2665 202001293803 ELCAP SM RV2 16V 100U PM20 R
2142 202203100132 ELCAP LZ 25V S 1000U PM20 B 3151 213811201103 RST SM 0805 RC05 10K PM5 R
2666 223878615649 CER2 0603 X7R 16V 100N PM10 R
2143 202203100132 ELCAP LZ 25V S 1000U PM20 B 3152 232273462492 RST SM 0805 RC12H 2K49 PM1 R
2671 223878615649 CER2 0603 X7R 16V 100N PM10 R
2144 202203100132 ELCAP LZ 25V S 1000U PM20 B 3153 212211000354 RST MFLM MF1/2WS A 820R PM1 A
2675 223878615649 CER2 0603 X7R 16V 100N PM10 R
2145 225260108026 CER2 DC X7R 1KV S 1N PM10 A 3154 232273061513 RST SM 0805 RC11 51K PM5 R
2680 223878615649 CER2 0603 X7R 16V 100N PM10 R
2146 202203100128 ELCAP LZ 16V S 1000U PM20 A 3155 232273463602 RST SM 0805 RC12H 3K6 PM1 R
2681 223878615649 CER2 0603 X7R 16V 100N PM10 R
2151 223886115561 CER1 0805 NP0 50V 560P PM5 R 3156 232273061109 RST SM 0805 RC11 10R PM5 R
2682 223886715279 CER1 0603 NP0 50V 27P PM5 R
2152 223858015638 CER2 0805 X7R 50V 15N PM10 R 3157 232273061109 RST SM 0805 RC11 10R PM5 R
2683 223886715279 CER1 0603 NP0 50V 27P PM5 R
2158 222291019856 CER2 0805 Y5V 25V 330N P8020 R 3158 213811201103 RST SM 0805 RC05 10K PM5 R
2684 223878615649 CER2 0603 X7R 16V 100N PM10 R
2171 222291019863 CER2 0805 Y5V 25V 1U P8020 R 3161 232270296001 RST SM 0603 JUMP. MAX 0R05 R
2685 223878615649 CER2 0603 X7R 16V 100N PM10 R
2172 202203100068 ELCAP GL 25V S 470U PM20 B 3171 212211000304 RST MFLM MF1/2WS A 2R2 PM1 A
2691 223878615649 CER2 0603 X7R 16V 100N PM10 R
2175 222291019863 CER2 0805 Y5V 25V 1U P8020 R 3176 213811201471 RST SM 0805 RC05 470R PM5 R
2692 223878615649 CER2 0603 X7R 16V 100N PM10 R
2176 202203100216 ELCAP RGA 16V S 220U PM20 A 3801 213811201103 RST SM 0805 RC05 10K PM5 R
2693 223878615649 CER2 0603 X7R 16V 100N PM10 R
2801 222278019763 CER2 0805 Y5V 16V 1U PM20 R 3802 213811201229 RST SM 0805 RC05 22R PM5 R
2694 223878615649 CER2 0603 X7R 16V 100N PM10 R
2802 222278019865 CER2 0805 Y5V 16V 1U5 P8020 R 3803 213810113623 RST CRB CFR-12 A 62K PM5 A
2695 223878615649 CER2 0603 X7R 16V 100N PM10 R
2803 223878019858 CER2 0805 Y5V 16V 470N P8020 R 3804 232273061105 RST SM 0805 RC11 1M PM5 R
2696 223878615649 CER2 0603 X7R 16V 100N PM10 R
2804 222291019863 CER2 0805 Y5V 25V 1U P8020 R 3805 213811273563 RST CRB CFR-25 A 56K PM5 A
2697 223878615649 CER2 0603 X7R 16V 100N PM10 R
2805 223891015649 CER2 0805 X7R 25V 100N PM10 R 3806 212211000412 RST MFLM MF1/2WS A 120K PM1 A
2698 223878615649 CER2 0603 X7R 16V 100N PM10 R
2806 223858015636 CER2 0805 X7R 50V 10N PM10 R 3807 231291511003 RST MFLM MBB0207 A 10K PM1 A
2699 223878615649 CER2 0603 X7R 16V 100N PM10 R
2807 223858015625 CER2 0805 X7R 50V 1N5 PM10 R 3808 213811201103 RST SM 0805 RC05 10K PM5 R
3809 213811201103 RST SM 0805 RC05 10K PM5 R
3622 232270260103 RST SM 0603 RC21 10K PM5 R
3623 212211805683 RST SM 0603 RC0603 100K PM5 R
Go to cover page
3810 232273463303 RST SM 0805 RC12H 33K PM1 R 6810 932205042685 DIO SIG SM BAV99LG (ONSE) R
3811 232273461003 RST SM 0805 RC12H 10K PM1 R 6811 932205042685 DIO SIG SM BAV99LG (ONSE) R
3812 213811201103 RST SM 0805 RC05 10K PM5 R 6812 932205042685 DIO SIG SM BAV99LG (ONSE) R
3813 213810113109 RST CRB CFR-12 A 10R PM5 A 6813 932205042685 DIO SIG SM BAV99LG (ONSE) R
3814 213810113109 RST CRB CFR-12 A 10R PM5 A 6814 932205042685 DIO SIG SM BAV99LG (ONSE) R
3815 213810113109 RST CRB CFR-12 A 10R PM5 A 6815 932205042685 DIO SIG SM BAV99LG (ONSE) R
3816 213810113109 RST CRB CFR-12 A 10R PM5 A 6816 932205042685 DIO SIG SM BAV99LG (ONSE) R
3817 213810113109 RST CRB CFR-12 A 10R PM5 A 6817 933913910115 DIO SIG SM BAS32L (PHSE) R
3818 213810113109 RST CRB CFR-12 A 10R PM5 A 6818 933913910115 DIO SIG SM BAS32L (PHSE) R
3819 213810113109 RST CRB CFR-12 A 10R PM5 A 6819 933913910115 DIO SIG SM BAS32L (PHSE) R
3820 213810113109 RST CRB CFR-12 A 10R PM5 A 6820 933913910115 DIO SIG SM BAS32L (PHSE) R
3821 232273061225 RST SM 0805 RC11 2M2 PM5 R 6821 933913910115 DIO SIG SM BAS32L (PHSE) R
3822 232273061561 RST SM 0805 RC11 560R PM5 R 6822 933913910115 DIO SIG SM BAS32L (PHSE) R
3823 232273061561 RST SM 0805 RC11 560R PM5 R 6825 933166820133 DIO REG BZX79 B5V6 A (PHSE) A
3824 232273061561 RST SM 0805 RC11 560R PM5 R
3825 232273061561 RST SM 0805 RC11 560R PM5 R 7101 935270037112 IC TEA1533AP/N1 (PHSE) L
3826 232273061561 RST SM 0805 RC11 560R PM5 R 7102 932217427687 FET POW FQPF7N80 (FSC0) L
3827 232273061561 RST SM 0805 RC11 560R PM5 R 7103 932216831676 TRA SIG BC337-40 (KEC0) A
3828 232273061474 RST SM 0805 RC11 470K PM5 R 7105 932214014667 OPT CP TCET1103(G) (VISH) L
3829 232273061331 RST SM 0805 RC11 330R PM5 R 7107 933589600215 TRA SIG SM BC847C (PHSE) R
3830 232273061474 RST SM 0805 RC11 470K PM5 R 7108 933589600215 TRA SIG SM BC847C (PHSE) R
3831 232273061331 RST SM 0805 RC11 330R PM5 R 7151 933771100686 IC TL431CLPG S (ONSE) R
3832 232273061474 RST SM 0805 RC11 470K PM5 R 7158 933826850126 THYRIS BT169B (PHSE) A
3833 232273061331 RST SM 0805 RC11 330R PM5 R 7801 932219312668 IC SM OZ960G (O2MI) R
3834 232273061474 RST SM 0805 RC11 470K PM5 R 7802 932219871668 FET POW SM FDS8958A (FSC0) R
3835 232273061331 RST SM 0805 RC11 330R PM5 R 7803 932219871668 FET POW SM FDS8958A (FSC0) R
3836 232273061474 RST SM 0805 RC11 470K PM5 R 7804 932219871668 FET POW SM FDS8958A (FSC0) R
3837 232273061331 RST SM 0805 RC11 330R PM5 R 7805 932219871668 FET POW SM FDS8958A (FSC0) R
3838 232273061474 RST SM 0805 RC11 470K PM5 R 7806 932215686685 FET SIG SM 2N7002LG (ONSE) R
3839 232273061331 RST SM 0805 RC11 330R PM5 R 7807 933864360215 TRA SIG SM MMBT3904 (PHSE) R
3842 213811201182 RST SM 0805 RC05 1K8 PM5 R 7808 933864360215 TRA SIG SM MMBT3904 (PHSE) R
