Professional Documents
Culture Documents
Technical Manual - Satellite MSP
Technical Manual - Satellite MSP
MSP
Medium Static Pressure
Slim Line
Ceiling Concealed Ducted Split Systems
Heat Pump
Rev. July 2014
53QDMT Series
12K - 18K - 24K - 30K - 36K - 42K - 48K - 60K
IAQ
Efficient Tropical Hydrophilic Auto 3 3 Minutes Self diagnostic
Anti-dust Filters Compressor Aluminum Fins Mode Min. Time Delay function
Fresh 40~100 Medium Stat- Super Independent De- Anti Anti-Freezing Refrigerant
Air Pa ic Pressures Quiet humidification Freezing
Protection Leak Detection
$ Efficient Inner Groove Auto Auto Auto Restart Defrost Easy Installation
Operation Copper Tubing Fan Speed Function Protection & Maintenance
Easy Installation, Service and Maintenance
Flexible two directions of air return : Remote system alarm function which required for
Back air return ( factory standard ) some applications such as computer rooms for fast Alarm
Bottom air return ( can be done at field ). and easy service and maintenance.
Back Bottom
Return Return
Air Air Optional drain pump which can lift the condensate
water up to 750 mm upmost.
Pre-Punched Fresh intake air built in the indoor Optinal drain pump is factory installed.
unit from both sides to make air quality more
healthy and more comfortable.
750mm
ceiling
motor
Blower
housing
Bottom
Panel
H
High Fan Speed indicator 7 TIMER ON or TIMER OFF function indicator
㩷 Auto Fan Speed indicator 8 LOCK function indicator
MSP
Medium Static Pressure
Ducted Split Air Conditioners
Wireless Remote control
Display Of Remote Control
2
1 AUTO COOL DRY HEAT FAN 3
5 SET TEMP.
o
CLOCK 6
㪈 㪊 4 TIMER ON
7
㪌
㪋 㪉 9 TIMER OFF
3. UNIT MODELS 8
8. REFRIGERATION CYCLES 25
0
1. Key Features
1
Key Features (Cont.)
2
Key Features (Cont.)
3
Key Features (Cont.)
4
Key Features (Cont.)
1 2 3 4 5 6 7
The display panel id indoor unit contains the following function indicators :
1 MANUAL Button
* This button is used to operate the unit temporarily in case you misplace
the remote control or its batteries are exhausted.
* Once you push temporary button, the air conditioner will run in such order :
Auto, Forced cool, off and back to Auto
AUTO
The OPERATION lamp is lit, and the air conditioner will run under AUTO mode.
The remote controller operation is enabled to operate according to the received signal.
FORCED COOL
The OPERATION lamp flashes, the air conditioner will turn to AUTO after it is enforced to cool
with a wind speed of HIGH for 30 minutes. The remote controller operation is disabled.
OFF
The OPERATION lamp goes off. The air conditioner is OFF while the remote controller operation
is enabled.
5
Key Features (Cont.)
The electronic printed circuit board in the indoor unit is equipped with
smart self diagnostic function which automatically stops the operation of
the air conditioner in case of a malfunction.
Leds Status and Error Code on the display panel of indoor unit ( all sizes ) refer to
malfunction reason for easy fast service and maintenance.
EEPROM malfunction E7
Pump temperature sensor malfunction
( option ) E5
Water-level alarm malfunction E8
Refrigerant leak X X EC
= Light = Flash at 5Hz = OFF
Leds status on the PCB of outdoor unit only sizes 36K – 42K – 48K and 60K ( 3Ph ) refers to malfunction reason
Protection function operates if a malfunction happens in the outdoor unit as below by leds of PCB of outdoor unit as follows:
Malfunction Reason LED 1 LED 2 LED 3
No defect off off on
Phase reversal on off on
Overload of current off on on
Phase loss on on on
NOTES
1- Prior to the malfunction repair, disconnect the electrical mains supply by moving the circuit breaker to OFF position.
2- After repairing the malfunction, connect the electrical main supply by moving the circuit breaker to ON position
and operate the air conditioner by using the wireless remote control or using wired room controller.
6
2. Unit Model Identification
53 Q D M T 18 - 7 1 8
Source
8 = Miraco Sourced Product
Control Type
1 = Standard Wired Control
Power Supply
7 = 220-240V / 1ph / 50Hz
5 = 380-420V / 3ph / 50Hz
Climate Type
T = High Ambient
Family Type
D = Ducted
System Type
Q = Heat Pump
Numeric Code
53 = Complete Split System
42 = Indoor Unit
38 = Outdoor Unit
7
3. Unit Models
8
4. Ducted Split System Description
9
6. Dimensions & Weights
6.1 Ducted Indoor Units Dimensions (mm) & Weights
Weight Supply air Return air Size of
Indoor Unit Outline dimesions
opening size opening size Mounted lug
Model Kg
A B C D E F G H I J K L M
42QDMT12 20 700 210 635 570 65 493 35 119 595 200 80 740 350
42QDMT18 24 920 210 635 570 65 713 35 119 815 200 80 960 350
42QDMT24 28 920 270 635 570 65 713 35 179 815 260 20 960 350
42QDMT30
42 1140 270 775 710 65 933 35 179 1035 260 20 1180 490
42QDMT36
42QDMT42
42QDMT48 48 1200 300 865 800 80 968 40 204 1094 288 45 1240 500
42QDMT60
Outline dimensions (mm)
Supply air opening size
G
H
B
E F D
A C
Back return air opening size
I Air Filter
Air Filter
13
Dimensions & Weights (Cont.)
6.2 Outdoor Units Dimensions & Weights
DIMENSIONS (mm)
Mounting Unit
Dimensions Dimensions Weight
Model (mm) (mm)
H
A B W H D Kg
B D
860 305
350
860
Weight
Model Kg
38QDMT48 1150
91
38QDMT60 92
14
7. Technical Specifications - Units
Outdoor Unit Model 38QDMT12-718
Model PH210M2A-4FTS1
Type Rotary Tropical
Supplier GMCC / Toshiba
Capacity ( @ 220/240V ) ± 5% Btu/h 12760 / 12860
Input ( @ 220/240V ) ± 5% W 1181 / 1280
Compressor Rated current ( @ 220/240V ) ± 5% A 5.62 / 6.16
Locked rotor Amp( + 10% ) A 33.6
Thermal protector position Internal
Capacitor uF / V 35 uF / 370 V
Refrigerant oil SUNISO 4G5D or NM56EP or Eqv
oil charge ml 440
Model YDK24-6-12
Supplier Welling
Outdoor fan motor Input W 1/10
Capacitor uF / V 2.5 uF / 450 V
Speed r/min 865
Number of rows 1
Tube pitch(a)× row pitch(b) mm 21 x 13.37
Fin spacing mm 1.6
Outdoor coil Fin type (code) Uncoated Aluminum
Tube outside dia.and type mm Ø 7, inner groove tube
Coil length × height × width mm 750 x 518 x 13.37
Number of circuits 2
Restrictor Size Cool / Heat C 0.041 / H 0.035
3
Outdoor air flow cfm (m /h) 1062 ( 1800 )
Dimension (W*H*D) mm 780 x 540 x 250
Outdoor unit Packing (W*H*D) mm 875 x 560 x 310
Net/Gross weight Kg 34 / 37
Indoor Unit Model 42QDMT12-718
Model YSK24-4C
Supplier Welling
Indoor fan motor Input W 62 / 42 / 36
Capacitor uF 2 uF / 450 V
Speed(Hi/Mi/Lo) r/min 1180 / 830 / 730
Number of rows 3
Tube pitch(a)× row pitch(b) mm 21 x 13.37
Fin spacing mm 1.5
Indoor coil Fin type (code) Precoated Hydrophilic Aluminum
Tube outside dia.and type mm Ø 7, inner groove tube
Coil length × height × width mm 515 x 252 x 40.11
Number of circuits 4
Dimension (W*H*D) mm 700 x 210 x 635
Indoor unit Packing (W*H*D) mm 915 x 290 x 655
Net/Gross weight kg 20 / 25
Installation Data
Power supply Ph-V-Hz 1Ph, 220-240V∼, 50Hz
Refrigerant type / quantity g R22 / 760
Design pressure MPa 2.94 / 1.0
Liquid side/ Gas side mm(inch) Ø 6.35 / Ø 12.7 ( 1/4" / 1/2" )
Refrigerant piping Max. refrigerant pipe length m 10
Max. difference in level m 4
Drainage water pipe outside diameter mm ODØ 25
Control type Wired Control / Wireless Remote Control
Operation temperature Ԩ 17 ~ 30
Ambient temperature (cooling/heating) Ԩ 21 ~ 52 / 2 ~ 24
15
Technical Specifications - Units (Cont.)
