foun/29/20273 12/8)
(UNE RESERVOIR DL-2T] {KYODO YUSHE CO., LED, 1{05-764)
SAFETY DATA SHEET {
1, Tdentitieation
Product isenti¢ier: ONE RESERVOIR DL-27
Receamended use of the chemical and restrictions on use:
Tobricating grease
Manufacturer
Nene: KYODO YUSHI CO., LRD,
Bddvass: 2-2-50, Tousiao'Kandsi, Fujisawa-shi, Kanagawa, Japan
PEL $91a466-33-3159
‘Emergency phone sumber? +81-466-39-9157 (kvODO YUSHE CO., LTO.)
‘1-847-364-2020 {KYODO YOSHI USA’ INC.)
2, fiazards Adentisieation
Classification of this procket in accordance with 29 CFR 1910.1200
{OSHA Hazcon 2022)
Gas Classitiostion
Physical dszarde +: Claseisication not
possible
Health Gazards
‘Sensitization - skin category 2
Envirennens Hazards F Classifloation aot
possibie
OSH Defined Hazarde: (Pysophoric gas, Simple asphyxiant,
Combustible dusty
possible
GUS labeling Elerents
Symbol:
t
Signal Wora: Masning
(317) May sauce an allergic skin reaction
Precast Lonazy Seaveneats
(261) Avoid breathing dust/fune/ga6/nist/vapors/spray.
(2272) Contaminated work clothing mast not be allowed Gut of
the workplace.
12280) Wear protective gloves/aye pratection/tace protection.
Response:
b30242952)
Ton skin: Wash with plenty of water
weass2819
Tf skin irritation or rash occurs: Get medical
savice/ateentsan
(e963) fash contaninated clothing before reuse.
Not apo2icabie
Disposals
(F501) Disposal showld be in accordance with applicable
regional, nations] and local laws and regulations,(aun/23/20071 (2/8)
uur RESERVOIR OL-2T) {k¥OD9 YUSHE co., ED, 1105-764)
Hazards Not otherwise Classified noc)
“Not applicable.
other information
“20-804 of the mixture consists of ingredients of unknown acute
tonaciey.
3. Composition/ information on ingredients
Formula: Not applicable.
reaper TRE rarer
ase oo Tear wirerat ST Tesae_secrer] 80-30
[PetsKener (oTentum soap) Tease eseree| OT
[Raaieive Ce) contataing Fine CompousaTeT] —] tradesecret| =
‘the specific chenical identity of composition has been withheld as 2
s22 Section 8 for exposure Linits (1£ applicable)
See Section 15 for legal controlled substance (if applicable).
nye Coneact’
“Innediscely flush with water gor st least 15 minutes. Get
guia Contact!
“"ThorouJhiy ramave with cloth or paper and wash cerefully with
soap and water.
Inhalation
“"hanove the victim from the contamination to fresh air, cover the
Viseia ina blankat to keep sarw and quiet, Consult a physician
regestion:
bo not induce vomiting. Immediate consult a physician.
Symptona/effacts, acute and delayed:
Who dats availiable:
indication of immediate medical attention and special treatment
needed
Supportive care. Treatment based on judamant of the physician in
response to reactions of the patient.
5. Fize-fighting measures
Extinguishing Mediar
“Foam, de¥ chanical, CO2, dry sand.
unsuitable Extinguishing Media
“oo'not use water. Water can be dangerous possibly leading to
Fize apron
specific Hasards with Regard to Fire-fighting:
“Thermal deconpositicn and canbustion may PEeduce carbon tionoxide
and/or cazbon dioxide(9un/23/2017) 13/81
uur ReseRvoIR DL-2T) (x¥000 YUSHT co., LED, 1 (05-764)
Specitie Methods of Pize-tiaghtsng}
“In the early stages of fire, vse dry chemical, Co2, dry sand,
ote. fireaxtinguisher.
sn cane of maseive fic, use foam fire-extinguisher to shut of £
the alr supply.
+ Gee all persons to safety. Authorized personnel only at the fire
spacial protective equipment and peacsutions for flue-fignters:
“Piro figneors should wear protect ive eqnipeant
‘start fire fighting tron the vindvard ide
6. Accidental release measurt
Persons] precautions, protective equipment, and amzyency procedures:
“leat Protective Sqhipnent curing cleanup work
“Prevent spills fron entering sewers or waterway,
Netnoas for Clean-Up:
“Collect spillage into a chemiosl waste container with a cover
for disposal, For small spills, wipe off with a solvent (eracy
kerosene)
prevention of Secondary Hazards
“Immediately shut off all sources of Lgnition
17, Handing and storage
Tenal ing
‘Techn deal Measures:
“iiandle the product in a well-ventilated place. Do not Leaky
Flood oF scatter tho product to prevent unwanced evapora sen
"Contact with eye may cause irritation. Use protective glasses
fe avoid contact with eyes.