3843 213811201182 RST SM 0805 RC05 1K8 PM5 R 7809 933864360215 TRA SIG SM MMBT3904 (PHSE) R
3845 212211000409 RST MFLM MF1/2WS A 100K PM1 A 7810 933864360215 TRA SIG SM MMBT3904 (PHSE) R
3846 213811201124 RST SM 0805 RC05 120K PM5 R 7811 933864360215 TRA SIG SM MMBT3904 (PHSE) R
3847 213810113512 RST CRB CFR-12 A 5K1 PM5 A 7812 933864360215 TRA SIG SM MMBT3904 (PHSE) R
3848 213811201202 RST SM 0805 RC05 2K PM5 R 7813 934044130115 TRA SIG SM PDTA144EU (PHSE) R
3849 213811201182 RST SM 0805 RC05 1K8 PM5 R 7814 933864360215 TRA SIG SM MMBT3904 (PHSE) R
3850 232271191032 RST SM 1206 JUMP. MAX 0R05 R 7815 933864360215 TRA SIG SM MMBT3904 (PHSE) R
3851 232271191032 RST SM 1206 JUMP. MAX 0R05 R
3853 232271191032 RST SM 1206 JUMP. MAX 0R05 R
3854 232271191032 RST SM 1206 JUMP. MAX 0R05 R
3855 232271191032 RST SM 1206 JUMP. MAX 0R05 R
3871 213811201102 RST SM 0805 RC05 1K PM5 R
3872 213811201102 RST SM 0805 RC05 1K PM5 R
3873 213811201102 RST SM 0805 RC05 1K PM5 R
3874 213811201102 RST SM 0805 RC05 1K PM5 R
3875 213811201102 RST SM 0805 RC05 1K PM5 R
3876 213811201102 RST SM 0805 RC05 1K PM5 R
Diversity of 200P7EB/00 compared with 200P7ES/00(LPL PANEL 1608 823827732071 CABLE RING TERM/45/FAST AWG18 3501 232270260103 RST SM 0603 RC21 10K PM5 R
Item 12NC Description 2537 223878615649 CER2 0603 X7R 16V 100N PM10 R 3525 232270260223 RST SM 0603 RC21 22K PM5 R
863900016917 200P7EB/00 3117 212010590704 RST MOX 1W RSS A 0R22 PM5 A 3527 232270260221 RST SM 0603 RC21 220R PM5 R
0004 313815761041 SUPER ERGO BASE ASSY 3229 212211805665 RST SM 0603 RC0603 4K7 PM5 R 3535 232270260223 RST SM 0603 RC21 22K PM5 R
0030 313815761021 BEZEL ASSY 3230 212211805665 RST SM 0603 RC0603 4K7 PM5 R 3702 232270296001 RST SM 0603 JUMP. MAX 0R05 R
0031 313815417841 BEZEL 3306 232270260101 RST SM 0603 RC21 100R PM5 R 3734 232270260479 RST SM 0603 RC21 47R PM5 R
0032 313815417831 BEZEL - DECO 3307 232270260101 RST SM 0603 RC21 100R PM5 R 3848 213811201332 RST SM 0805 RC05 3K3 PM5 R
0033 313815417851 CONTROL KNOB 3308 232270260101 RST SM 0603 RC21 100R PM5 R 4205 212211805637 RST SM 0603 RC0603 22R PM5 R
0040 313815761031 BACK COVER ASSY 3309 232270260101 RST SM 0603 RC21 100R PM5 R 4206 212211805637 RST SM 0603 RC0603 22R PM5 R
0041 313815417871 BACK COVER 3310 232270260101 RST SM 0603 RC21 100R PM5 R 4207 212211805637 RST SM 0603 RC0603 22R PM5 R
0042 313815417861 MIDDLE COVER 3311 232270260101 RST SM 0603 RC21 100R PM5 R 5104 313816872621 BEAD COIL (BF30TA-2.5X3X1B)
0126 313815569021 RATING LABEL 3312 232270260101 RST SM 0603 RC21 100R PM5 R 6111 932221086673 DIO REC BYV26EGP A (GULF) A
0140 313800991371 PROCESS BOX 3313 232270260101 RST SM 0603 RC21 100R PM5 R 6145 932219932687 DIO REC STPS10H100CFP (ST00) L
0300 282206240595 INK CARTRIDGE -EP-T 3314 235003510101 RST NETW SM ARV24 4X100R PM5 R 6402 933957760673 DIO REC SB140-E3 A (VISH) A
Diversity of 200P7EB/27 compared with 200P7ES/00(LPL PANEL 3315 235003510101 RST NETW SM ARV24 4X100R PM5 R 8061 823827732073 CBLE-024 14/480/8+6-018+016
Item 12NC Description 3316 235003510101 RST NETW SM ARV24 4X100R PM5 R
863900016918 200P7EB/27 3317 235003510101 RST NETW SM ARV24 4X100R PM5 R
0004 313815761041 SUPER ERGO BASE ASSY 3318 235003510101 RST NETW SM ARV24 4X100R PM5 R Diversity of 200P7MG/00(LPL) compared with 200P7ES/00(LPL)
0030 313815761021 BEZEL ASSY 3319 235003510101 RST NETW SM ARV24 4X100R PM5 R
0031 313815417841 BEZEL 3320 235003510101 RST NETW SM ARV24 4X100R PM5 R Item 12NC Description
0032 313815417831 BEZEL - DECO 3321 235003510101 RST NETW SM ARV24 4X100R PM5 R 863900016914 200P7MG/00
0033 313815417851 CONTROL KNOB 3414 232270260122 RST SM 0603 RC21 1K2 PM5 R 0004 313815761091 SUPER ERGO BASE ASSY(T)
0040 313815761031 BACK COVER ASSY 3501 232270260103 RST SM 0603 RC21 10K PM5 R 0030 313815761071 FRONT BEZEL ASSY(T)
0041 313815417871 BACK COVER 3525 232270260223 RST SM 0603 RC21 22K PM5 R 0031 313815417901 BEZEL(T)
0042 313815417861 MIDDLE COVER 3527 232270260221 RST SM 0603 RC21 220R PM5 R 0032 313815417911 BEZEL DECO.(T)
0126 313815569031 RATING LABEL 3535 232270260223 RST SM 0603 RC21 22K PM5 R 0033 313815417921 CONTROL BUTTON(T)
0140 313800991371 PROCESS BOX 3702 232270296001 RST SM 0603 JUMP. MAX 0R05 R 0034 313815417712 OSD INSULATE PLATE
0291 313815569041 LABEL-CPU(LPL) 3734 232270260479 RST SM 0603 RC21 47R PM5 R 0035 313815418071 OSD OPAQUE PLATE
0292 313815569041 LABEL-CPU(LPL) 3848 213811201332 RST SM 0805 RC05 3K3 PM5 R 0040 313815761081 BACK COVER ASSY(T)
0300 282206240595 INK CARTRIDGE -EP-T 4205 212211805637 RST SM 0603 RC0603 22R PM5 R 0041 313815417931 BACK COVER(T)
0615 313811709311 HEX CODE OF F/W (NO MATL REQ) 4206 212211805637 RST SM 0603 RC0603 22R PM5 R 0042 313815417941 MIDDLE COVER(T)
1051 313815867121 SCALER ASSY(US) 4207 212211805637 RST SM 0603 RC0603 22R PM5 R 0116 313810440571 HOUSING COVER
1061 313818870491 MAINSCORD UL 10A 1M8 DET BK 5104 313816872621 BEAD COIL (BF30TA-2.5X3X1B) 0126 313815569881 RATING LABEL
1062 242203300265 CON ACC ADP V 15P F MA-002 B 6111 932221086673 DIO REC BYV26EGP A (GULF) A 0210 313800992041 PROCESS BOX
7351 313815867131 CPU IC ASSY(US) 6145 932219932687 DIO REC STPS10H100CFP (ST00) L 0214 313810164871 EYELET HOLES 1.9
7353 313815867141 EEPROM IC ASSY(US) 6402 933957760673 DIO REC SB140-E3 A (VISH) A 0326 313815131561 HEAT SINK
Diversity of 200P7EB/75 compared with 200P7ES/00(LPL PANEL 7351 313815867161 CPU IC ASSY(AU) 0451 313815641492 CUSHION - TOP
Item 12NC Description 7353 313815867171 EEPROM IC ASSY(AU) 0452 313815641502 CUSHION - BOTTOM
863900016939 200P7EB/75 8061 823827732073 CBLE-024 14/480/8+6-018+016 0602 313811709681 E-D.F.U.