Outdoor Unit Model 38QDMT18-718
Model PH340X3C-4KTS1
Type Rotary Tropical
Supplier GMCC / Toshiba
Capacity ( @ 220/240V ) ± 5% Btu/h 20640 / 20860
Input ( @ 220/240V ) ± 5% W 1890 / 2050
Compressor Rated current ( @ 220/240V ) ± 5% A 8.75 / 9.30
Locked rotor Amp( + 10% ) A 53
Thermal protector position Internal
Capacitor uF / V 60 / 440
Refrigerant oil SUNISO 4GSD or NM56EP or Eqv
Oil charge ml 620
Model YDK48-6H (A)
Supplier Welling
Outdoor fan motor Output HP 1/10
Capacitor uF / V 3 / 450
Speed r/min 890
Number of rows 2
Tube pitch(a)× row pitch(b) mm 21 x 13.37
Fin spacing mm 1.8
Outdoor coil Fin type (code) Uncoated Aluminum
Tube outside dia.and type mm Ø 7, inner groove tube
Coil length × height × width mm 846 x 561 x 26.7
Number of circuits 4
Restrictor Size Cool / Heat C 0.052 / H 0.041
3
Outdoor air flow cfm (m /h) 1475 ( 2500 )
Dimension (W*H*D) mm 760 x 590 x 285
Outdoor unit Packing (W*H*D) mm 870 x 600 x 340
Net/Gross weight Kg 42 / 46
Indoor Unit Model 42QDMT18-718
Model YSK68-4P
Supplier Welling
Indoor fan motor Input W 107 / 65 / 52
Capacitor uF 3.5 / 450
Speed(Hi/Mi/Lo) r/min 1150 / 800 / 700
Number of rows 3
Tube pitch(a)× row pitch(b) mm 21×13.37
Fin spacing mm 1.5
Indoor coil Fin type (code) Hydrophilic aluminum
Tube outside dia.and type mm Ф7, inner groove tube
Coil length × height × width mm 735×252×40.11
Number of circuits 4
Dimension (W*H*D) mm 920 x 210 x 635
Indoor unit Packing (W*H*D) mm 1135 x 290 x 655
Net/Gross weight kg 24 / 29
Installation Data
Power supply Ph-V-Hz 1Ph, 220-240V∼, 50Hz
Refrigerant type / quantity g R22 / 1000
Design pressure MPa 2.94 / 1.0
Liquid side/ Gas side mm(inch) Ф6.35 / Ф12.7 ( 1/4" / 1/2" )
Refrigerant piping Max. refrigerant pipe length m 20
Max. difference in level m 10
Drainage water pipe outside diameter mm ODØ 25
Control type Wired Control / Wireless Remote Control
Operation temperature Ԩ 17 ~ 30
Ambient temperature (cooling/heating) Ԩ 21 ~ 52 / 2 ~ 24
16
Technical Specifications - Units (Cont.)
Outdoor Unit Model 38QDMT24-718
Model 2V40S225BUB
Type Rotary Tropical
Supplier Panasonic
Capacity ( @ 220/240V ) ± 5% Btu/h 23130 / 23235
Input ( @ 220/240V ) ± 5% W 2255 / 2370
Compressor Rated current ( @ 220/240V ) ± 5% A 10.5 / 10.5
Locked rotor Amp( + 10% ) A 79
Thermal protector position Internal
Capacitor uF / V 60 / 440
Refrigerant oil ATMOS NM56M or SUNISO 4GDID
Oil charge ml 750
Model YDK75-6T
Supplier Welling
Outdoor fan motor Output HP 1/10 ( 75 )
Capacitor uF / V 5 uF / 370 V
Speed r/min 860
Number of rows 2
Tube pitch(a)× row pitch(b) mm 25.4 x 22
Fin spacing mm 1.8
Outdoor coil Fin type (code) Uncoated Aluminum
Tube outside dia.and type mm Ø 9.52, inner groove tube
Coil length × height × width mm 832 x 561 x 44
Number of circuits 3
Restrictor Size Cool / Heat C 0.062 / H 0.052
3
Outdoor air flow cfm (m /h) 1390 ( 2355 )
Dimension (W*H*D) mm 860 x 575 x 350
Outdoor unit Packing (W*H*D) mm 960 x 600 x 415
Net/Gross weight Kg 57.7 / 61.7
Indoor Unit Model 42QDMT24-718
Model YSK74-4P
Supplier Welling
Indoor fan motor Input W 163/93/75
Capacitor uF 3.5uF/450V
Speed(Hi/Mi/Lo) r/min 1000/750/680
Number of rows 4
Tube pitch(a)× row pitch(b) mm 21×13.37
Fin spacing mm 1.5
Indoor coil Fin type (code) Precoated Hydrophilic Aluminum
Tube outside dia.and type mm Ф7, inner groove tube
Coil length × height × width mm 735 x 252 x 53.48
Number of circuits 6
Dimension (W*H*D) mm 920 x 270 x 635
Indoor unit Packing (W*H*D) mm 1135 x 350 x 655
Net/Gross weight kg 28 / 33
Installation Data
Power supply Ph-V-Hz 1Ph, 220-240V∼, 50Hz
Refrigerant type / quantity g R22 / 1500
Design pressure MPa 2.94 / 1.0
Liquid side/ Gas side mm(inch) Ф9.52 / Ф15.9 ( 3/8" / 5/8" )
Refrigerant piping Max. refrigerant pipe length m 20
Max. difference in level m 10
Drainage water pipe outside diameter mm ODØ 25
Control type Wired Control / Wireless Remote Control
Operation temperature Ԩ 17 ~ 30
Ambient temperature (cooling/heating) Ԩ 21 ~ 52 / 2 ~ 24
17
Technical Specifications - Units (Cont.)
Outdoor Unit Model 38QDMT30-718
Model NHT52VBET
Type Rotary Tropical
Supplier Mitsubishi
Capacity ( @ 220/240V ) ± 5% Btu/h 31800 / 32070
Input ( @ 220/240V ) ± 5% W 9320 / 9400
Compressor Rated current ( @ 220/240V ) ± 5% A 14.1 / 14.1
Locked rotor Amp( + 10% ) A 86 / 94
Thermal protector position Internal
Capacitor uF / V 60 uF / 440 V
Refrigerant oil Diamond MS 56 or Eqv
Oil charge ml 1300
Model YDK75-6T
Supplier Welling
Outdoor fan motor Output HP 1/10 ( 75 )
Capacitor uF / V 5 uF / 370 V
Speed r/min 860
Number of rows 2
Tube pitch(a)× row pitch(b) mm 25.4 x 22
Fin spacing mm 1.8
Outdoor coil Fin type (code) Uncoated Aluminum
Tube outside dia.and type mm Ø 9.52, inner groove tube
Coil length × height × width mm 832 x 561 x 44
Number of circuits 3
Restrictor Size Cool / Heat C 0.082 / H 0.057
3
Outdoor air flow cfm (m /h) 1390 ( 2355 )
Dimension (W*H*D) mm 860 x 575 x 350
Outdoor unit Packing (W*H*D) mm 960 x 600 x 415
Net/Gross weight Kg 61.4 / 65.4
Indoor Unit Model 42QDMT30-718
Model YSK140-4P
Brand Welling
Indoor fan motor Input W 168 /
Capacitor uF 10 uF / 450 V
Speed(Hi/Mi/Lo) r/min 790 / 210 / 640
Number of rows 4
Tube pitch(a)× row pitch(b) mm 21 x 13.37
Fin spacing mm 1.5
Indoor coil Fin type (code) Precoated Hydrophilic Aluminum
Tube outside dia.and type mm Ø 7, inner groove tube
Coil length × height × width mm 955 x 336 x 53.48
Number of circuits 8
Dimension (W*H*D) mm 1140 x 270 x 775
Indoor unit Packing (W*H*D) mm 1355 x 350 x 795
Net/Gross weight kg 42 / 46
Installation Data
Power supply Ph-V-Hz 1Ph, 220-240V∼, 50Hz
Refrigerant type / quantity g R22 / 1650
Design pressure MPa 2.94 / 1.0
Liquid side/ Gas side mm(inch) Ф9.52 / Ф19 ( 3/8" / 3/4" )
Refrigerant piping Max. refrigerant pipe length m 20
Max. difference in level m 10
Drainage water pipe outside diameter mm ODØ 25
Control type Wired Control / Wireless Remote Control
Operation temperature Ԩ 17 ~ 30
Ambient temperature (cooling/heating) Ԩ 21 ~ 52 / 2 ~ 24
18
Technical Specifications - Units (Cont.)
