Professional Documents
Culture Documents
CRVPDF
CRVPDF
DTC B1187: Gauge Control Module Lost Communication With the SRS Unit (SRS Message)
NOTE:
If you are troubleshooting multiple DTCs, be sure to follow the instructions in B-CAN System Diagnosis Test
Mode A.
If the HDS does not communicate with the SRS unit, the SRS indicator stay on, go to symptom
troubleshooting for SRS indicator stay on, but no DTCs are stored.
2. Turn the ignition switch to LOCK (0), and then back to ON (II).
YES — Go to step 5.
NO — Intermittent failure, the system is OK at this time. Check for loose or poor connections between
the gauge control module and the SRS unit.■
9. Check for continuity between gauge control module 36P connector terminals No. 33 and No. 34 and SRS
unit connector A (28P) terminals No. 12 and No. 11 respectively.
https://dh.identifix.com/SearchFixes/Index?ROID=258404955&VID=2204252&VSM=1&LocationId=2&WorkflowPath=1#KW=b1187&SOption=1&VETI… 1/2
6/10/2020 Direct-Hit -- Search
Is there continuity?
YES — Substitute a known-good SRS unit, and recheck. If the indication goes away, replace the original
SRS unit. If the DTC is still present, replace the gauge control module.■
NO — Repair an open in the wire.■
Portions of materials contained herein are sourced from American Honda Motor Inc., Co.
https://dh.identifix.com/SearchFixes/Index?ROID=258404955&VID=2204252&VSM=1&LocationId=2&WorkflowPath=1#KW=b1187&SOption=1&VETI… 2/2