0004 313815761041 SUPER ERGO BASE ASSY Diversity of 200P7EG/00 compared with 200P7ES/00(LPL PANEL 1050 823827720831 LCD LM201U04-SL06
0030 313815761021 BEZEL ASSY Item 12NC Description 1052 313815865832 USB ASSY(200P7)
0031 313815417841 BEZEL 863900017084 200P7EG/00 1055 313815867091 POWER ASSY-200P7 MEDICAL
0032 313815417831 BEZEL - DECO 0004 313815761091 SUPER ERGO BASE ASSY(T) 1057 313815865812 METAL FRAME+WIRE ASSY
0033 313815417851 CONTROL KNOB 0030 313815761071 FRONT BEZEL ASSY(T) 1063 313819872531 CORD USB A/1M8/USB B BK
0040 313815761031 BACK COVER ASSY 0031 313815417901 BEZEL(T) 1102 823827732016 CBLE-921 11/70/11-021 AWG26
0041 313815417871 BACK COVER 0032 313815417911 BEZEL DECO.(T) 1104 242208610239 FUSE 5X20 HT 3A15 250V IEC B
0042 313815417861 MIDDLE COVER 0033 313815417921 CONTROL BUTTON(T) 1191 313815867101 DIODE ASSY
0126 313815569051 RATING LABEL 0035 313815418071 OSD OPAQUE PLATE 1608 823827732071 CABLE RING TERM/45/FAST AWG18
0291 313815569061 LABEL-CPU(LPL) 0040 313815761081 BACK COVER ASSY(T) 2001 823827736064 CER2 1206 X7R 25V 2U2 PM10 R
0292 313815569061 LABEL-CPU(LPL) 0041 313815417931 BACK COVER(T) 2003 202203100134 ELCAP EB 10V S 820U PM20 B
0615 313811709351 HEX CODE OF F/W (NO MATL REQ) 0042 313815417941 MIDDLE COVER(T) 2004 223858015636 CER2 0805 X7R 50V 10N PM10 R
1051 313815867151 SCALER ASSY(AU) 0116 313810440571 HOUSING COVER 2051 202203100068 ELCAP GL 25V S 470U PM20 B
1061 313819872931 MAINSCORD AUS/NZ 10A 1M8 BK 0126 313815569731 RATING LABEL 2054 222291019863 CER2 0805 Y5V 25V 1U P8020 R
7351 313815867161 CPU IC ASSY(AU) 0130 313815569641 ENERGY STAR LABEL 2056 222291019863 CER2 0805 Y5V 25V 1U P8020 R
7353 313815867171 EEPROM IC ASSY(AU) 0290 313800990591 PROCESS BOX 2105 203830200203 CAP MPOL 630V S 47N PM10 B
Diversity of 200P7EB/93 compared with 200P7ES/00(LPL PANEL 0451 313815641492 CUSHION - TOP 2115 225260108026 CER2 DC X7R 1KV S 1N PM10 A
Item 12NC Description 0452 313815641502 CUSHION - BOTTOM 2116 202203100132 ELCAP LZ 25V S 1000U PM20 B
863900017102 200P7EB/93 1052 313815865832 USB ASSY(200P7) 2117 202203100333 ELCAP LZ 25V S 1000U PM20 B
0004 313815761041 SUPER ERGO BASE ASSY 1055 313815866502 POWER ASSY 2118 202203100132 ELCAP LZ 25V S 1000U PM20 B
0030 313815761301 FRONT BEZEL ASSY(B) 1057 313815865812 METAL FRAME+WIRE ASSY 2122 223886115561 CER1 0805 NP0 50V 560P PM5 R
0031 313815417841 BEZEL 1060 313819871461 CORD SUB-D 15/1M8/SUB-D 15 GY 2123 223858015634 CER2 0805 X7R 50V 6N8 PM10 R
0032 313815417831 BEZEL - DECO 1061 313818870461 MAINSCORD IEC 10A 1M8 DET TDS
2124 223858015641 CER2 0805 X7R 50V 22N PM10 R
0033 313815417851 CONTROL KNOB 1064 313819871501 CORD DVI 18+1/1M8/DVI 18+1 GY
2126 202055490158 CERSAF CD 250V S 2N2 PM20 B
0035 313815418071 OSD OPAQUE PLATE 1608 823827732071 CABLE RING TERM/45/FAST AWG18
2537 223878615649 CER2 0603 X7R 16V 100N PM10 R
0040 313815761031 BACK COVER ASSY 2537 223878615649 CER2 0603 X7R 16V 100N PM10 R
2809 823827736056 ELCAP TH 25V S 470U PM20B
0041 313815417871 BACK COVER 3117 212010590704 RST MOX 1W RSS A 0R22 PM5 A
2811 823827736056 ELCAP TH 25V S 470U PM20B
0042 313815417861 MIDDLE COVER 3229 212211805665 RST SM 0603 RC0603 4K7 PM5 R
2847 222278019763 CER2 0805 Y5V 16V 1U PM20 R
0116 313810440571 HOUSING COVER 3230 212211805665 RST SM 0603 RC0603 4K7 PM5 R
2848 223858015636 CER2 0805 X7R 50V 10N PM10 R
0130 313815569641 ENERGY STAR LABEL 3306 232270260101 RST SM 0603 RC21 100R PM5 R
2849 222278019763 CER2 0805 Y5V 16V 1U PM20 R
0133 313810539241 PASS CARD LABEL 3307 232270260101 RST SM 0603 RC21 100R PM5 R
2850 223858015636 CER2 0805 X7R 50V 10N PM10 R
0134 313810541222 QUALITY ASSURANCE CARD 3308 232270260101 RST SM 0603 RC21 100R PM5 R
2851 222278019763 CER2 0805 Y5V 16V 1U PM20 R
0290 313800990591 PROCESS BOX 3309 232270260101 RST SM 0603 RC21 100R PM5 R
2852 223858015636 CER2 0805 X7R 50V 10N PM10 R
0291 313815569061 LABEL-CPU(LPL) 3310 232270260101 RST SM 0603 RC21 100R PM5 R
2853 222278019763 CER2 0805 Y5V 16V 1U PM20 R
0292 313815569061 LABEL-CPU(LPL) 3311 232270260101 RST SM 0603 RC21 100R PM5 R
2854 223858015636 CER2 0805 X7R 50V 10N PM10 R
0450 313815642371 CARTON 3312 232270260101 RST SM 0603 RC21 100R PM5 R
2855 222278019763 CER2 0805 Y5V 16V 1U PM20 R
0451 313815641492 CUSHION - TOP 3313 232270260101 RST SM 0603 RC21 100R PM5 R
2856 223858015636 CER2 0805 X7R 50V 10N PM10 R
0452 313815641502 CUSHION - BOTTOM 3314 235003510101 RST NETW SM ARV24 4X100R PM5 R
2857 222278019763 CER2 0805 Y5V 16V 1U PM20 R
0508 313815642371 CARTON 3315 235003510101 RST NETW SM ARV24 4X100R PM5 R
2858 223858015636 CER2 0805 X7R 50V 10N PM10 R
0508 313815642371 CARTON 3316 235003510101 RST NETW SM ARV24 4X100R PM5 R
3002 232273463902 RST SM 0805 RC12H 3K9 PM1 R
0615 313811709351 HEX CODE OF F/W (NO MATL REQ) 3317 235003510101 RST NETW SM ARV24 4X100R PM5 R
3003 232273461203 RST SM 0805 RC12H 12K PM1 R
1051 313815867151 SCALER ASSY(AU) 3318 235003510101 RST NETW SM ARV24 4X100R PM5 R
3108 212261200059 NTC DC SCK-104 S 10R PM15 B
1052 313815865832 USB ASSY(200P7) 3319 235003510101 RST NETW SM ARV24 4X100R PM5 R
3113 232273061513 RST SM 0805 RC11 51K PM5 R
1055 313815866502 POWER ASSY 3320 235003510101 RST NETW SM ARV24 4X100R PM5 R
3117 212010590704 RST MOX 1W RSS A 0R22 PM5 A
1057 313815865812 METAL FRAME+WIRE ASSY 3321 235003510101 RST NETW SM ARV24 4X100R PM5 R
3119 213811201689 RST SM 0805 RC05 68R PM5 R
1061 313818871651 MAINSCORD CCEE 10A 1M8 DET BK 3414 232270260122 RST SM 0603 RC21 1K2 PM5 R
3121 212211000315 RST MFLM MF1/2WS A 10R PM1 A
According to the ECO-CA005956,Add QSG-ergo base and Jig on P.E. bag for 200P7,Following is the detail
1.Item 0129 Qty from 1to 2, and add new Item: 0142-313815524581- QUICK SET GUIDE-ERGO BASE
2.