Outdoor Unit Model 38QDMT36-718
Model CR47KQM-PFZ
Type Reciprocating Tropical
Supplier Copeland
Capacity ( @ 220V ) ± 5% Btu/h 40700
Input ( @ 220V ) ± 5% W 3950
Compressor Rated current ( @ 220V ) ± 5% A 20
Locked rotor Amp ( @ 220V ) A 110
Thermal protector position Internal
Capacitor uF / V 60 uF / 440 V
Refrigerant oil Mineral
Oil charge ml 1330
Model YDK150-4H
Supplier Welling
Outdoor fan motor Output HP 1/6 ( 127 )
Capacitor uF / V 7.5 uF / 440 V
Speed r/min 1030
Number of rows 2
Tube pitch(a)× row pitch(b) mm 25.4 x 19.05
Fin spacing mm 1.7
Outdoor coil Fin type (code) Uncoated Aluminum
Tube outside dia.and type mm Ф9.52,inner grooved tube
Coil length × height × width mm 832 x 713 x 38.1
Number of circuits 4
Restrictor Size Cool / Heat C 0.071 / H 0.058
3
Outdoor air flow cfm (m /h) 2080 ( 3526 )
Dimension (W*H*D) mm 860 x 720 x 350
Outdoor unit Packing (W*H*D) mm 960 x 745 x 415
Net/Gross weight Kg 80 / 84
Indoor Unit Model 42QDMT36-718
Model YSK140-4P
Supplier Welling
Indoor fan motor Input W 291 / 168 / 138
Capacitor uF 10 uF / 450 V
Speed(Hi/Mi/Lo) r/min 1070 / 790 / 710
Number of rows 4
Tube pitch(a)× row pitch(b) mm 21 x 13.37
Fin spacing mm 1.5
Indoor coil Fin type (code) Precoated Hydrophilic Aluminum
Tube outside dia.and type mm Ф7,Inner grooved tube
Coil length × height × width mm 955 x 336 x 53.48
Number of circuits 8
Dimension (W*H*D) mm 1140 x 270 x 775
Indoor unit Packing (W*H*D) mm 1355 x 350 x 795
Net/Gross weight kg 42 / 46
Installation Data
Power supply Ph-V-Hz 1Ph, 220-240V∼, 50Hz
Refrigerant type / quantity g R22 / 1800
Design pressure MPa 2.94/1.0
Liquid side/ Gas side mm(inch) Ф9.52 / Ф19 ( 3/8" / 3/4" )
Refrigerant piping Max. refrigerant pipe length m 25
Max. difference in level m 10
Drainage water pipe outside diameter mm ODØ 25
Control type Wired Control / Wireless Remote Control
Operation temperature Ԩ 17 ~ 30
Ambient temperature (cooling/heating) Ԩ 21 ~ 52 / 2 ~ 24
19
Technical Specifications - Units (Cont.)
Outdoor Unit Model 38QDMT36-518
Model C-SB303H8A
Type Scroll Tropical
Supplier Sanyo
Capacity ( @ 220V ) ± 5% Btu/h 40260
Input ( @ 220V ) ± 5% W 3650
Compressor Rated current ( @ 220V ) ± 5% A 6.5
Locked rotor Amp ( @ 220V ) A 48
Thermal protector position Internal
Capacitor uF / V SAY56T
Refrigerant oil 1700 / 1600
Oil charge ml YDK150-4H
Model YDK150-4H
Supplier Welling
Outdoor fan motor Output HP 1/6 ( 127 )
Capacitor uF / V 7.5 uF / 440 V
Speed r/min 1030
Number of rows 2
Tube pitch(a)× row pitch(b) mm 25.4 x 19.05
Fin spacing mm 1.7
Outdoor coil Fin type (code) Uncoated Aluminum
Tube outside dia.and type mm Ф9.52,inner grooved tube
Coil length × height × width mm 832 x 713 x 38.1
Number of circuits 4
Restrictor Size Cool / Heat C 0.088 / H 0.064
3
Outdoor air flow cfm (m /h) 2080 ( 3526 )
Dimension (W*H*D) mm 8
Outdoor unit Packing (W*H*D) mm 960 x 745 x 415
Net/Gross weight Kg 80 / 84
Indoor Unit Model 42QDMT36-718
Model YSK140-4P
Brand Welling
Indoor fan motor Input W 291 / 168 / 138
Capacitor uF 10 uF / 450 V
Speed(Hi/Mi/Lo) r/min 1070 / 790 / 710
Number of rows 4
Tube pitch(a)× row pitch(b) mm 21 x 13.37
Fin spacing mm 1.5
Indoor coil Fin type (code) Precoated Hydrophilic Aluminum
Tube outside dia.and type mm Ф7,Inner grooved tube
Coil length × height × width mm 955 x 336 x 53.48
Number of circuits 8
Dimension (W*H*D) mm 1140 x 270 x 775
Indoor unit Packing (W*H*D) mm 1355 x 350 x 795
Net/Gross weight kg 42 / 46
Installation Data
Power supply Ph-V-Hz 3Ph, 380-420V∼, 50Hz
Refrigerant type / quantity g R22 / 1800
Design pressure MPa 2.94/1.0
Liquid side/ Gas side mm(inch) Ф9.52 / Ф19 ( 3/8" / 3/4" )
Refrigerant piping Max. refrigerant pipe length m 25
Max. difference in level m 10
Drainage water pipe outside diameter mm ODØ 25
Control type Wired Control / Wireless Remote Control
Operation temperature Ԩ 17 ~ 30
Ambient temperature (cooling/heating) Ԩ 21 ~ 52 / 2 ~ 24
20
Technical Specifications - Units (Cont.)
Outdoor Unit Model 38QDMT42-718
Model CR47KQM-PFZ
Type Reciprocating Tropical
Supplier Copeland
Capacity ( @ 220V ) ± 5% Btu/h 40700
Input ( @ 220V ) ± 5% W 3950
Compressor Rated current ( @ 220V ) ± 5% A 20
Locked rotor Amp ( @ 220V ) A 110
Thermal protector position Internal
Capacitor uF / V 60 uF / 440 V
Refrigerant oil Mineral
Oil charge ml 1330
Model YDK150-4H
Supplier Welling
Outdoor fan motor Output HP ( W ) 1/6 ( 127 )
Capacitor uF / V 7.5 uF / 440 V
Speed r/min 1030
Number of rows 2
Tube pitch(a)× row pitch(b) mm 25.4 x 19.05
Fin spacing mm 1.7
Outdoor coil Fin type (code) Uncoated Aluminum
Tube outside dia.and type mm Ф9.52,inner grooved tube
Coil length × height × width mm 832 x 713 x 38.1
Number of circuits 4
Restrictor Size Cool / Heat C 0.077 / H 0.066
3
Outdoor air flow cfm (m /h) 2080 ( 3526 )
Dimension (W*H*D) mm 860 x 720 x 350
Outdoor unit Packing (W*H*D) mm 960 x 745 x 415
Net/Gross weight Kg 81 / 85
Indoor Unit Model 42QDMT42-718
Model YSK170-4P
Supplier Welling
Indoor fan motor Input W 356/201/152
Capacitor uF 10uF/450V
Speed(Hi/Mi/Lo) r/min 1070/750/650
Number of rows 4
Tube pitch(a)× row pitch(b) mm 21×13.37
Fin spacing mm 1.5
Indoor coil Fin type (code) Precoated Hydrophilic Aluminum
Tube outside dia.and type mm Ф7,Inner grooved tube
Coil length × height × width mm 1030×378×53.48
Number of circuits 8
Dimension (W*H*D) mm 1200 x 300 x 865
Indoor unit Packing (W*H*D) mm 1385 x 373 x 920
Net/Gross weight kg 48 / 56
Installation Data
Power supply Ph-V-Hz 1Ph, 220-240V∼, 50Hz
Refrigerant type / quantity g R22 / 1850
Design pressure MPa 2.94 / 1.0
Liquid side/ Gas side mm(inch) Ф9.52 / Ф19 ( 3/8" / 3/4" )
Refrigerant piping Max. refrigerant pipe length m 30
Max. difference in level m 15
Drainage water pipe outside diameter mm ODØ 25
Control type Wired Control / Wireless Remote Control
Operation temperature Ԩ 17 ~ 30
Ambient temperature (cooling/heating) Ԩ 21 ~ 52 / 2 ~ 24
21
Technical Specifications - Units (Cont.)
