Professional Documents
Culture Documents
To verify this, a simple built-up gage may be used as a go/no-go inspection. Where variable data is desired, an indicator may be zeroed out at 26.8mm. All readings, as the surface is trammed (probed), must be below the zero point. In addition,
of course, the size must be verified with local measurements with a micrometer-type device.
Note: The stock size and material usually are stated in a material specification note. For that reason the size appears here in parenthesis as a reference.
Home About GD&T Training Software Catalog GD&T Resources Prototyping Contact Site-Map
http://www.tec-ease.com/tips/september-03.htm 11/03/2007