+ Contact wien akin may esis
to avoid ghz contact,
+ Do Rot evallow. (Drinking the product say cause diarrhes and
vomiting.
+ Close container after each use.
Peceautions for safe #andling:
“ear gloves to avold injuey on hands at opening the containes,
storage
Appropriate Storage Conditions
“feep container closed to protect from dust/acer ingress ater
+ Store in a cool, dry place, away from direct sunlight, heat
+ Keep out of reach of children,
safe Packaging Materisls:
“bp not expose empty container to pressure.
‘do not weld, heat, aril or cut container” Residve ignition
and explosion hazneds.
irritation. Use protective gloves[wn/25/20171 14/81
(ONE RESERVOIR DL-27] {KYODO YOSHE CO., LED, } (05-764)
Exposure controls/personal protection
Exposure Guidelines
‘si
"O41 misty mineral: THA Sng/=3
‘Mineral oil: TWA Sug/m3
Oi) mist (aineral): TWA Sng/e3
Engineering Controls
“nen vapor of mist exhsles, install an apparatus to close the
Yapor/mist source of ventilation equipment
Individual protection measures, such as personal protective
equipment:
“ear protective gloves/protective clothing/eye protection /face
Protestion.
Proteative Equipment
Respiratory Protection:
Wear a gas nask for organic gas when needed (not necessary
under normal conditions) -
end Protect ian:
“ear oll-resistant pratective gloves in case of prolonged
and/or repeated skin contact.
Bye Protection
"Wear chemical safaty goggles whenever the product spiastes:
Skinvend Bosy Protection
“year long-sleeved ofi-reaistant working clothes whenever
handling for many houre and/or getting wet. Inedtately take
Off the wet clothes and thoroughly wash then before reusing.
9. Physical and chemical properties
iapeeazance
Form Semt-201sd
color Light yellowish brown
doe shighe’ odor
DSSE threshold No data. avasable,
Nov applicable.
Belting point No dats availabte,
Initial Belling point and boiling
ange No gata available.
Flash point 198'c(setar
Evaporation rate No data avadzabie,
Flannabilicy. No data available.
Uppes/ lower flamability or explosive
limite No date avazable.
Vapor. pressure Po date available
Solubtliey in water Ineolsble in water
Vapor density No data svailaple-
Density 0.92128 cyg/ens
Partition coefficient: n-octanol/uater | No data available,
Asto-ignition temperature Ne data available.
Decomposition temperature No data available.
Viscosity Not, applicable.
Dropping point 200°(30n/23/2017) 15/81
LOWE RESERVOIR DL-271 [KYODO YUSHT CO.,LTD. }[05-764)
10
n
Stabitity and reactivity
Reactivity, Conditions to avotd:
void contact with strong oxidant.
chemical Seabsiicy?
Possibility of Hazardous Reactions:
wot avasisole
Material: to avotd:
‘ streag oxidizers,
“gnie material is expected to Be stable under nosmal conditions
of wee.
‘Toxicological information
Information on the Likely routes of exposure
‘Skin Contact: May cause an allergic skin reaction
Delayed and imsediate effects and also chronic effects from short
‘Route toxicity = Oral: No data available.
“Refined mineral oil L950 Acute oral 95 g/kg (eat)
Acute toxicity = Dermal: Wo data available
toxicity > Inhalation (Gases): No daca available.
toxicity = Inhalation (Vapors): to data available.
Route toxicity - Inhelation (Duses end mists): No data available.
Chronic toxicity: wo daca available
Skin corrosion/ireieation: No data. available.
ye damage/irritation: No data avallable:
Sensitization ~ Respiratory: tio data available.
“Classified under category 1 based on the category of each
ingredient or the product properties.
Germ cet mutagentelty: No dats avallabie
Carcinogenicity: No data available.
‘Toxse ts reproduction: No data avaslabl
Ettecce on or via dactation: No daca available,
Specific target organ toxicity (Single exposure):
specific target organ toxicity (Repeated exposure)
No daca availanle.