Outdoor Unit Model 38QDMT42-518
Model C-SB303H8A
Type Scroll Tropical
Supplier Sanyo
Capacity ( @ 220V ) ± 5% Btu/h 40260
Input ( @ 220V ) ± 5% W 3650
Compressor Rated current ( @ 220V ) ± 5% A 6.5
Locked rotor Amp ( @ 220V ) A 48
Thermal protector position Internal
Capacitor uF / V SAY56T
Refrigerant oil 1700 / 1600
Oil charge ml 1330
Model YDK150-4H
Supplier Welling
Outdoor fan motor Output HP ( W ) 1/6 ( 127 )
Capacitor uF / V 7.5 uF / 440 V
Speed r/min 1030
Number of rows 2
Tube pitch(a)× row pitch(b) mm 25.4 x 19.05
Fin spacing mm 1.7
Outdoor coil Fin type (code) Uncoated Aluminum
Tube outside dia.and type mm Ф9.52,inner grooved tube
Coil length × height × width mm 832 x 713 x 38.1
Number of circuits 4
Restrictor Size Cool / Heat C 0.079 / H 0.068
3
Outdoor air flow cfm (m /h) 2080 ( 3526 )
Dimension (W*H*D) mm 860 x 720 x 350
Outdoor unit Packing (W*H*D) mm 960 x 745 x 415
Net/Gross weight Kg 81 / 85
Indoor Unit Model 42QDMT42-718
Model YSK170-4P
Brand Welling
Indoor fan motor Input W 356/201/152
Capacitor uF 10uF/450V
Speed(Hi/Mi/Lo) r/min 1070/750/650
Number of rows 4
Tube pitch(a)× row pitch(b) mm 21×13.37
Fin spacing mm 1.5
Indoor coil Fin type (code) Precoated Hydrophilic Aluminum
Tube outside dia.and type mm Ф7,Inner grooved tube
Coil length × height × width mm 1030×378×53.48
Number of circuits 8
Dimension (W*H*D) mm 1200 x 300 x 865
Indoor unit Packing (W*H*D) mm 1385 x 373 x 920
Net/Gross weight kg 48 / 56
Installation Data
Power supply Ph-V-Hz 3Ph, 380-420V∼, 50Hz
Refrigerant type / quantity g R22 / 1850
Design pressure MPa 2.94 / 1.0
Liquid side/ Gas side mm(inch) Ф9.52 / Ф19 ( 3/8" / 3/4" )
Refrigerant piping Max. refrigerant pipe length m 30
Max. difference in level m 15
Drainage water pipe outside diameter mm ODØ 25
Control type Wired Control / Wireless Remote Control
Operation temperature Ԩ 17 ~ 30
Ambient temperature (cooling/heating) Ԩ 21 ~ 52 / 2 ~ 24
22
Technical Specifications - Units (Cont.)
Outdoor Unit Model 38QDMT48-518
Model C-SB303H8A
Type Scroll Tropical
Supplier Sanyo
Capacity ( @ 380 V ) ± 5% Btu/h 40260
Input ( @ 380 V ) ± 5% W 3650
Compressor
Rated current ( @ 380 V ) ± 5% A 6.5
Locked rotor Amp ( @ 380 V ) A 48
Thermal protector position Internal
Refrigerant oil uF / V SAY56T
Oil initial charge / recharge ml 1700 / 1600
Model YDK150-4H
Supplier Welling
Outdoor fan motor (1) Output HP ( W ) 1/6 ( 127 )
Capacitor uF / V 7.5 / 440
Speed r/min 1030
Model YDK150-4H
Supplier Welling
Outdoor fan motor (2) Output HP ( W ) 1/6 ( 127 )
Capacitor uF / V 7.5 / 440
Speed r/min 1030
Number of rows 2
Tube pitch(a)× row pitch(b) mm 22×19.05
Fin spacing mm 1.6
Outdoor coil Fin type (code) Hydrophilic aluminum
Tube outside dia.and type mm Ф7.94,inner grooved tube
Coil length × height × width mm 837×1100×38.1
Number of circuits 8
Restrictor Size Cool / Heat C 0.069 / H 0.054
3
Outdoor air flow cfm (m /h) 4160 ( 7055 )
Dimension (W*H*D) mm 860 x 1150 x 350
Outdoor unit Packing (W*H*D) mm 995 x 1170 x 415
Net/Gross weight Kg 90 / 95
Indoor Unit Model 42QDMT48-718
Model YSK170-4P
Supplier Welling
Input W 356/201/152
Indoor fan motor Capacitor uF 10uF/450V
Speed(Hi/Mi/Lo) r/min 1070/750/650
a.Number of rows 4
Tube pitch(a)× row pitch(b) mm 21×13.37
Fin spacing mm 1.5
Fin type (code) Precoated Hydrophilic Aluminum
Indoor coil Tube outside dia.and type mm Ф7,Inner grooved tube
Coil length × height × width mm 1030×378×53.48
Number of circuits 8
Model C-SB303H8A
Dimension (W*H*D) mm 1200 x 300 x 865
Indoor unit Packing (W*H*D) mm 1385 x 373 x 920
Net/Gross weight kg 48 / 56
Installation Data
Power supply Ph-V-Hz 3Ph, 380-420V∼, 50Hz
Refrigerant type / quantity g R22 / 3900
Design pressure MPa 2.94/1.0
Liquid side/ Gas side mm(inch) Ф9.52 / Ф19 ( 3/8" / 3/4" )
Refrigerant piping Max. refrigerant pipe length m 30
Max. difference in level m 15
Drainage water pipe outside diameter mm ODØ 25
Control type Wired Control / Wireless Remote Control
Operation temperature Ԩ 17 ~ 30
Ambient temperature (cooling/heating) Ԩ 21 ~ 52 / 2 ~ 24
23
Technical Specifications - Units (Cont.)
Outdoor Unit Model 38QDMT60-518
Model ZR61KH-TFD-522
Type Scroll Tropical
Supplier Copeland
Capacity ( @ 380 V ) ± 5% Btu/h 51100
Input ( @ 380 V ) ± 5% W 4440
Compressor
Rated current ( @ 380 V ) ± 5% A 7.8
Locked rotor Amp ( @ 380 V ) A 97
Thermal protector position Internal
Refrigerant oil uF / V Blended White – Mineral Oil
Oil initial charge / recharge ml 1774 / 1656
Model YDK150-4H
Supplier Welling
Outdoor fan motor (1) Output HP ( W ) 1/6 ( 127 )
Capacitor uF / V 7.5 / 440
Speed r/min 1030
Model YDK150-4H
Supplier Welling
Outdoor fan motor (2) Output HP ( W ) 1/6 ( 127 )
Capacitor uF / V 7.5 / 440
Speed r/min 1030
Number of rows 2
Tube pitch(a)× row pitch(b) mm 22×19.05
Fin spacing mm 1.6
Outdoor coil Fin type (code) Hydrophilic Aluminum
Tube outside dia.and type mm Ф7.94,inner grooved tube
Coil length × height × width mm 837×1100×38.1
Number of circuits 8
Restrictor Size Cool / Heat C 0.085 / H 0.068
3
Outdoor air flow cfm (m /h) 4160 ( 7055 )
Dimension (W*H*D) mm 900×1167×340
Outdoor unit Packing (W*H*D) mm 1032×1307×443
Net/Gross weight Kg 105/110
Indoor Unit Model 42QDMT60-718
Model YSK180-4P
Brand Welling
Indoor fan motor Input W 355 / 223 / 173
Capacitor uF 10 uF / 450 V
Speed(Hi/Mi/Lo) r/min 1080 / 830 / 710
Number of rows 4
Tube pitch(a)× row pitch(b) mm 21 x 13.37
Fin spacing mm 1.5
Indoor coil Fin type (code) Precoated Hydrophilic Aluminum
Tube outside dia.and type mm Ф7,Inner grooved tube
Coil length × height × width mm 1030 x 378 x 53.48
Number of circuits 8
Dimension (W*H*D) mm 1200 x 300 x 865
Indoor unit Packing (W*H*D) mm 1385 x 373 x 920
Net/Gross weight kg 48/56
Installation Data
Power supply Ph-V-Hz 3Ph, 380-420V∼, 50Hz
Refrigerant type / quantity g R22 / 2750
Design pressure MPa 2.94 / 1.0
Liquid side/ Gas side mm(inch) Ф9.52 / Ф19 ( 3/8" / 3/4" )
Refrigerant piping Max. refrigerant pipe length m 30
Max. difference in level m 15
Drainage water pipe outside diameter mm ODØ 25
Control type Wired Control / Wireless Remote Control
Operation temperature Ԩ 17 ~ 30
Ambient temperature (cooling/heating) Ԩ 21 ~ 52 / 2 ~ 24
24
8. Refrigeration Cycles
Ducted Split System
53QDMT12-718 Heat Pump
220-240V / 1Ph / 50Hz
42QDMT12-718
INDOOR UNIT
Indoor Coil
T2 Indoor Coil
Temp. sensor
T1 Air return
temperature sensor
Centrifugal Blowers
Connecting
Gas Liquid
Refrigerant
1/2" 1/4"
Piping Lines
Gas Liquid
Service Valve Service Valve
Reversing Valve
Compressor 38QDMT12-718
Rotary Tropical
GMCC / Toshiba
PH210M2A-4FTS1
Outdoor Coil
T3 Outdoor
Coil Temp.
sensor
Restrictor
C 0.041
OUTDOOR UNIT H 0.035
Propeller Fan
25
Refrigeration Cycles (Cont.)
