You are on page 1of 4

Zolertia Re-Mote MAX ratings:

About ADCs in Re-Mote:


All ADCx are exposed in JP5 connector, but only ADC1 and ADC3 have GND and VDD (3/5V) pins next to
it, so these can be exposed into a 3-pin phidget-like connector, for ADC2 either solder a wire to connect, or
use a 4-pin connector to expose both ADC1 and ADC2 in a single connector, but this will leave no space
for a ADC3 connector

The internal ADC reference is 1190mV, use either a voltage divider as input, or a different voltage
reference, like AVDD5, or externally using PA7/AIN7 and PA6/AIN6 configurable as differential reference,
by removing the R26 and R33 0Ohm resistors to disconnect off the Micro-SD, and those will be accessible
from JP5 connector

To enable the ADC[2,4-6], remove any 0Ohm resistors if required (see above), and define in your
application `ADC_SENSORS_CONF_ADCx_PIN` and set its value with the corresponding pin number (i.e
ADC2 to 4 as mapped to PA4). To disable any ADC[1-6] just define as above, but set to (-1) instead.

Sensor Operating Voltage Operating Port input


current
MQ131 5V 150 mA ADC
Multichannel Gas sensor 3-5V 45.54 mA I2C
1.0
PM10 5V 20 mA ADC
Noise 3.5-10V 26.5 mA ADC

Ozone: MQ131 (ppm, ppb, mg_m3, ug_m3)

 Heater consumes at least 150 mA. So, don't connect it directly on a pin


of the Arduino.
Multichannel gas sensor – Grove:
CO: 1-1000 ppm

NO2 0.05-10 ppm

C2H6OH 10-500 ppm

H2: 1-1000 ppm

NH3: 1-500 ppm

CH4: > 1000 ppm

Propane C3H8 >1000ppm

C4H10 > 1000ppm


Electrical Characteristics:

I max = 0.15 W / 3.3 V ≃ 45.54 mA

PM10 GP2Y10:
Partículas de polvo: 0.5V por cada 0.1mg/m^3

Consumo en torno a los 20mA, Vcc entre los 0-7V

Loudness Sensor v0.9b:


I typ=¿26 mA

Voltage: 3.5~10v
Power requirements of sensors:

MQ131:

Multichannel Gas Sensor- Grove

You might also like