You are on page 1of 6

6505® Piranha™

アンプ

オペレーション
マニュアル

www.peavey.com
FCC/ICES Compliancy Statement

This device complies with Part 15 of the FCC rules and Industry Canada license-exempt RSS Standard(s). Operation is
subject to the following two conditions: (1) this device may not cause harmful interference, and (2) this device must
accept any interference received, that may cause undesired operation.

Le présent appareil est conforme aux CNR d’lndustrie Canada applicables aux appareils radio exempts de
licence. L’exploitation est autorisée aux deux conditions suivantes: (1) I’appareil ne doit pas produire de
brouillage, et (2) I’utilisateur de I’appareil doit accepter tout brouillage radioélectrique subi, même si le
brouillage est susceptible d’en compromettre le fonctionnement.

Warning: Changes or modifications to the equipment not approved by Peavey Electronics Corp. can void the
user’s authority to use the equipment.

Note – This equipment has been tested and found to comply with the limits for a Class B digital device,
pursuant to Part 15 of the FCC Rules. These limits are designed to provide reasonable protection against
harmful interference in a residential installation. This equipment generates, uses, and can radiate radio
frequency energy and, if not installed and used in accordance with the instructions, may cause harmful
interference to radio communications. However, there is no guarantee that interference will not occur in a
particular installation. If this equipment does cause harmful interference to radio or television reception,
which can be determined by turning the equipment off and on, the user is encouraged to try and correct the
interference by one or more of the following measures.

• Reorient or relocate the receiving antenna.


• Increase the separation between the equipment and receiver.
• Connect the equipment into an outlet on a circuit different from that to which the receiver is
connected.
• Consult the dealer or an experienced radio/TV technician for help.

Caution
The equipment complies with FCC radiation exposure limits set forth for an uncontrolled
environment.
日本語

6505® Piranha™
チューブアンプ
6505 Piranha ヘッドをお買い上げいただきありがとうございます!本器は、大型のオールチューブ製品の
特徴と”クランチ”、”リード”トーンを受け継ぎ、最大20ワット (4オーム)の小型パッケージに収めていま
す。12AX7シングルチューブは、ほとんどの主要ステージでゲイン構造を補います。本器は、112-6、212-6、お
よび伝説の6505 412キャビネットなど、 プレミアムドライバのある大型キャビネットでその性能とサウンド
の魅力を最大限に発揮します。 ミニマルなコントロールと堅牢構造により、ライブやレコーディングに適し
た、”スイスアーミーナイフ”のように万能のツールです。ヘッドフォンジャックとAUX入力は練習用に、エフ
ェクトセンドは大型アンプの入力に接続して“6505 プリアンプドライバ”として使用すれば、簡単な“リアン
ピング”に良く、他にも用途が広がります。

使用前に本書をよく読み、ボリュームレベルに注意してお楽しみください!

特徴

* 20W RMS - 4 オーム

* 12AX7/ECC83 プリアンプチューブ

* スピーカー出力

* クランチ/リードスイッチ

* シングルノブ EQ:一般的な 6505 設定でモーフィング

* 補助入力

* バッファードエフェクトループ

* 堅牢メタルエンクロージャ

換気:換気を良くするため可燃物表面から24 (30cm以上)
スペースを空けてください。
フロントパネル

1 2 3 4 5 6 7

1 入力 - 低ノイズ・高品質シールドケーブルでこのジャックにギターを接続します。

2 クランチ/リード - プリアンプのゲインモードをクランチからリードに切り替えます。
クランチは、ブライト
ブーストのあるオリジナルの6505リズムチャネルの”クランチ”設定に特有、リードは、クラシックな6505ハ
イゲインリードサウンドに特有なサウンドです。

3 ゲイン - 最初のJFETゲインステージでアンプの入力レベルを調整します。時計回りに調整すると、
アンプ
入力回路に対して熱く、”レスポンス”の良い信号になります。

4 EQ -「ノッチ」位置で6505 “ノッチ” 3バンドEQ 設定(10-0-7)を“モーフィング”し、中間位置で一般的な“7-7-


7”設定に、時計回りに回し切った位置でフルミッドレンジ(10-10-10)まで調整します。

5 ボリューム - パワーアンプセクションでプリアンプ全体のボリュームを調整します。

6 AUX IN - ポータブルMP3プレーヤー、他のメディアデバイスなど、
フルレンジオーディオソースを信号チ
ェーンに送る1/8”ステレオ入力です。

7 PHONES - 一般的なスタジオヘッドフォンをドライブする¼”ステレオジャックです。
リアパネル

8 9 10 11

8 スピーカー - 外部スピーカーキャビネットを接続する1/4” モノジャックです。最小負荷インピーダンスは


4 オームです。

9 エフェクトループセンド、 エフェクトループリターン
信号を外部エフェクトや信号処理機器に送る1/4” 出力ジャックと、外部エフェクトや信号処理機器から信
号が戻る1/4”入力です。

10 DC電源 - 付属+30VDC電源を接続します。注:6505 PIRANHAの電源には付属の電源アダプタ


(Peavey
#30908151)を使用してください。

11 電源 - DC電源を内部回路に送り/切り離します。

製品仕様

パワーアンプセクション:
定格出力 & 負荷:20W(rms)、4 オーム;15W(rms)、8 オーム;10W(rms)16 オーム
DC電源(付属) :+30VDC @ 1ADC(正端子); Peavey品番#30908151
プリアンプセクション:
測定方法:@ 1kHz、 コントロールはすべて中間位置 (12時の位置)にセット、 クランチ設定
入力:
インピーダンス:1Mオーム、公称入力レベル:-20dBV, 100mV(rms)
エフェクトループセンド:
負荷インピーダンス:10kオーム以上、公称入力レベル:0dBV, 1.0V(rms)
エフェクトループリターン:
インピーダンス:1Mオーム、設計入力レベル:0dBV, 1.0V(rms)
(未使用時、切替えジャックはプリアンプ出力をパワーアンプ入力に送信)
AUX 入力:
公称入力レベル:0dBV, 1.0V(rms)
寸法 & 重量:
5.2” (132mm) L x 7.0” (178mm) W x 3.2” (82mm) H;
2.5 lbs (1.13 kg)
注:機能、仕様は予告なく変更することがあります。
www.peavey.com
Warranty registration and information for U.S. customers available online at
www.peavey.com/warranty
or use the QR tag below

Features and specifications subject to change without notice.


Peavey Electronics Corporation 5022 Hartley Peavey Drive Meridian, MS 39305 (601) 483-5365 FAX (601) 486-1278
Logo referenced in Directive 2002/96/EC Annex IV
(OJ(L)37/38,13.02.03 and defined in EN 50419: 2005
The bar is the symbol for marking of new waste and
is applied only to equipment manufactured after
13 August 2005

You might also like