Read the Do-It-Yourself Installation Instructions Door clearance should be 1/32” (1mm) on all sides. completely before starting. Door thickness should be 5/8” (16mm) or 3/4” (19mm). Make sure all parts are included. Placing several cabinets together requires that an amount of the frame or opening (reveal) must show Parts List between the doors for the doors to properly open and Concealed Hinge close. Mounting Plate
Recommended Tools and Materials
#2 Phillips (or other relevant) Screwdriver Pencil or Scribe Metric Ruler Drill and 1/16” Drill bit for pilot holes Boring Bit 35mm (Forstner Bit) for hinge cup #8x3/4” or #8x5/8” Screws (thickness of panel should be considered)- recommended number 4 per hinge
Data 1. Marking Drill Holes
See chart below for recommended number of a) Use blank paper to mark hinge cup and holes and hinges per door size. create a hinge cup drilling template. See the sample If hanging a door with a mirror or very wide door at the end of instructions. you will need additional hinges. b) Cut prepared template and use hinge cups template for drilling hinge cup and screw pilot holes. c) Align hinge cup template to door and mark location of holes. d) Prepare, mark and cut out mounting plate template for drilling screw pilot holes in the same way. e) Align mounting plate template to the edge of cabinet and mark location of holes.
Important: Verify product measurements prior to
drilling. Printer configurations may not be set to print templates to actual size. Full Overlay European Concealed Hinges
2. Installing Hinge to Door 5. Door Adjustment
a. Drill hole 12 mm (15/32”) deep for hinge cup per Align door using following adjustment feature. template using a. Horizontal 35mm boring bit. Adjustment Do not drill through allows for door face. adjusting the b. Drill pilot holes for door side to side. screws per template. Do not drill through door face. c. Insert hinge into b. In-and-Out door and fasten with screws. Do not overtighten. Adjustment allows for 3. Installing Mounting Plate to Cabinet adjusting the door in and out. a. Drill pilot holes for screws. Do not drill through cabinet. b. Align mounting plate to holes and fasten with c. Vertical screws. Do not overtighten. Adjustment allows for adjusting the door up and 4. Installing Door to Cabinet down.
a. Open hinge to full extension.
b. Connect door to cabinet as shown below.
Samples of Mounting Plate and Hinge Cup Template
Important: Verify product measurements prior to
drilling. Printer configurations may not be set to print templates to actual size.