Service Manual
Radio Cassette
RX-1450S
FM/MW Radio Cassette Recorder
RX-1450LS MECHANISM SERIES
Specifications
Power Requirement: AG; 220V, 50/60 He Speaker 10 om (4") PM Dynamic
Power consumption; 7W speaker (8a)
Battery; 6 V (four UM-1, R20 Ravio Frequency Range: FM; 87.5~108 MHz
sizo dry batteries) MW; 520~1610 kHz
Power Output 20.W.....AMS (max) (s7~186m)
Frequency Range 400~2,000 Hz Intermediate Froquoncy: FM; 10.7 MHz
Recording System. [AG bias, MAGNET erase AM (MW); 455 KH
Tape Spoed: 48 emis, (15 ips) Sensitivity FM; 3.37/50 mW output
Program Time 1 hour with C-60 cassette tape MW: 140V/m/60 mW output
Track System 2utrack 1-channe! monaural Dimensions 32.1 em (W) «24.5 em(H) x
recording and playback 11-1 em (0)
AEC/PB Connection 5 DIN type: sensitivity 1125" (W) x84" (H) x49"(D)]
IN; 18 mV (1 ka over) Weight 26 kg (Sibs. 12.02) without
(OUT; variable batteries
output EXT SP; 80
Specifications are subject to change without notice,
Matsushita Electric Trading Co, Ltd.
@ Panasonic Fo Bon 265" Contra Ona Tapst
EBISSzSAwaTELESCOPIC
cA
ieaeees anes
SCHEMATIC DIAGRAM MODE
Record/playback switch (shown in
Playback position)
"TAPE/MW/FM selector (shown in tape
position).
LTAPE, 9...MW, 4..FM.
Monitor ON/OFF switch (shown in OFF
position).
Motor ON/OFF switch (shown in OFF
position).
AC/DC select switch (shown in DC
6. Se~Sees....DIN ON/OFF switch (shown in OFF
position)
7. Raw Tone contro
a Volume control
8 6 test point. e.g. W=Test pc
10. shown in circuitry are und
ith volume control at maxime
position, For measurement, use electronics voltr
The upper values should be measured during Fb
the lower values during MW (Radio circuit)
The voltage Indication of Quo: are measured durintae hy sy
oe RSI, al és 2oag0
Te tte o
(pepe! ree | gt
wvovbies | 1
yy
exox |W
?
2si45 gl 28H.
noon
eats
imc
= xt
7 is
5 ae, HL Chon
x BY
PE ete
LAS || | | ASI
gs 8
;
-
AVDIOET
RECT
AvovD261L
va!
FF switeh (shown in OFF 11, Battery current: No signal
SkHe | +3~—1208
135 ma
(Record mode and monitor switch to OFF position.)
rol 412, ‘indicates that only parts specified by the manufacture
ontrol
point. €.g. W=Test point 1
vn in circuitry are under no
ume control at maximum
nt, use electronics voltmeter.
be measured during FM and
MW (Radio circuit),
Qs: are measured during
bbe used for safety.
HORN ae!
@ |
ins
10T~105, 201
on [-
= a
a
oe
3