Ducted Split System
53QDMT18-718 Heat Pump
220-240V / 1Ph / 50Hz
42QDMT18-718
INDOOR UNIT
Indoor Coil
T2 Indoor Coil
Temp. sensor
T1 Air return
temperature sensor
Centrifugal Blowers
Connecting
Gas Refrigerant Liquid
1/2" 1/4"
Piping Lines
Gas Liquid
Service Valve Service Valve
Reversing Valve
Compressor
Rotary Tropical
GMCC / Toshiba
PH340G2C-4KTS1 38QDMT18-718
Outdoor Coil
T3 Outdoor
Coil Temp.
sensor
Restrictor
C 0.041
OUTDOOR UNIT H 0.035
Propeller Fan
26
Refrigeration Cycles (Cont.)
Ducted Split System
53QDMT24-718 Heat Pump
220-240V / 1Ph / 50Hz
42QDMT24-718
INDOOR UNIT
Indoor Coil
T2 Indoor Coil
Temp. sensor
T1 Air return
temperature sensor
Centrifugal Blowers
Connecting
Gas Liquid
Refrigerant
5/8" 3/8"
Piping Lines
Gas Liquid
Service Valve Service Valve
Reversing Valve
Compressor
Rotary Tropical
Panasonic
2V40S225BUB
38QDMT24-718
Outdoor Coil
T3 Outdoor
Coil Temp.
sensor
Restrictor
C 0.062
H 0.052
OUTDOOR UNIT Propeller Fan
27
Refrigeration Cycles (Cont.)
Ducted Split System
53QDMT30-718 Heat Pump
220-240V / 1Ph / 50Hz
42QDMT30-718
INDOOR UNIT
Indoor Coil
T2 Indoor Coil
Temp. sensor
T1 Air return
temperature sensor
Centrifugal Blowers
Connecting Liquid
Gas
Refrigerant 3/8"
3/4"
Piping Lines
Gas Liquid
Service Valve Service Valve
Reversing Valve
Compressor
Rotary Tropical
Mitsubishi
NHT52VBET
T3 Outdoor
Coil Temp.
sensor
Restrictor
C 0.082
OUTDOOR UNIT H 0.057
Propeller Fan
28
Refrigeration Cycles (Cont.)
Ducted Split System
53QDMT36-718 Heat Pump
220-240V / 1Ph / 50Hz
42QDMT36-718
INDOOR UNIT
Indoor Coil
T2 Indoor Coil
Temp. sensor
T1 Air return
temperature sensor
Centrifugal Blowers
Connecting
Gas Refrigerant Liquid
3/4" Piping Lines 3/8"
Gas Liquid
Service Valve Service Valve
Reversing Valve
Accumulator
Compressor
Reciprocating Tropical
Copeland
CR47KQM-PFZ
38QDMT36-718
Outdoor Coil
T3 Outdoor
Coil Temp.
sensor
Restrictor
C 0.071
H 0.058
OUTDOOR UNIT Propeller Fan
29
Refrigeration Cycles (Cont.)
Ducted Split System
53QDMT36-518 Heat Pump
380-420V / 3Ph / 50Hz
42QDMT36-718
INDOOR UNIT
Indoor Coil
T2 Indoor Coil
Temp. sensor
T1 Air return
temperature sensor
Centrifugal Blowers
Connecting
Gas Refrigerant Liquid
3/4" Piping Lines 3/8"
Gas Liquid
Service Valve Service Valve
Reversing Valve
Accumulator
Compressor
Scroll Tropical
Sanyo
C-SB303H8A
38QDMT36-518
Outdoor Coil
T3 Outdoor
Coil Temp.
sensor
Restrictor
C 0.071
H 0.058
OUTDOOR UNIT Propeller Fan
30
Refrigeration Cycles (Cont.)
Ducted Split System
53QDMT42-718 Heat Pump
220-240V / 1Ph / 50Hz
42QDMT42-718
INDOOR UNIT
Indoor Coil
T2 Indoor Coil
Temp. sensor
T1 Air return
temperature sensor
Centrifugal Blowers
Connecting
Gas Refrigerant Liquid
3/4" Piping Lines 3/8"
Gas Liquid
Service Valve Service Valve
Reversing Valve
Accumulator
Compressor
Reciprocating Tropical
Copeland
CR47KQM-PFZ
38QDMT42-718
Outdoor Coil
T3 Outdoor
Coil Temp.
sensor
Restrictor
C 0.077
H 0.066
OUTDOOR UNIT Propeller Fan
31
Refrigeration Cycles (Cont.)
Ducted Split System
53QDMT42-518 Heat Pump
380-420V / 3Ph / 50Hz
42QDMT42-718
INDOOR UNIT
Indoor Coil
T2 Indoor Coil
Temp. sensor
T1 Air return
temperature sensor
Centrifugal Blowers
Connecting
Gas Refrigerant Liquid
3/4" Piping Lines 3/8"
Gas Liquid
Service Valve Service Valve
Reversing Valve
Accumulator
Compressor
Scroll Tropical
Sanyo
C-SB303H8A
38QDMT42-518
Outdoor Coil
T3 Outdoor
Coil Temp.
sensor
Restrictor
C 0.077
H 0.066
OUTDOOR UNIT Propeller Fan
32
Refrigeration Cycles (Cont.)
Ducted Split System
53QDMT48-518 Heat Pump
380-420V / 3Ph / 50Hz
42QDMT48-718
INDOOR UNIT
Indoor Coil
T2 Indoor Coil
Temp. sensor
T1 Air return
temperature sensor
Centrifugal Blowers
Connecting Liquid
Gas
Refrigerant 3/8"
3/4"
Piping Lines
Gas Liquid
Service Valve Service Valve
Reversing Valve
Accumulator
Compressor
Scroll Tropical
Sanyo
C-SB303H8A
T3 Outdoor
Coil Temp.
sensor
Restrictor
C 0.085
H 0.068
OUTDOOR UNIT Propeller Fan
33
Refrigeration Cycles (Cont.)
Ducted Split System
53QDMT60-518 Heat Pump
380-420V / 3Ph / 50Hz
42QDMT60-718
INDOOR UNIT
Indoor Coil
T2 Indoor Coil
Temp. sensor
T1 Air return
temperature sensor
Centrifugal Blowers
Connecting
Gas Refrigerant Liquid
3/4" Piping Lines 3/8"
Gas Liquid
Service Valve Service Valve
Reversing Valve
Accumulator
Compressor
Scroll Tropical
Copeland
ZR61KH-TFD-522
Outdoor Coil
38QDMT60-518
T3 Outdoor
Coil Temp.
sensor
Restrictor
C 0.085
H 0.068
OUTDOOR UNIT Propeller Fan
34
9. Air Flow Versus External Static Pressure Data For Ducted Indoor Unit
42QDMT12
in.wg 0 0.04 0.08 0.10 0.12 0.16
ESP
Test Pa 0 10 20 25 30 40
Volt cfm cfm cfm cfm cfm cfm
Air Flow 3 3 3 3 3 3
m /h m /h m /h m /h m /h m /h
42QDMT18
in.wg 0 0.04 0.08 0.10 0.12 0.16 0.20 0.24
ESP
Test Pa 0 10 20 25 30 40 50 60
Volt cfm cfm cfm cfm cfm cfm cfm cfm
Air Flow 3 3 3 3 3 3 3 3
m /h m /h m /h m /h m /h m /h m /h m /h
35
Air Flow Versus External Static Pressure Data For Ducted Indoor Unit (Cont.)