REF 12NC Description
1 863900016914 200P7MG/00
2 863900016915 200P7MG/27
3 863900016916 200P7ES/00
4 863900016917 200P7EB/00
5 863900016918 200P7EB/27
6 863900016939 200P7EB/75
7 863900017084 200P7EG/00
8 863900017102 200P7EB/93
According to the ECO-CA005973, Customer Request and Solve the icon shift problem , following is the detail:
ALL New 2318 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2319 223878615649 CER2 0603 X7R 16V 100N PM10 R
REF 12NC Description ALL New 2320 223878615649 CER2 0603 X7R 16V 100N PM10 R
1 313815868041 SCALER ASSY ALL New 2321 223878615649 CER2 0603 X7R 16V 100N PM10 R
2 313815868071 SCALER ASSY ALL New 2322 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2323 223878615649 CER2 0603 X7R 16V 100N PM10 R
3 313815868101 Scaler Assy ALL New 2324 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2325 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2326 223878615649 CER2 0603 X7R 16V 100N PM10 R
REF Action Item 12NC Description ALL New 2327 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 1 313810362762 SCALER PCB ALL New 2328 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 171 313810600121 FAMILY SHEET- SERVICE ALL New 2329 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 172 313815550562 PRODUCT TRACEABILITY LABEL ALL New 2330 223858615636 CER2 0603 X7R 50V 10N PM10 R
ALL New 290 313800992071 PROCESS BOX ALL New 2332 823827736009 CHIP 4.7UF 25V X7R 1206
ALL New 1098 243803100435 SOC IC V 8P F 2.54 DIL L ALL New 2333 823827736009 CHIP 4.7UF 25V X7R 1206
ALL New 1201 242203300013 SOC DVI H 29P F DVI-I Y ALL New 2334 223878615649 CER2 0603 X7R 16V 100N PM10 R
242203300522 SOC DVI H 29P F 1.91DVI-I Y ALL New 2351 223878615649 CER2 0603 X7R 16V 100N PM10 R
242203300524 SOC DVI H 29P F 1.91DVI-I Y ALL New 2353 223886715229 CER1 0603 NP0 50V 22P PM5 R
ALL New 1202 242202518053 SOC SUBD H 15P F BU 1216 B ALL New 2354 223886715229 CER1 0603 NP0 50V 22P PM5 R
242202518065 SOC SUBD H 15P F BU 900 Y ALL New 2355 223886715101 CER1 0603 NP0 50V 100P PM5 R
242202518432 SOC SUBD H 15P F SBFR Y ALL New 2356 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 1351 243854300075 RES XTL SM 12MHZ 32P HC49/S R ALL New 2358 223886715101 CER1 0603 NP0 50V 100P PM5 R
243854300079 RES XTL SM 12MHZ 32P SMD-49 R ALL New 2359 823827736009 CHIP 4.7UF 25V X7R 1206
ALL New 1401 243854300086 RES XTL SM 14M318 18P HC49/S R ALL New 2360 223878615649 CER2 0603 X7R 16V 100N PM10 R
243854300093 RES XTL SM 14M3181 18P SMD49 R ALL New 2361 223886715101 CER1 0603 NP0 50V 100P PM5 R
ALL New 1501 242202518826 CON V 14P M 2.00 63394 B ALL New 2401 202203100205 ELCAP SM RVS 25V 47U PM20 R
ALL New 1505 313816872071 11P WAFER M242611(VERT) 202203100206 ELCAP SM HV 25V 47U PM20 R
ALL New 1701 242202518804 CON V 30P M 1.25 SM 60948 R ALL New 2402 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 1703 242254000017 RES CER SM 60MHZ CSTCW*X51 R ALL New 2403 823827736009 CHIP 4.7UF 25V X7R 1206
ALL New 1705 242202518816 CON V 4P M 2.00 63384 B ALL New 2404 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2201 223878615649 CER2 0603 X7R 16V 100N PM10 R ALL New 2405 823827736009 CHIP 4.7UF 25V X7R 1206
ALL New 2202 223878615649 CER2 0603 X7R 16V 100N PM10 R ALL New 2406 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2203 223886715331 CER1 0603 NP0 50V 330P PM5 R ALL New 2407 823827736009 CHIP 4.7UF 25V X7R 1206
ALL New 2204 223886715331 CER1 0603 NP0 50V 330P PM5 R ALL New 2408 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2205 223878615649 CER2 0603 X7R 16V 100N PM10 R ALL New 2409 823827736009 CHIP 4.7UF 25V X7R 1206
ALL New 2206 223878615645 CER2 0603 X7R 16V 47N PM10 R ALL New 2410 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2207 223878615645 CER2 0603 X7R 16V 47N PM10 R ALL New 2411 823827736009 CHIP 4.7UF 25V X7R 1206
ALL New 2208 223878615645 CER2 0603 X7R 16V 47N PM10 R ALL New 2412 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2209 223878615645 CER2 0603 X7R 16V 47N PM10 R ALL New 2413 202203100205 ELCAP SM RVS 25V 47U PM20 R
ALL New 2210 223878615645 CER2 0603 X7R 16V 47N PM10 R 202203100206 ELCAP SM HV 25V 47U PM20 R
ALL New 2211 223886715221 CER1 0603 NP0 50V 220P PM5 R ALL New 2414 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2212 223886715339 CER1 0603 NP0 50V 33P PM5 R ALL New 2415 823827736009 CHIP 4.7UF 25V X7R 1206
ALL New 2213 223878615645 CER2 0603 X7R 16V 47N PM10 R ALL New 2416 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2214 223878615649 CER2 0603 X7R 16V 100N PM10 R ALL New 2417 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2215 223886715331 CER1 0603 NP0 50V 330P PM5 R ALL New 2419 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2216 223886715331 CER1 0603 NP0 50V 330P PM5 R ALL New 2420 823827736009 CHIP 4.7UF 25V X7R 1206
ALL New 2217 223886715339 CER1 0603 NP0 50V 33P PM5 R ALL New 2421 823827736009 CHIP 4.7UF 25V X7R 1206
ALL New 2218 223886715221 CER1 0603 NP0 50V 220P PM5 R ALL New 2422 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2219 223878615649 CER2 0603 X7R 16V 100N PM10 R ALL New 2423 823827736009 CHIP 4.7UF 25V X7R 1206
ALL New 2221 223878615645 CER2 0603 X7R 16V 47N PM10 R ALL New 2424 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2222 223858615623 CER2 0603 X7R 50V 1N PM10 R ALL New 2425 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2224 223878615645 CER2 0603 X7R 16V 47N PM10 R ALL New 2426 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2225 223878615645 CER2 0603 X7R 16V 47N PM10 R ALL New 2427 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2227 223878615645 CER2 0603 X7R 16V 47N PM10 R ALL New 2428 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2228 223878615645 CER2 0603 X7R 16V 47N PM10 R ALL New 2429 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2229 223878615649 CER2 0603 X7R 16V 100N PM10 R ALL New 2430 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2236 223878615649 CER2 0603 X7R 16V 100N PM10 R ALL New 2431 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2240 223858615623 CER2 0603 X7R 50V 1N PM10 R ALL New 2432 823827736009 CHIP 4.7UF 25V X7R 1206
ALL New 2241 223878615645 CER2 0603 X7R 16V 47N PM10 R ALL New 2433 823827736009 CHIP 4.7UF 25V X7R 1206
ALL New 2302 223878615649 CER2 0603 X7R 16V 100N PM10 R ALL New 2434 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2303 202203100198 ELCAP SM HV 16V 22U PM20 R ALL New 2435 223878615649 CER2 0603 X7R 16V 100N PM10 R
202203100429 ELCAP SM RVL 16V 22U PM20 R ALL New 2436 823827736009 CHIP 4.7UF 25V X7R 1206