Aspiration hazard: No data avatiabie,
other Toxicity Information
Tare Nenogrephar Hot sisted.(40/23/2017 (6/8),
[UNE RESERVOIR L-27) [KYODO YUSHE cO., LTD. 1 05-764)
12
2a
a,
as
Ecological information
Beotoxicity
Hazardous to the aquatic envizonment (Route hazard):
No data svailaple:
Hazardous to the aquatic envizonment (Long-term hazard)
io data available:
Persistence and Degradability: No data available.
Bioaccumlative potential? No data. available.
wopsliey i acl? No data avatlable.
Hazardous to the ozone Layers Mo data available.
Disposal considerations
Maste Rossdues
“properly dispose of in accosdance with any celevant regulations:
Properly dispose of by a licensed waste disposer
+ for in-house incineration disposal, ensure exaust gas treatwent
(washing treatment, etc.) to prevent air pollution fram sulfur
oxides.
No dumping:
When Burning, be sure to do 20 on sonsone’s watch in a safe
place and in'tho way that burning and/or explosion will never
Pose a potential hazard.
contaminated Packaging
“Dispose of container after completely removing the contents
Transport information
Dot Herardous Materiaia: Not applicapie.
OW transport of Dangezous Goods
UN thinber! lot applicable
UW Proper shipping Name: Not applicable,
‘Transport Hazard Class: Not applicable
Packing Group: Not applicable.
and (R30/a0a) # tot applicable:
Sen (IM0/ MDa) = Noe applicable:
Biz (ICAO/TATA) + Now applicable
Specific Precautionary Transport Measures and Conditions:
wnContaing combustible lnguid. Koop fire eet.
Handle with care to prevent Container datage.
‘Ensure proper packaging becore shipping £0 avoid load shitting
ana falling accident
Regulatory information
Regulatery information with regard to thie product in your country
oy your region should be exawined by your ewn eesponaibility,
U8 TSCA (Toxic substances Control Act)
‘ALL conponance of this produce are Listed on the TSCA inventory of
Chemical substances.
Us OSHA (Occupational Satety and Health act)
‘This product 1s not hazazdous accozding to the OSHA Hazard
Communication Standard, 29 CFR 1910-1200,WME RESERVOIR DL-2T1 [KYODO YUSHE CO.,LTD, 1(05-764)
(90n/29/20273 07/8)
(Comprehensive Environmental Release, Compensation & Liabslity act)
ane ThessholaTe] | CRS Wo [Contents TT
pine compound tar 30-1 | Trace secrer]—I=3 J
US SARA (Superfund Amendment ¢ Reauthorization Act } Title TT
‘SARA Extremely Hazeedous Substances (302) None
SARA Hazard categories (311/312): None
SABA Toxie Release Inventory (TRE) (313): None
Tare Tarsanare eR TSE OT
ieTne seapounetsy SOL | Wrage secret] Tv
PROPOSITION 65 Lists Wone
Other Information
Wealth hazards: 1
Flaneabstieys 1
Instability: 0
Special Hazard: =
contact information
Mane: "KYODO YUSHT co., Urb.
International Sueinese Dept.
Addvess: 2-220, Tsujide Randal, Fujisawarshi, Kenegava, Japan
TL fet-agb-33-3157
Name: Y000 USAT USA Ie.
Adseaes! Continental Towers ~ Tower T, 1701 Golf Road, Suite 1108
Rolling Meadows 60008 Il, U.S.A
re ieaateseq-2020
Eemail: infoehyodoyushiusa.com
original date: oct/31/2028
Revision date: un/22/2017
‘eterences
{losin Hazard Communication Standard 29 CER 1910.1200,
2itnrecholds limit values for chemical supetances and physical
‘agents and biological exposure indices, ACGIN(2012)
3.08 NIOSH Pocket Guide to. chemical Hazards, 2010,
LIAR MONOGRAPHS ON THE EVALOATION OF THE CARCINOGENIC RISK OF
‘CHEMICALS TO HUMANS VOLUME 32
Report on Carcinogens Swelfeh Eaition 2011, NIP
BU CLP Regulation {B6 No 1272/2008 RIMEX VI Harmonised
classification and labelling for certain hazardous substances)
7.GiobaLly Harmonized System of Classificntion and Labelling of
Chemicals (Gis) Third revised edition(oun/23/2017) 18/8),
(ONE RESERVOIR DL-2T] {KYODO YOSHE CO., LED. 108-764)
This SDs Ls an addition and coaplenentary document beside the
technical data shest.the information 1s based upon our knowledge
about the product at the date of edition.
Since we cannot anticipate or control the different conditions
Under which these information or our product may be used, We make
fo guarantee that recommendations will be adequate for sil
Unaividuals and situations.