42QDMT24
in.wg 0 0.04 0.08 0.10 0.12 0.16 0.20 0.24
ESP
Test Pa 0 10 20 25 30 40 50 60
Volt cfm cfm cfm cfm cfm cfm cfm cfm
Air Flow 3 3 3 3 3 3 3 3
m /h m /h m /h m /h m /h m /h m /h m /h
42QDMT30
in.wg 0 0.04 0.08 0.12 0.15 0.16 0.20 0.24 0.28 0.32
ESP
Test Pa 0 10 20 30 37 40 50 60 70 80
Volt cfm cfm cfm cfm cfm cfm cfm cfm cfm cfm
Air Flow 3 3 3 3 3 3 3 3 3 3
m /h m /h m /h m /h m /h m /h m /h m /h m /h m /h
1080 1036 1005 976 954 947 915 883 851 819
230 High Speed
1831 1756 1703 1654 1617 1605 1551 1497 1442 1388
910 880 850 820 797 790 760 730 700 670
230 Medium Speed
1542 1492 1441 1390 1351 1339 1288 1237 1186 1136
645 596 562 525 502 495 453 411 369 327
230 Low Speed
1093 1010 952 890 851 839 768 697 625 554
36
Air Flow Versus External Static Pressure Data For Ducted Indoor Unit (Cont.)
42QDMT36
in.wg 0 0.04 0.08 0.12 0.15 0.16 0.20 0.24 0.28 0.32
ESP
Test Pa 0 10 20 30 37 40 50 60 70 80
Volt cfm cfm cfm cfm cfm cfm cfm cfm cfm cfm
Air Flow 3 3 3 3 3 3 3 3 3 3
m /h m /h m /h m /h m /h m /h m /h m /h m /h m /h
1080 1036 1005 976 954 947 915 883 851 819
230 High Speed
1831 1756 1703 1654 1617 1605 1551 1497 1442 1388
910 880 850 820 797 790 760 730 700 670
230 Medium Speed
1542 1492 1441 1390 1351 1339 1288 1237 1186 1136
645 596 562 525 502 495 453 411 369 327
230 Low Speed
1093 1010 952 890 851 839 768 697 625 554
42QDMT42
in.wg 0 0.04 0.08 0.12 0.16 0.20 0.24 0.28 0.32 0.36 0.40
ESP
Test Pa 0 10 20 30 40 50 60 70 80 90 100
Volt cfm cfm cfm cfm cfm cfm cfm cfm cfm cfm cfm
Air Flow 3 3 3 3 3 3 3 3 3 3 3
m /h m /h m /h m /h m /h m /h m /h m /h m /h m /h m /h
1370 1333 1300 1255 1223 1187 1151 1115 1079 1043 1007
230 High Speed
2322 2259 2203 2127 2073 2012 1951 1890 1829 1768 1707
1260 1223 1190 1145 1113 1077 1041 1005 969 933 897
230 Medium Speed
2136 2073 2017 1941 1886 1825 1764 1703 1642 1581 1520
715 668 636 594 548 491 434 377 320 263 206
230 Low Speed
1212 1132 1078 1007 929 832 736 639 542 446 349
37
Air Flow Versus External Static Pressure Data For Ducted Indoor Unit (Cont.)
42QDMT48
in.wg 0 0.04 0.08 0.12 0.16 0.20 0.24 0.28 0.32 0.36 0.40
ESP
Test Pa 0 10 20 30 40 50 60 70 80 90 100
Volt cfm cfm cfm cfm cfm cfm cfm cfm cfm cfm cfm
Air Flow 3 3 3 3 3 3 3 3 3 3 3
m /h m /h m /h m /h m /h m /h m /h m /h m /h m /h m /h
1370 1333 1300 1255 1223 1187 1151 1115 1079 1043 1007
230 High Speed
2322 2259 2203 2127 2073 2012 1951 1890 1829 1768 1707
1260 1223 1190 1145 1113 1077 1041 1005 969 933 897
230 Medium Speed
2136 2073 2017 1941 1886 1825 1764 1703 1642 1581 1520
715 668 636 594 548 491 434 377 320 263 206
230 Low Speed
1212 1132 1078 1007 929 832 736 639 542 446 349
42QDMT60
in.wg 0 0.04 0.08 0.12 0.16 0.20 0.24 0.28 0.32 0.36 0.40
ESP
Test Pa 0 10 20 30 40 50 60 70 80 90 100
Volt cfm cfm cfm cfm cfm cfm cfm cfm cfm cfm cfm
Air Flow 3 3 3 3 3 3 3 3 3 3 3
m /h m /h m /h m /h m /h m /h m /h m /h m /h m /h m /h
1470 1441 1405 1380 1345 1314 1283 1252 1221 1190 1159
230 High Speed
2492 2442 2381 2339 2280 2227 2175 2122 2070 2017 1964
1375 1346 1310 1285 1250 1219 1188 1157 1126 1095 1064
230 Medium Speed
2331 2281 2220 2178 2119 2066 2014 1961 1909 1856 1803
860 828 800 762 728 703 678 653 628 603 578
230 Low Speed
1458 1403 1356 1292 1234 1192 1149 1107 1064 1022 980
38
10. Sound Levels Versus External Static Data For Ducted Indoor Unit
Supply Return
Air Air
Ducted
Duct Indoor Unt Duct
42QDMT12
42QDMT18
Sound Level dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A)
High Speed 44.7 44.3 43.9 43.7 43.6 43.2 42.8 42.4
Medium Speed 40.5 40.1 39.7 38.0 39.3 38.9 38.5 38.1
Low Speed 31.6 31.2 30.8 30.6 30.4 30.0 29.6 29.2
42QDMT24
Sound Level dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A)
High Speed 47.2 46.8 46.4 46.2 46.1 45.7 45.3 44.9
Medium Speed 44.3 43.9 43.5 43.3 43.1 42.7 42.3 41.9
Low Speed 40.4 40.0 39.6 39.4 39.2 38.8 38.4 38.0
42QDMT30
in.wg 0 0.04 0.08 0.12 0.15 0.16 0.20 0.24 0.28 0.32
ESP
Pa 0 10 20 30 37 40 50 60 70 80
Sound Level dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A)
High Speed 51.5 51.1 50.7 50.4 50.1 50.0 49.6 49.2 48.9 48.6
Medium Speed 48.5 48.1 47.7 47.3 47.0 46.9 46.5 46.1 45.7 45.3
Low Speed 44.0 43.6 43.2 42.8 42.5 42.4 42.0 41.6 41.2 40.8
39
Sound Levels Versus External Static Data For Ducted Indoor Unit (Cont.)