202203100431 ELCAP SM RVS 16V 22U PM20 R ALL New 2437 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2304 223878615649 CER2 0603 X7R 16V 100N PM10 R ALL New 2438 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2305 223878615649 CER2 0603 X7R 16V 100N PM10 R ALL New 2439 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2306 223878615649 CER2 0603 X7R 16V 100N PM10 R ALL New 2440 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2307 223878615649 CER2 0603 X7R 16V 100N PM10 R ALL New 2441 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2308 223878615649 CER2 0603 X7R 16V 100N PM10 R ALL New 2442 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2309 223878615649 CER2 0603 X7R 16V 100N PM10 R ALL New 2443 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2310 223878615649 CER2 0603 X7R 16V 100N PM10 R ALL New 2444 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2311 223878615649 CER2 0603 X7R 16V 100N PM10 R ALL New 2445 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2312 202203100198 ELCAP SM HV 16V 22U PM20 R ALL New 2446 223878615649 CER2 0603 X7R 16V 100N PM10 R
202203100429 ELCAP SM RVL 16V 22U PM20 R ALL New 2447 223886715339 CER1 0603 NP0 50V 33P PM5 R
202203100431 ELCAP SM RVS 16V 22U PM20 R ALL New 2448 223886715339 CER1 0603 NP0 50V 33P PM5 R
ALL New 2313 223878615649 CER2 0603 X7R 16V 100N PM10 R ALL New 2451 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2314 223878615649 CER2 0603 X7R 16V 100N PM10 R ALL New 2452 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2315 223878615649 CER2 0603 X7R 16V 100N PM10 R ALL New 2453 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 2316 223878615649 CER2 0603 X7R 16V 100N PM10 R ALL New 2454 223858615636 CER2 0603 X7R 50V 10N PM10 R
ALL New 2317 223878615649 CER2 0603 X7R 16V 100N PM10 R ALL New 2455 823827736009 CHIP 4.7UF 25V X7R 1206
ALL New 2456 823827736009 CHIP 4.7UF 25V X7R 1206
ALL New 2457 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 3202 212211805656 RST SM 0603 RC0603 1K PM5 R
ALL New 2501 223858619812 CER2 0603 Y5V 50V 100N P8020 R
232270260102 RST SM 0603 RC21 1K PM5 R
223891619849 CER2 0603 Y5V 25V 100N P8020 R
ALL New 3203 212211805656 RST SM 0603 RC0603 1K PM5 R
ALL New 2502 223858619812 CER2 0603 Y5V 50V 100N P8020 R
232270260102 RST SM 0603 RC21 1K PM5 R
223891619849 CER2 0603 Y5V 25V 100N P8020 R
ALL New 3207 212211805669 RST SM 0603 RC0603 10K PM5 R
ALL New 2503 202203100205 ELCAP SM RVS 25V 47U PM20 R
232270260103 RST SM 0603 RC21 10K PM5 R
202203100206 ELCAP SM HV 25V 47U PM20 R
ALL New 3208 212211805669 RST SM 0603 RC0603 10K PM5 R
ALL New 2504 223878615649 CER2 0603 X7R 16V 100N PM10 R
232270260103 RST SM 0603 RC21 10K PM5 R
ALL New 2505 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 3209 212211805669 RST SM 0603 RC0603 10K PM5 R
ALL New 2506 202203100205 ELCAP SM RVS 25V 47U PM20 R
232270260103 RST SM 0603 RC21 10K PM5 R
202203100206 ELCAP SM HV 25V 47U PM20 R
ALL New 3210 212211805674 RST SM 0603 RC0603 22K PM5 R
ALL New 2510 223878615649 CER2 0603 X7R 16V 100N PM10 R
232270260223 RST SM 0603 RC21 22K PM5 R
ALL New 2511 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 3211 212211805643 RST SM 0603 RC0603 100R PM5 R
ALL New 2515 223878615649 CER2 0603 X7R 16V 100N PM10 R
232270260101 RST SM 0603 RC21 100R PM5 R
ALL New 2516 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 3212 212211805643 RST SM 0603 RC0603 100R PM5 R
ALL New 2517 223878615649 CER2 0603 X7R 16V 100N PM10 R
232270260101 RST SM 0603 RC21 100R PM5 R
ALL New 2518 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 3213 212211805643 RST SM 0603 RC0603 100R PM5 R
ALL New 2519 223878615649 CER2 0603 X7R 16V 100N PM10 R
232270260101 RST SM 0603 RC21 100R PM5 R
ALL New 2520 223878615645 CER2 0603 X7R 16V 47N PM10 R
ALL New 3214 212211805643 RST SM 0603 RC0603 100R PM5 R
ALL New 2521 202203100205 ELCAP SM RVS 25V 47U PM20 R
232270260101 RST SM 0603 RC21 100R PM5 R
202203100206 ELCAP SM HV 25V 47U PM20 R
ALL New 3215 212211805643 RST SM 0603 RC0603 100R PM5 R
ALL New 2522 223878615649 CER2 0603 X7R 16V 100N PM10 R
232270260101 RST SM 0603 RC21 100R PM5 R
ALL New 2523 223858619812 CER2 0603 Y5V 50V 100N P8020 R
ALL New 3216 212211805641 RST SM 0603 RC0603 68R PM5 R
223891619849 CER2 0603 Y5V 25V 100N P8020 R
232270260689 RST SM 0603 RC21 68R PM5 R
ALL New 2524 823827736009 CHIP 4.7UF 25V X7R 1206
ALL New 3217 212211805964 RST SM 0603 RC0603 75R PM1 R
ALL New 2525 823827736009 CHIP 4.7UF 25V X7R 1206
232270467509 RST SM 0603 RC22H 75R PM1 R
ALL New 2526 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 3218 212211805641 RST SM 0603 RC0603 68R PM5 R
ALL New 2527 223878615649 CER2 0603 X7R 16V 100N PM10 R
232270260689 RST SM 0603 RC21 68R PM5 R
ALL New 2528 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 3219 212211805964 RST SM 0603 RC0603 75R PM1 R
ALL New 2529 823827736009 CHIP 4.7UF 25V X7R 1206
232270467509 RST SM 0603 RC22H 75R PM1 R
ALL New 2530 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 3220 212211805964 RST SM 0603 RC0603 75R PM1 R
ALL New 2531 823827736009 CHIP 4.7UF 25V X7R 1206
232270467509 RST SM 0603 RC22H 75R PM1 R
ALL New 2537 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 3221 212211805641 RST SM 0603 RC0603 68R PM5 R
ALL New 2538 223878615645 CER2 0603 X7R 16V 47N PM10 R
232270260689 RST SM 0603 RC21 68R PM5 R
ALL New 2701 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 3222 212211805661 RST SM 0603 RC0603 2K2 PM5 R
ALL New 2702 223878615649 CER2 0603 X7R 16V 100N PM10 R
232270260222 RST SM 0603 RC21 2K2 PM5 R
ALL New 2703 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 3223 212211805638 RST SM 0603 RC0603 33R PM5 R
ALL New 2704 223878615649 CER2 0603 X7R 16V 100N PM10 R
232270260339 RST SM 0603 RC21 33R PM5 R
ALL New 2705 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 3224 212211805638 RST SM 0603 RC0603 33R PM5 R
ALL New 2706 223878615649 CER2 0603 X7R 16V 100N PM10 R
232270260339 RST SM 0603 RC21 33R PM5 R
ALL New 2707 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 3225 212211805638 RST SM 0603 RC0603 33R PM5 R
ALL New 2708 223858619812 CER2 0603 Y5V 50V 100N P8020 R
232270260339 RST SM 0603 RC21 33R PM5 R
223891619849 CER2 0603 Y5V 25V 100N P8020 R
ALL New 3226 212211805652 RST SM 0603 RC0603 470R PM5 R
ALL New 2709 823827736009 CHIP 4.7UF 25V X7R 1206
232270260471 RST SM 0603 RC21 470R PM5 R
ALL New 2710 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 3227 212211805643 RST SM 0603 RC0603 100R PM5 R
ALL New 2711 223878615649 CER2 0603 X7R 16V 100N PM10 R
232270260101 RST SM 0603 RC21 100R PM5 R
ALL New 2712 823827736009 CHIP 4.7UF 25V X7R 1206
ALL New 3228 212211805661 RST SM 0603 RC0603 2K2 PM5 R
ALL New 2713 823827736009 CHIP 4.7UF 25V X7R 1206
232270260222 RST SM 0603 RC21 2K2 PM5 R
ALL New 2714 202203100205 ELCAP SM RVS 25V 47U PM20 R
ALL New 3229 212211805665 RST SM 0603 RC0603 4K7 PM5 R
202203100206 ELCAP SM HV 25V 47U PM20 R
232270260472 RST SM 0603 RC21 4K7 PM5 R
ALL New 2715 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 3230 212211805665 RST SM 0603 RC0603 4K7 PM5 R
