1 Engine Electronic Control Module 2 Crankshaft Position Sensor 3 Oil Pressure Switch 4 Engine Coolant Temperature Sensor 5 Engine Sub-harness Connector 6 Cooling Fan 7 Cooling Fan Relay 8 Engine Management System Relay 9 Fuel Pump 10 Fuel Pump Relay 11 Rear Brake Switch 12 Brake Light 13 Rear Light 14 Rear Brake Relay 15 Left Hand Rear Direction Indicator 16 Right Hand Rear Direction Indicator 17 Rider’s Heated Seat 18 Passenger’s Heated Seat 19 Rider’s Heated Seat High/Low 20 Rider’s Heated Seat Power On 21 Alarm Connector 22 Starter Motor Solenoid Relay 23 Starter Motor 24 Starter Motor Solenoid 25 Regulator/Rectifier 26 Battery 27 Fuse Box 28 Passenger’s Heated Seat Relay 29 USB Connector 30 Key Antenna 31 Ignition Switch Connector 32 Rider Accessory Socket 33 Immobiliser 34 Front Brake Switch 35 Right Hand Switch Housing Black Connector A 36 Right Hand Switch Housing Grey Connector D 37 Left Hand Switch Housing Connector B (2 Pin) 38 Left Hand Switch Housing Connector A (6 Pin Black Connector) 39 Ambient Air Temperature Sensor 40 Heated Grips 41 Bluetooth Connector 42 Rear Wheel Speed Sensor 43 Front Wheel Speed Sensor 44 ABS Modulator 45 Diagnostic Connector 46 Headlight 47 Position Light 48 Right Hand Front Direction Indicator 49 Left Hand Front Direction Indicator Key Item Description 50 Horn Relay 51 Horn 52 Instruments 53 MAP Sensor 54 Ambient Air Pressure Sensor 55 Fuel Level Sender 56 Side Stand Switch 57 Fall Detection Switch 58 Gear Position Sensor 59 Ignition Coil 1 60 Ignition Coil 2 61 Ignition Coil 3 62 Oxygen Sensor 63 Intake Air Temperature Sensor 64 Injector 1 65 Injector 2 66 Injector 3 67 Purge Valve 68 Secondary Air Injection Solenoid 69 Drive By Wire Throttle Actuator Motor 70 Throttle Position Sensor 71 Twist Grip Position Sensor 72 Fog Light Relay 73 Left Hand Fog Light 74 Right Hand Fog Light 75 Sub - Harness Switch Housing
Key To Wiring Colour Codes
Code Wiring Colour B Black U Blue N Brown G Green S Slate/Grey O Orange K Pink R Red P Purple W White Y Yellow LG Light Green LU Light Blue