Professional Documents
Culture Documents
STEP 1:
STEP 2: Double Click the 4/n way valve and click the symbols shown in the picture below. Choose the roller in the
mechanically in both left and right. Same goes with the spring returned in both left and right actuation.
STEP 3: Double click your 3/2 way valve and choose the pushbutton with the spring returned in the right actuation. Do
this step with the other one 3/2 way vavle.
STEP 4: Click the all terminator 3 and change the connection line into the symbol shown in the picture. Except for the
terminator on 4/3 way vavle
STEP 5: Connect all the terminator from double acting cylinder to the compressor air supply/
STEP 6: Review your work if its functioning or not. If it is functioning the result would be like this
Laboratory 5
Pneumatic Circuit for Shuttle Valve Operation
Components used
The pneumatic components which can be used to implement the mentioned task are as follows:
STEP 2: Double click 5/2 way valve into pneumatically and click the connection design of both sides and change 14 on
the left and 12 on the right.
STEP 3: Change your 2 3/2 way valve into pushbutton and pedal button while the other one is roller. All of the 3/2 way
valve has the spring returned in the right actuation. And on the bottom change it into pushbutton on both right and left
actuation. Change also the bottom 3/2 way valve into the initial position.
STEP 4: Change all of your terminator no. 5 and 3 in 5/2 way valve and no.3 in all 3/2 way valve into the symbol shown
in the photo.
STEP 5: Connect all of the connection line from double acting cylinder to the air supply.
STEP 6: Double click your distance rule and encode the S3 and put the value of 100. After that, placed the label on the
3/2 way valve with roller.
STEP 7: Placed a text on the double acting cylinder as A, the 5/3 way valve as V2, shuttle valve as V1. As for the 3/2
way pushbutton label as S1, pedal button as S2, roller as S3 and both push button as S0. Additional information, labeled
the air service unit as Z0.
STEP 8: Review your work beforehand, if its working. It would show this;
Laboratory 6
Pneumatic Circuit for Embossing Application
Components used
The pneumatic components to be used to implement this task are:
• double acting cylinder
• 3/2 push button valve
• 3/2 roller valve • shuttle valve
• 5/3 pneumatic actuated direction control valve
• pressure sequence valve
• compressed air source
• pressure gauge and connecting piping