ALL New 2716 223878615649 CER2 0603 X7R 16V 100N PM10 R
232270260472 RST SM 0603 RC21 4K7 PM5 R
ALL New 2717 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 3231 212211805641 RST SM 0603 RC0603 68R PM5 R
ALL New 2718 223878615649 CER2 0603 X7R 16V 100N PM10 R
232270260689 RST SM 0603 RC21 68R PM5 R
ALL New 2719 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 3233 212211805669 RST SM 0603 RC0603 10K PM5 R
ALL New 2720 223878615649 CER2 0603 X7R 16V 100N PM10 R
232270260103 RST SM 0603 RC21 10K PM5 R
ALL New 2721 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 3234 212211805674 RST SM 0603 RC0603 22K PM5 R
ALL New 2722 223878615649 CER2 0603 X7R 16V 100N PM10 R
232270260223 RST SM 0603 RC21 22K PM5 R
ALL New 2723 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 3235 212211805643 RST SM 0603 RC0603 100R PM5 R
ALL New 2724 823827736009 CHIP 4.7UF 25V X7R 1206
232270260101 RST SM 0603 RC21 100R PM5 R
ALL New 2725 202203100205 ELCAP SM RVS 25V 47U PM20 R
ALL New 3236 212211805643 RST SM 0603 RC0603 100R PM5 R
202203100206 ELCAP SM HV 25V 47U PM20 R
232270260101 RST SM 0603 RC21 100R PM5 R
ALL New 2726 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 3237 212211805643 RST SM 0603 RC0603 100R PM5 R
ALL New 2727 223878615649 CER2 0603 X7R 16V 100N PM10 R
232270260101 RST SM 0603 RC21 100R PM5 R
ALL New 2728 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 3238 212211805643 RST SM 0603 RC0603 100R PM5 R
ALL New 2729 223878615649 CER2 0603 X7R 16V 100N PM10 R
232270260101 RST SM 0603 RC21 100R PM5 R
ALL New 2730 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 3239 212211805643 RST SM 0603 RC0603 100R PM5 R
ALL New 2731 823827736009 CHIP 4.7UF 25V X7R 1206
232270260101 RST SM 0603 RC21 100R PM5 R
ALL New 2732 202203100205 ELCAP SM RVS 25V 47U PM20 R
ALL New 3240 212211805643 RST SM 0603 RC0603 100R PM5 R
202203100206 ELCAP SM HV 25V 47U PM20 R
232270260101 RST SM 0603 RC21 100R PM5 R
ALL New 2733 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 3241 212211805661 RST SM 0603 RC0603 2K2 PM5 R
ALL New 2734 223878615649 CER2 0603 X7R 16V 100N PM10 R
232270260222 RST SM 0603 RC21 2K2 PM5 R
ALL New 2737 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 3242 212211805661 RST SM 0603 RC0603 2K2 PM5 R
ALL New 2738 202203100173 ELCAP EB 25V S 470U PM20 B
232270260222 RST SM 0603 RC21 2K2 PM5 R
202203100181 ELCAP LZ 25V S 470U PM20 B
ALL New 3243 212211805964 RST SM 0603 RC0603 75R PM1 R
ALL New 2739 223858619812 CER2 0603 Y5V 50V 100N P8020 R
232270467509 RST SM 0603 RC22H 75R PM1 R
223891619849 CER2 0603 Y5V 25V 100N P8020 R
ALL New 3244 212211805638 RST SM 0603 RC0603 33R PM5 R
ALL New 2740 223858015614 CER2 0805 X7R 50V 220P PM10 R
232270260339 RST SM 0603 RC21 33R PM5 R
ALL New 2741 223858015641 CER2 0805 X7R 50V 22N PM10 R
ALL New 3247 212211805652 RST SM 0603 RC0603 470R PM5 R
ALL New 2742 223878615649 CER2 0603 X7R 16V 100N PM10 R
232270260471 RST SM 0603 RC21 470R PM5 R
ALL New 2743 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 3248 212211805964 RST SM 0603 RC0603 75R PM1 R
ALL New 2744 223878615649 CER2 0603 X7R 16V 100N PM10 R
232270467509 RST SM 0603 RC22H 75R PM1 R
ALL New 2745 223878615649 CER2 0603 X7R 16V 100N PM10 R
ALL New 3249 212211805638 RST SM 0603 RC0603 33R PM5 R
ALL New 3201 212211805669 RST SM 0603 RC0603 10K PM5 R
232270260339 RST SM 0603 RC21 33R PM5 R
232270260103 RST SM 0603 RC21 10K PM5 R
ALL New 3528 212211805643 RST SM 0603 RC0603 100R PM5 R ALL New 4503 212211805631 RST SM 0603 JUMP. MAX 0R05 R
232270260101 RST SM 0603 RC21 100R PM5 R 232270296001 RST SM 0603 JUMP. MAX 0R05 R
ALL New 3532 212211805669 RST SM 0603 RC0603 10K PM5 R ALL New 4508 212211805631 RST SM 0603 JUMP. MAX 0R05 R
232270260103 RST SM 0603 RC21 10K PM5 R 232270296001 RST SM 0603 JUMP. MAX 0R05 R
ALL New 3533 212211805669 RST SM 0603 RC0603 10K PM5 R ALL New 4510 212211805631 RST SM 0603 JUMP. MAX 0R05 R
232270260103 RST SM 0603 RC21 10K PM5 R 232270296001 RST SM 0603 JUMP. MAX 0R05 R
ALL New 3534 212211805669 RST SM 0603 RC0603 10K PM5 R ALL New 4703 213811291002 RST SM 0805 JUMP. MAX 0R05 R
232270260103 RST SM 0603 RC21 10K PM5 R 232273091002 RST SM 0805 JUMP. MAX 0R05 R
ALL New 3535 212211805674 RST SM 0603 RC0603 22K PM5 R ALL New 4708 212211805631 RST SM 0603 JUMP. MAX 0R05 R
232270260223 RST SM 0603 RC21 22K PM5 R 232270296001 RST SM 0603 JUMP. MAX 0R05 R
ALL New 3701 212211805689 RST SM 0603 RC0603 1M PM5 R ALL New 4709 212211805631 RST SM 0603 JUMP. MAX 0R05 R
232270260105 RST SM 0603 RC21 1M PM5 R 232270296001 RST SM 0603 JUMP. MAX 0R05 R
ALL New 3702 212211805631 RST SM 0603 JUMP. MAX 0R05 R ALL New 4710 212211805631 RST SM 0603 JUMP. MAX 0R05 R
232270296001 RST SM 0603 JUMP. MAX 0R05 R 232270296001 RST SM 0603 JUMP. MAX 0R05 R
ALL New 3703 212211805643 RST SM 0603 RC0603 100R PM5 R ALL New 4711 212211805631 RST SM 0603 JUMP. MAX 0R05 R
232270260101 RST SM 0603 RC21 100R PM5 R 232270296001 RST SM 0603 JUMP. MAX 0R05 R
ALL New 3704 212211805639 RST SM 0603 RC0603 47R PM5 R ALL New 4712 212211805631 RST SM 0603 JUMP. MAX 0R05 R
232270260479 RST SM 0603 RC21 47R PM5 R 232270296001 RST SM 0603 JUMP. MAX 0R05 R
ALL New 3705 212211805669 RST SM 0603 RC0603 10K PM5 R ALL New 5201 242254945582 IND FXD 0805 EMI 100MHZ 300R R
232270260103 RST SM 0603 RC21 10K PM5 R ALL New 5202 242254945582 IND FXD 0805 EMI 100MHZ 300R R
ALL New 3706 212211805643 RST SM 0603 RC0603 100R PM5 R ALL New 5203 242254945582 IND FXD 0805 EMI 100MHZ 300R R
232270260101 RST SM 0603 RC21 100R PM5 R ALL New 5204 242254945582 IND FXD 0805 EMI 100MHZ 300R R
ALL New 3707 212211805669 RST SM 0603 RC0603 10K PM5 R ALL New 5301 242254945582 IND FXD 0805 EMI 100MHZ 300R R
232270260103 RST SM 0603 RC21 10K PM5 R ALL New 5302 242254945582 IND FXD 0805 EMI 100MHZ 300R R
ALL New 3708 212211805643 RST SM 0603 RC0603 100R PM5 R ALL New 5351 242254945582 IND FXD 0805 EMI 100MHZ 300R R
232270260101 RST SM 0603 RC21 100R PM5 R ALL New 5401 242254945582 IND FXD 0805 EMI 100MHZ 300R R
ALL New 3710 212211805643 RST SM 0603 RC0603 100R PM5 R ALL New 5402 242254945582 IND FXD 0805 EMI 100MHZ 300R R
232270260101 RST SM 0603 RC21 100R PM5 R ALL New 5403 242254945582 IND FXD 0805 EMI 100MHZ 300R R
ALL New 3713 212211805669 RST SM 0603 RC0603 10K PM5 R ALL New 5404 242254945582 IND FXD 0805 EMI 100MHZ 300R R
232270260103 RST SM 0603 RC21 10K PM5 R ALL New 5405 242254945582 IND FXD 0805 EMI 100MHZ 300R R
ALL New 3714 212211805669 RST SM 0603 RC0603 10K PM5 R ALL New 5406 242254945582 IND FXD 0805 EMI 100MHZ 300R R
232270260103 RST SM 0603 RC21 10K PM5 R ALL New 5407 242254945582 IND FXD 0805 EMI 100MHZ 300R R
ALL New 3715 212211805643 RST SM 0603 RC0603 100R PM5 R ALL New 5409 242254945582 IND FXD 0805 EMI 100MHZ 300R R
232270260101 RST SM 0603 RC21 100R PM5 R ALL New 5410 242254945582 IND FXD 0805 EMI 100MHZ 300R R
