190 Options
Contents
190.1. Reversible fan drive
PR776-1296/12569.; 190-2
PR776-1298 EBHERR 190-1Options Service manual
190.1 Reversible fan drive
Valid for: PR776-1296/12589-;
4 Function
4.1 Basic function
block 66-P — axial piston
constant motor fan drive 61 A-B -»+ block 66-T —» directional valve 67 + block 66-T
= fitting chain distributor oil cooler 64 — block leftright 68 -P —>
scheck valve 71 and check valve 72-» solenoid valves Y52 and Y53 (de-ener-
gised) -» directional valve 69 —» gear motor - fan oil cooler leftlright 54 A-B —» block
leftright 68-T — hydraulic tank 60.
Fan rotates with minimum rpm or is at a standstill. As media temperature increases
(hydraulic oil, diesel engine coolant, charge air) the current feed from proportional
pressure cut off valve Y76 is proportionally reduced and as a result, the pressure in
the fan drive is correspondingly increased. The fan speed increases.
If one of the media reaches the operating temperature, then the proportional pres-
sure cut off valve Y76 is supplied with minimum current from A700 and it regulates
the pressure level in the fan drive to the maximum normal operating pressure.
1.3 Reversal of direction of rotation
When the machine is initially put into service, the fans run in normal direction of
rotation,
The ECU A700 measures the running time of the diesel engine. When the diesel
engine is turned off, the timing is only interrupted, but not reset to zero. After 30
minutes of run time (adjustable by the operator from 20 minutes to 45 minutes) the
proportional pressure cut-off valve Y76 (about 12 seconds) is provided with the
maximum current feed
As a result, the axial piston constant motor fan drive 61 and the gear motor - fan oil
cooler leftright £4 is operated by the control unit (ECU) A700 for a short time at
minimum speed.
‘Thereafter, the solenoid valves Y51, Y52 and YS3 are supplied with current from
A700 — directional valves 67 and directional valves 69 are switched to the 3rd
switch position
‘The pump flow is led onto the previous downstream side of the fan hydraulic
motors.
Note
If the hydraulic motors are still rotating, the shifting of the directional valves 67 and
directional valves 69 is impeded at the 3rd switch position.
‘A700 reduces the current feed at the proportional pressure cut-off valve Y76,
whereby the maximum pressure is reached and the fans turn in the opposite direc-
tion at maximum speed. After 30 seconds of reversed direction of rotation (adjust-
able by the operator from 20 seconds to 45 seconds), the A700 provides the
PR775-1298
LIEBHERR 190-5Options
Service manual
maximum current feed to the proportional pressure cut-off valve Y76 and, as a
result, the axial piston fixed displacement motor fan drive 61 and the gear motor -
fan oil cooler left/right 54 are operated at minimum speed for a short time.
Thereafter, the solenoid valves Y81, Y52 and YS3 are switched off. Thereafter, the
directional valves 67 and directional valves 69 are returned to the starting position
This returns the fan drive again to normal direction of rotation. At the same time,
the counter is set to 0 and the entire cycle begins again,
In addition to the automatic control, the change of the direction of rotation can also
be triggered manually via the push button $41. The manual actuation sets the
counter back to 0.
190-6
LIEBHERR PRI76-1296