Professional Documents
Culture Documents
Because of these loads, the footprint of the tyre increases and the part of the tyre against the ground is
subject to a lot of deformation, as shown in illustration 1 below. The structure of the tyre has to be incredibly
strong and elastic to cope with this constant flexing.
In red: beyond 350kph, the part of the tyre in contact with the asphalt undergoes notable deformations.
At the same time, the upper section of the tyre (which is not in contact with the ground – illustration 2) is
subjected to a big centrifugal force, but despite this the shape of the tyre does not change much: stretching
by just 1%. This is due to the low weight and extremely high stiffness of the materials developed by Pirelli
for Formula One.
Beyond 350kph, the highest part of the tyre only changes shape by 1%, despite being subject to an enormous
centrifugal force.
The F1 tyres are designed precisely with these extreme forces in mind: during laboratory testing, before they
even see a race track, the tyres are exposed to higher loads and forces than they would normally experience,
and accelerated to speeds of up to 450kph. Not only that, but they are also fired into solid surfaces at speeds
in excess of 250kph: simulating the impacts with kerbs for which Monza is also famed.