ALL New 3716 212211805643 RST SM 0603 RC0603 100R PM5 R ALL New 5411 242254945582 IND FXD 0805 EMI 100MHZ 300R R
232270260101 RST SM 0603 RC21 100R PM5 R ALL New 5412 242254945582 IND FXD 0805 EMI 100MHZ 300R R
ALL New 3717 212211805643 RST SM 0603 RC0603 100R PM5 R ALL New 5414 242254945582 IND FXD 0805 EMI 100MHZ 300R R
232270260101 RST SM 0603 RC21 100R PM5 R ALL New 5501 242254900482 IND FXD 1206 EMI 100MHZ 80R R
ALL New 3718 212211805643 RST SM 0603 RC0603 100R PM5 R 242254945579 IND FXD 1206 EMI 100MHZ 100R R
232270260101 RST SM 0603 RC21 100R PM5 R ALL New 5502 242254900482 IND FXD 1206 EMI 100MHZ 80R R
ALL New 3719 212211805643 RST SM 0603 RC0603 100R PM5 R 242254945579 IND FXD 1206 EMI 100MHZ 100R R
232270260101 RST SM 0603 RC21 100R PM5 R ALL New 5701 242254900482 IND FXD 1206 EMI 100MHZ 80R R
ALL New 3720 212211805643 RST SM 0603 RC0603 100R PM5 R 242254945579 IND FXD 1206 EMI 100MHZ 100R R
232270260101 RST SM 0603 RC21 100R PM5 R ALL New 5702 242254900482 IND FXD 1206 EMI 100MHZ 80R R
ALL New 3721 212211805665 RST SM 0603 RC0603 4K7 PM5 R 242254945579 IND FXD 1206 EMI 100MHZ 100R R
232270260472 RST SM 0603 RC21 4K7 PM5 R ALL New 5703 242254900482 IND FXD 1206 EMI 100MHZ 80R R
ALL New 3722 212211805643 RST SM 0603 RC0603 100R PM5 R 242254945579 IND FXD 1206 EMI 100MHZ 100R R
232270260101 RST SM 0603 RC21 100R PM5 R ALL New 5704 242254900482 IND FXD 1206 EMI 100MHZ 80R R
ALL New 3723 212211805665 RST SM 0603 RC0603 4K7 PM5 R 242254945579 IND FXD 1206 EMI 100MHZ 100R R
232270260472 RST SM 0603 RC21 4K7 PM5 R ALL New 5705 242254900482 IND FXD 1206 EMI 100MHZ 80R R
ALL New 3724 212211805643 RST SM 0603 RC0603 100R PM5 R 242254945579 IND FXD 1206 EMI 100MHZ 100R R
232270260101 RST SM 0603 RC21 100R PM5 R ALL New 5706 242254900482 IND FXD 1206 EMI 100MHZ 80R R
ALL New 3725 212211805669 RST SM 0603 RC0603 10K PM5 R 242254945579 IND FXD 1206 EMI 100MHZ 100R R
232270260103 RST SM 0603 RC21 10K PM5 R ALL New 5707 242254900482 IND FXD 1206 EMI 100MHZ 80R R
ALL New 3726 212211805669 RST SM 0603 RC0603 10K PM5 R 242254945579 IND FXD 1206 EMI 100MHZ 100R R
232270260103 RST SM 0603 RC21 10K PM5 R ALL New 5708 242254900482 IND FXD 1206 EMI 100MHZ 80R R
ALL New 3727 212211805665 RST SM 0603 RC0603 4K7 PM5 R 242254945579 IND FXD 1206 EMI 100MHZ 100R R
232270260472 RST SM 0603 RC21 4K7 PM5 R ALL New 5710 242254900482 IND FXD 1206 EMI 100MHZ 80R R
ALL New 3728 212211805643 RST SM 0603 RC0603 100R PM5 R 242254945579 IND FXD 1206 EMI 100MHZ 100R R
232270260101 RST SM 0603 RC21 100R PM5 R ALL New 5711 242254900482 IND FXD 1206 EMI 100MHZ 80R R
ALL New 3730 212211805678 RST SM 0603 RC0603 47K PM5 R 242254945579 IND FXD 1206 EMI 100MHZ 100R R
232270260473 RST SM 0603 RC21 47K PM5 R ALL New 5712 313818875691 COI CHOKE 35UH 82M OHM DR10X8
ALL New 3731 212211805669 RST SM 0603 RC0603 10K PM5 R ALL New 6201 932205976685 DIO SIG SM LS4148 (VISH) R
232270260103 RST SM 0603 RC21 10K PM5 R 933913910115 DIO SIG SM BAS32L (PHSE) R
ALL New 3732 212211805665 RST SM 0603 RC0603 4K7 PM5 R 933952510685 DIO SIG SM LL4148 (VISH) R
232270260472 RST SM 0603 RC21 4K7 PM5 R ALL New 6202 932205976685 DIO SIG SM LS4148 (VISH) R
ALL New 3733 212211805669 RST SM 0603 RC0603 10K PM5 R 933913910115 DIO SIG SM BAS32L (PHSE) R
232270260103 RST SM 0603 RC21 10K PM5 R 933952510685 DIO SIG SM LL4148 (VISH) R
ALL New 3734 212211805639 RST SM 0603 RC0603 47R PM5 R ALL New 6203 932205976685 DIO SIG SM LS4148 (VISH) R
232270260479 RST SM 0603 RC21 47R PM5 R 933913910115 DIO SIG SM BAS32L (PHSE) R
ALL New 4205 212211805637 RST SM 0603 RC0603 22R PM5 R 933952510685 DIO SIG SM LL4148 (VISH) R
232270260229 RST SM 0603 RC21 22R PM5 R ALL New 6204 932205976685 DIO SIG SM LS4148 (VISH) R
ALL New 4206 212211805637 RST SM 0603 RC0603 22R PM5 R 933913910115 DIO SIG SM BAS32L (PHSE) R
232270260229 RST SM 0603 RC21 22R PM5 R 933952510685 DIO SIG SM LL4148 (VISH) R
ALL New 4207 212211805637 RST SM 0603 RC0603 22R PM5 R ALL New 6401 932220675682 DIO REC M100AL-5301-E3 (VISH)B
232270260229 RST SM 0603 RC21 22R PM5 R ALL New 6402 932220367673 DIO REC SB140A-E3 A (VISH) A
ALL New 4301 212211805631 RST SM 0603 JUMP. MAX 0R05 R 932220628682 DIO REC SB140AL-5301E3 (VISH)B
232270296001 RST SM 0603 JUMP. MAX 0R05 R 933957760673 DIO REC SB140-E3 A (VISH) A
ALL New 4302 212211805631 RST SM 0603 JUMP. MAX 0R05 R 933957760683 DIO REC SB140-E3 A (VISH) R
232270296001 RST SM 0603 JUMP. MAX 0R05 R ALL New 6403 932220367673 DIO REC SB140A-E3 A (VISH) A
ALL New 4303 212211805631 RST SM 0603 JUMP. MAX 0R05 R 932220628682 DIO REC SB140AL-5301E3 (VISH)B
232270296001 RST SM 0603 JUMP. MAX 0R05 R 933957760673 DIO REC SB140-E3 A (VISH) A
ALL New 4304 212211805631 RST SM 0603 JUMP. MAX 0R05 R 933957760683 DIO REC SB140-E3 A (VISH) R
232270296001 RST SM 0603 JUMP. MAX 0R05 R
REF Action Item 12NC Description REF Action Item 12NC Description
1 New 292 313815570071 EEPROM-Label(LPL-SL06) ALL From 2143 202203100132 ELCAP LZ 25V S 1000U PM20 B
2 New 292 313815570091 EEPROM-LABEL (LPL-SL06) 202203100135 ELCAP EB 25V S 1000U PM20 B
3 New 292 313815570111 EEPROM-LABEL (LPL-SL06) To 2143 823827736056 ELCAP TH 25V S 470U PM20B
Affected Sets
REF 12NC Description REF 12NC Description
1 313815865801 EEPROM ASSY-LPL 1 313815868041 SCALER ASSY
2 313815868071 SCALER ASSY
2 313815866611 EEPROM ASSY 3 313815868101 Scaler Assy
3 313815867141 EEPROM IC ASSY(US) 1 863900016916 200P7ES/00
4 313815867171 EEPROM IC ASSY(AU) 1 863900016917 200P7EB/00
2 863900016918 200P7EB/27
5 313815867441 EEPROM IC ASSY
3 863900016939 200P7EB/75
6 313815867471 EEPROM IC ASSY 1 863900017084 200P7EG/00
7 313815867481 EEPROM IC ASSY 3 863900017102 200P7EB/93
Go to cover page
Safety Checks
After the original service problem has been corrected,a complete safety check
should be made. Be sure to check over the entire set, not just the areas 6. New picture tubes are specifically designed to withstand higher operathng
where you have worked. Some previous servicer may have left an unsafe voltages without creating undesirable X-radiation. It is strongly
condition,which could be unknowingly passed on to your customer. Be sure recommended that any shop test fixture which is to be used with the new
to check all of the following: higher voltage chassis be equipped with one of the new type tubes
designed for this service. Addition of a permanently connected HV meter
Fire and Shock Hazard
to the shop test fixture is advisable. The CRT types used in these new
1. Be sure all components are positioned in such a way as to avoid the
sets should never be replaced with any other types, as this may result in
possibility of adjacent component shorts. This is especially important
excessive X-radiation.
on those chassis which are transported to and from the service shop.
7. It is essential to use the specified picture tube to avoid a possible X-diation
2. Never release a repaired unit unless all protective devices such as