42QDMT36
in.wg 0 0.04 0.08 0.12 0.15 0.16 0.20 0.24 0.28 0.32
ESP
Pa 0 10 20 30 37 40 50 60 70 80
Sound Level dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A)
High Speed 51.5 51.1 50.7 50.4 50.1 50.0 49.6 49.2 48.9 48.6
Medium Speed 48.5 48.1 47.7 47.3 47.0 46.9 46.5 46.1 45.7 45.3
Low Speed 44.0 43.6 43.2 42.8 42.5 42.4 42.0 41.6 41.2 40.8
42QDMT42
in.wg 0 0.04 0.08 0.12 0.16 0.20 0.24 0.28 0.32 0.36 0.40
ESP
Pa 0 10 20 30 40 50 60 70 80 90 100
Sound Level dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A)
High Speed 52.0 51.6 51.2 50.9 50.5 50.1 49.7 49.3 49.0 48.6 48.2
Medium Speed 48.1 47.7 47.3 46.9 46.5 45.7 45.7 45.3 44.9 44.5 44.1
Low Speed 42.4 42.0 41.6 41.2 40.8 40.4 40.0 39.6 39.2 38.8 38.4
42QDMT48
in.wg 0 0.04 0.08 0.12 0.16 0.20 0.24 0.28 0.32 0.36 0.40
ESP
Pa 0 10 20 30 40 50 60 70 80 90 100
Sound Level dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A)
High Speed 52.0 51.6 51.2 50.9 50.5 50.1 49.7 49.3 49.0 48.6 48.2
Medium Speed 48.1 47.7 47.3 46.9 46.5 46.1 45.7 45.3 44.9 44.5 44.1
Low Speed 42.4 42.0 41.6 41.2 40.8 40.4 40.0 39.6 39.2 38.8 38.4
42QDMT60
in.wg 0 0.04 0.08 0.12 0.16 0.20 0.24 0.28 0.32 0.36 0.40
ESP
Pa 0 10 20 30 40 50 60 70 80 90 100
Sound Level dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A)
High Speed 54.2 53.8 53.4 53.1 52.7 52.3 51.9 51.5 51.1 50.8 50.4
Medium Speed 51.1 50.7 50.3 49.9 49.5 49.1 48.7 48.3 47.9 47.5 47.1
Low Speed 44.9 44.6 44.2 43.9 43.5 43.2 42.9 42.5 42.2 41.8 41.5
40
11. Sound Levels Data For Outdoor Units
Outdoor Unit
Microphone
1m
38QDMT12-718 56
38QDMT18-718 57
38QDMT24-718 62
38QDMT30-718 62
38QDMT36-718 65
38QDMT42-718 65
38QDMT36-518 66
38QDMT42-518 66
38QDMT48-518 68
38QDMT60-518 69
41
12. Operating Limits - Cooling
COOLING
Dry Bulb Wet Bulb
Difference
Temp. C° Temp. C°
Indoor temperature
Maximum 32 23
Minimum 21 15
Outdoor temperature
Maximum 52 -
Minimum 20 -
53QDMT18-718
53QDMT24-718
220-240/1/50 198 254
53QDMT30-718
53QDMT36-718
53QDMT42-718
53QDMT36-518
53QDMT42-518
380-420/3/50 342 462
53QDMT48-518
53QDMT60-518
NOTES:
* When the system is operated above or below these limits for a long time,
system diagnostics may detect a malfunction and the unit will not operate properly.
42
13. System Cooling Performance Data
Ducted Split System
53QDMT12-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT12-718
38QDMT12-718
Indoor Conditions Outdoor Ambient Temperature
Temp. °C 35°C 43°C 46°C 52°C
Air
ESP Fan Capacity Capacity Capacity Capacity
Flow Input Input Input Input
in.wg Speed DB WB Btu/hr Btu/hr Btu/hr Btu/hr
cfm W W W W
Total Sensible Total Sensible Total Sensible Total Sensible
21 15 12105 9980 1195 11580 10025 1230 11300 9920 1245 10735 9710 1275
24 17 12475 10445 1240 11705 10150 1305 11460 10060 1330 10975 9870 1380
High 400
27 19 13000 10480 1265 12105 10230 1330 11700 10025 1355 10885 9610 1400
32 23 13530 12290 1325 12475 12000 1380 12110 11875 1395 11385 11630 1420
21 15 11500 9185 1150 11005 9225 1185 10735 9130 1200 10200 8935 1225
0 24 17 11855 9615 1195 11120 9340 1255 10890 9260 1280 10430 9085 1325
Medium 345
in.wg 27 19 12350 9645 1215 11500 9415 1280 11115 9225 1305 10345 8845 1345
32 23 12855 11310 1275 11855 11040 1325 11505 10925 1340 10820 10700 1365
21 15 10580 7810 1070 10125 7840 1100 9880 7765 1115 9385 7595 1140
24 17 10905 8170 1110 10235 7945 1170 10020 7870 1190 9595 7720 1235
Low 250
27 19 11365 8200 1130 10580 8000 1190 10230 7840 1210 9515 7520 1250
32 23 11830 9610 1185 10905 9390 1235 10585 9290 1250 9955 9095 1270
21 15 11860 9605 1180 11345 9820 1215 11070 9725 1230 10520 9520 1260
24 17 12225 10045 1225 11470 9950 1290 11235 9860 1315 10755 9670 1365
High 344
27 19 12740 10070 1250 11860 10030 1315 11465 9820 1340 10670 9415 1390
32 23 13250 11850 1310 12220 11750 1365 11860 11635 1380 11150 11395 1405
21 15 11270 8840 1135 10780 9040 1170 10520 8950 1185 9995 8760 1210
0.08 24 17 11615 9245 1180 10900 9155 1240 10675 9075 1265 10220 8905 1315
Medium 289
in.wg 27 19 12105 9265 1200 11270 9230 1265 10895 9040 1290 10140 8665 1335
32 23 12590 10905 1260 11610 10815 1315 11270 10705 1325 10595 10490 1350
21 15 10370 7515 1055 9920 7685 1085 9680 7610 1100 9195 7450 1125
24 17 10685 7855 1095 10025 7785 1155 9820 7710 1175 9400 7565 1220
Low 203
27 19 11135 7875 1120 10370 7845 1175 10025 7685 1200 9330 7365 1245
32 23 11585 9270 1170 10685 9190 1220 10370 9100 1235 9750 8915 1255
21 15 11800 9510 1175 11290 9775 1210 11015 9675 1225 10470 9475 1255
24 17 12165 9945 1220 11415 9905 1285 11180 9815 1310 10710 9630 1360
High 328
27 19 12675 9970 1245 11800 9980 1310 11410 9775 1335 10625 9370 1385
32 23 13180 11745 1305 12155 11690 1360 11795 11570 1375 11090 11335 1405
21 15 11215 8755 1130 10730 9000 1165 10470 8905 1180 9950 8715 1205
0.10 24 17 11555 9155 1175 10850 9115 1235 10625 9035 1260 10175 8865 1310
Medium 273
in.wg 27 19 12045 9175 1200 11215 9185 1260 10840 9000 1285 10095 8625 1330
32 23 12520 10805 1255 11550 10755 1310 11210 10645 1325 10535 10435 1350
21 15 10320 7440 1050 9870 7650 1085 9630 7570 1095 9155 7410 1125
24 17 10635 7780 1090 9980 7750 1150 9775 7680 1175 9360 7535 1215
Low 191
27 19 11080 7795 1115 10320 7810 1175 9975 7650 1195 9290 7335 1240
32 23 11520 9185 1170 10625 9145 1215 10315 9050 1230 9695 8865 1255
21 15 11740 9415 1170 11235 9730 1205 10960 9625 1220 10420 9425 1250
24 17 12100 9845 1215 11360 9860 1280 11125 9770 1305 10660 9590 1355
High 312
27 19 12610 9865 1240 11740 9930 1305 11350 9730 1330 10575 9325 1380
32 23 13105 11635 1300 12085 11625 1355 11730 11505 1370 11025 11270 1400
21 15 11155 8665 1125 10675 8955 1160 10415 8855 1175 9900 8670 1200
0.12 24 17 11495 9060 1170 10795 9075 1230 10570 8990 1255 10130 8825 1305
Medium 257
in.wg 27 19 11980 9080 1195 11155 9140 1255 10785 8955 1280 10050 8585 1325
32 23 12450 10705 1250 11485 10695 1305 11145 10585 1320 10475 10375 1345
21 15 10265 7365 1045 9820 7615 1080 9580 7530 1090 9110 7370 1120
24 17 10580 7700 1085 9930 7710 1145 9725 7645 1170 9320 7500 1210
Low 180
27 19 11025 7715 1110 10265 7770 1170 9920 7615 1190 9245 7300 1235
32 23 11455 9100 1165 10565 9095 1210 10255 9000 1225 9640 8815 1250
43
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT18-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT12-718
38QDMT12-718
Indoor Conditions Outdoor Ambient Temperature
Temp. °C 35°C 43°C 46°C 52°C
Air
ESP Fan Capacity Capacity Capacity Capacity
Flow Input Input Input Input
in.wg Speed DB WB Btu/hr Btu/hr Btu/hr Btu/hr
cfm W W W W
Total Sensible Total Sensible Total Sensible Total Sensible
21 15 11620 9225 1160 11115 9620 1195 10845 9525 1210 10300 9320 1240
24 17 11970 9635 1205 11235 9745 1270 11000 9655 1295 10535 9475 1345
High 275
27 19 12475 9650 1230 11620 9820 1295 11230 9620 1320 10450 9220 1370
32 23 12965 11415 1290 11960 11505 1345 11610 11390 1360 10920 11155 1390