problem.
insulators, barries, covers, strain reliefs, and other hardware have been
8. Most TV receivers contain some type of emergency "Hold Down" circuit to
installed in accordance with the original design.
prevent HV from rising to excessive levels in the presence of a failure
3. Soldering and wiring must be inspected to locate possible cold solder
mode. These various circuits should be understood by all technicians
joints,solder splashes,sharp solder points, frayed leads, pinched leads,
servicing them, especially since many hold down circuits are inoperative
or damaged insulation ( including the ac cord).Be certain to remove
as long as the receiver performs normally.
loose solder balls and all other loose foreign particles.
4. Check across-the-line components and other components for physical
Leakage Current Cold Check
evidence of damage or deterioration and replace if necessary. Follow
1. Unplug the ac line cord and connect a jumper between the two prongs of
original layout,lead length, and dress.
the plug.
5. No lead or component should touch a receiving tube or a resistor rated
2. Turn on the power switch.
at 1 watt or more. Lead tension around protruding metal surfaces or
3. Measure the resistance value between the jumpered ac plug and all
edges must be avoided.
exposed cabinet parts of the receiver, such as screw heads, antennas,
6. Critical components having special safety characteristics are identified
and control shafts. When the exposed metallic part has a return path to
with ans by the Ref. No. in the parts list and enclosed within a broken line
the chassis, the reading should be between 1 megohm and 5.2 megohms.
* (where several critical components are grouped in one area) along with
When the exposed metal does not have a return path to the chassis, the
the safety symbols on the schematic diagrams and/or exploded views.
reading must be infinity. Remove the jumper from the ac line cord.
7. When servicing any unit, always use a separate isolation transformer
for the chassis Failure to use a separate isolation transformer may
expose you to possible shock hazard, and may cause damage to
servicing instruments.
8. Many electronic products use a polarized ac line cord (one wide pin on
the plug.) Defeating this safety feature may create a potential hazard to
the service and the user. Extension cords which do not incorporate the
polarizing feature should never be used. TO 0.15 uF WATER
9. After reassembly of the unit, always perform an leakage test or resistance INSTRUMENTS PIPE
test from the line cord to all exposed metal parts of the cabinet. Also check EXPOSED EARTH
all metal control shafts(with knobs removed), antenna terminals, handles, METAL PARTS 1500 ohm, 10W GROUND
screws, etc. to be sure the unit may be safety operated without danger of
electrical shock.
Leakage Current Hot Check
* Broken line
1. Do not use an isolation transformer for this test. Plug the completely
reassembled receiver directly into the ac outlet.
Implosion
2. Connect a 1.5k, 10w resistor paralleled by a 0.15uf. capacitor between
1. All picture tubes used in current model receivers are equipped with an
each exposed metallic cabinet part and a good earth ground such as a
integral implosion system. Care should always be used, and safety
water pipe, as shown above.
glasses worn,whenever handling any picture tube. Avoid scratching or
3. Use an ac voltmeter with at least 5000 ohms volt sensitivity to measure
otherwise damaging the picture tube during installation.
the potential across the resistor.
2. Use only replacement tubes specified by the manufacturer.
4. The potential at any point should not exceed 0.75 volts. A leakage current
tester may be used to make this test; leakage current must not exceed
X-radiation
0.5 milliamps. If a measurement is outside of the specified limits, there is
1. Be sure procedures and instructions to all your service personnel cover
a possibility of shock hazard. The receiver should be repaired and
the subject of X-radiation. Potential sources of X-rays in TV receivers are
rechecked before returning it to the customer.
the picture tube and the high voltage circuits. The basic precaution which
5. Repeat the above procedure with the ac plug reversed.( Note: An ac
must be exercised is to keep the high voltage at the factory recommended
adapter is necessary when a polarized plug is used. Do not defeat the
level.
polarizing feature of the plug.)
2. To avoid possible exposure to X-radiation and electrical shock, only the
manufacturer's specified anode connectors must be used.
Picture Tube Replacement
3. It is essential that the service technician has an accurate HV meter
The primary source of X-radiation in this television receiver is the picture
available at all times. The calibration of this meter should be checked
tube. The picture tube utilized in this chassis is specially constructed to limit
periodically against a reference standard.
X-radiation emissions. For continued X-radiation protection, the replacement
4. When the HV circuitry is operating properly there is no possibility of an x-
tube must be the same type as the original, including suffix letter, or a Philips
radiation problem. High voltage should always be kept at the
approved type.
manufacturer's
rated value-no higher - for optimum performance. Every time a color set is
Parts Replacement
serviced, the brightness should be run up and down while monitoring the
Many electrical and mechanical parts in Philips television sets have special
HV with a meter to be certain that the HV is regulated correctly and does
safety related characteristics. These characteristics are often not evident from
not exceed the specified value. We suggest that you and your technicians
visual inspection nor can the protection afforded by them necessarily be
review test procedures so that HV and HV regulation are always checked as
obtained by using replacement components rated for higher voltage, wattage,
a standard servicing procedure, and the reason for this prudent routine is
etc. The use of a substitute part which does not have the same safety
clearly understood by everyone. It is important to use an accurate and
characteristics as the Philips recommended replacement part shown in this
reliable HV meter. It is recommended that the HV recorded on each
service manual may create shock, fire, or other hazards
customer's invoice, which will demonstrate a proper concern for the
customer's safety.
5. When troubleshooting and making test measurements in a receiver with
a problem of excessive high voltage, reduce the line voltage by means of
a Variac to bring the HV into acceptable limits while troubleshooting. Do
WARNING : Before removing the CRT anode cap, turn the unit OFF and short the HIGH VOLTAGE to the CRT DAG ground.
SERVICE NOTE : The CRT DAG is not at chassis ground.