21 15 11040 8490 1115 10560 8850 1150 10305 8765 1165 9785 8580 1195
0.16 24 17 11375 8865 1160 10675 8965 1220 10450 8890 1245 10010 8725 1295
Medium 220
in.wg 27 19 11855 8885 1185 11040 9040 1245 10670 8850 1270 9930 8485 1320
32 23 12320 10510 1240 11365 10585 1295 11030 10480 1310 10375 10265 1335
21 15 10160 7215 1040 9715 7525 1070 9480 7450 1085 9005 7295 1110
24 17 10465 7535 1080 9820 7625 1135 9615 7555 1160 9210 7410 1205
Low 156
27 19 10905 7550 1100 10160 7685 1160 9820 7525 1180 9135 7210 1225
32 23 11335 8930 1155 10455 9000 1205 10150 8910 1215 9545 8725 1245
44
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT18-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT18-718
38QDMT18-718
Indoor Conditions Outdoor Ambient Temperature
Temp. °C 35°C 43°C 46°C 52°C
Air
ESP Fan Capacity Capacity Capacity Capacity
Flow Input Input Input Input
in.wg Speed DB WB Btu/hr Btu/hr Btu/hr Btu/hr
cfm W W W W
Total Sensible Total Sensible Total Sensible Total Sensible
21 15 19070 14145 1865 18260 14220 1915 17835 14070 1935 16985 13770 1975
24 17 19690 14795 1940 18455 14400 2050 18030 14220 2085 17180 13860 2155
High 530
27 19 20500 14825 1985 19070 14505 2095 18455 14225 2135 17225 13665 2210
32 23 21315 17410 2080 19695 16985 2155 19080 16820 2175 17850 16500 2215
21 15 18120 13020 1795 17350 13085 1840 16945 12950 1860 16140 12670 1900
0 24 17 18710 13610 1865 17535 13250 1970 17130 13085 2005 16325 12755 2070
Medium 460
in.wg 27 19 19475 13645 1910 18120 13345 2015 17535 13085 2050 16365 12570 2125
32 23 20250 16020 2000 18715 15630 2070 18130 15475 2090 16960 15180 2130
21 15 16670 11065 1670 15960 11125 1710 15590 11010 1730 14845 10770 1765
24 17 17210 11575 1735 16130 11265 1835 15760 11125 1865 15020 10840 1925
Low 295
27 19 17920 11600 1775 16670 11345 1875 16130 11125 1910 15055 10690 1975
32 23 18630 13620 1860 17215 13285 1925 16680 13155 1945 15605 12905 1980
21 15 18275 13560 1850 17495 13625 1900 17090 13485 1920 16280 13205 1960
24 17 18865 14180 1925 17680 13800 2030 17275 13630 2070 16465 13285 2140
High 487
27 19 19640 14205 1965 18275 13900 2075 17680 13635 2115 16505 13105 2190
32 23 20420 16685 2060 18870 16275 2135 18280 16120 2155 17100 15815 2195
21 15 17365 12480 1780 16625 12540 1825 16240 12410 1845 15470 12150 1885
0.08 24 17 17925 13045 1850 16800 12700 1950 16415 12545 1990 15645 12225 2055
Medium 417
in.wg 27 19 18660 13075 1890 17365 12790 1995 16800 12545 2035 15680 12060 2105
32 23 19400 15350 1980 17930 14975 2050 17370 14835 2070 16245 14555 2110
21 15 15975 10610 1655 15295 10655 1700 14940 10550 1715 14230 10325 1750
24 17 16490 11090 1720 15455 10795 1815 15100 10660 1850 14395 10390 1915
Low 256
27 19 17170 11110 1755 15975 10875 1855 15455 10665 1890 14430 10250 1960
32 23 17850 13050 1840 16495 12730 1910 15980 12610 1925 14950 12375 1960
21 15 18075 13415 1845 17305 13480 1895 16905 13340 1915 16105 13065 1955
24 17 18660 14025 1920 17490 13650 2025 17090 13485 2065 16290 13145 2135
High 476
27 19 19425 14055 1960 18075 13750 2070 17490 13490 2110 16325 12960 2190
32 23 20200 16500 2055 18665 16100 2130 18080 15945 2150 16915 15645 2190
21 15 17175 12345 1775 16445 12405 1820 16065 12275 1840 15305 12025 1880
0.10 24 17 17730 12905 1845 16620 12565 1945 16235 12410 1985 15475 12095 2050
Medium 406
in.wg 27 19 18455 12935 1885 17175 12650 1990 16620 12410 2030 15510 11930 2105
32 23 19190 15185 1975 17735 14810 2045 17180 14675 2065 16070 14395 2105
21 15 15800 10495 1650 15130 10545 1695 14780 10435 1715 14080 10220 1750
24 17 16310 10970 1715 15290 10680 1810 14940 10545 1845 14240 10280 1910
Low 246
27 19 16980 10995 1755 15800 10755 1850 15290 10550 1885 14275 10140 1960
32 23 17655 12905 1840 16315 12590 1905 15805 12475 1925 14785 12240 1960
21 15 17875 13265 1840 17115 13335 1890 16720 13195 1910 15930 12925 1950
24 17 18455 13870 1915 17295 13500 2020 16900 13335 2060 16110 13000 2130
High 465
27 19 19210 13900 1955 17875 13600 2060 17295 13340 2105 16145 12815 2185
32 23 19975 16315 2050 18455 15920 2125 17875 15770 2145 16725 15470 2185
21 15 16985 12205 1770 16260 12270 1815 15885 12140 1835 15135 11895 1875
0.12 24 17 17535 12760 1840 16435 12425 1940 16055 12270 1980 15305 11960 2045
Medium 395
in.wg 27 19 18250 12790 1880 16985 12510 1980 16435 12275 2025 15340 11795 2100
32 23 18980 15015 1970 17535 14645 2040 16985 14510 2060 15890 14235 2100
21 15 15625 10375 1645 14960 10430 1690 14615 10320 1710 13925 10110 1745
24 17 16130 10850 1710 15120 10560 1805 14775 10430 1840 14085 10170 1905
Low 237
27 19 16790 10875 1750 15625 10635 1840 15120 10435 1880 14115 10025 1955
32 23 17460 12760 1835 16130 12450 1900 15625 12335 1920 14620 12100 1955
45
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT18-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT18-718
38QDMT18-718
Indoor Conditions Outdoor Ambient Temperature
Temp. °C 35°C 43°C 46°C 52°C
Air
ESP Fan Capacity Capacity Capacity Capacity
Flow Input Input Input Input
in.wg Speed DB WB Btu/hr Btu/hr Btu/hr Btu/hr
cfm W W W W
Total Sensible Total Sensible Total Sensible Total Sensible
21 15 17470 12965 1830 16730 13030 1880 16345 12900 1900 15575 12635 1940
24 17 18040 13560 1905 16910 13200 2010 16525 13035 2050 15755 12710 2120
High 444
27 19 18780 13585 1945 17470 13290 2050 16910 13040 2090 15790 12545 2160
32 23 19520 15950 2040 18040 15560 2115 17475 15415 2135 16355 15125 2175
21 15 16600 11930 1760 15895 11990 1805 15530 11870 1825 14800 11630 1865
0.16 24 17 17140 12480 1830 16065 12145 1930 15700 11995 1970 14970 11695 2040
Medium 374
in.wg 27 19 17845 12500 1870 16600 12230 1970 16065 12000 2010 15005 11540 2075
32 23 18545 14680 1960 17140 14315 2035 16605 14185 2050 15540 13920 2090
21 15 15270 10140 1635 14625 10190 1680 14290 10090 1700 13615 9885 1735
24 17 15770 10610 1705 14780 10325 1795 14445 10195 1835 13770 9940 1895
Low 218
27 19 16415 10625 1740 15270 10395 1835 14780 10200 1870 13805 9810 1930
32 23 17065 12475 1825 15770 12175 1890 15275 12055 1910 14295 11830 1945
21 15 17070 12665 1820 16345 12735 1870 15970 12610 1890 15220 12355 1930
24 17 17625 13245 1895 16525 12900 2000 16150 12745 2040 15400 12430 2110
High 423
27 19 18350 13275 1935 17070 12985 2040 16525 12750 2075 15435 12275 2135
32 23 19075 15585 2030 17625 15205 2105 17075 15065 2125 15985 14780 2165
21 15 16220 11655 1750 15530 11720 1800 15175 11600 1815 14460 11370 1855
0.20 24 17 16745 12185 1820 15700 11870 1920 15345 11730 1960 14630 11435 2030
Medium 353
in.wg 27 19 17435 12215 1860 16220 11950 1960 15700 11730 1995 14665 11295 2050
32 23 18125 14340 1950 16745 13985 2025 16225 13860 2040 15190 13600 2080
21 15 14920 9910 1625 14290 9960 1670 13960 9860 1690 13305 9665 1725
24 17 15405 10360 1695 14445 10090 1790 14120 9970 1825 13460 9725 1885
Low 199
27 19 16040 10380 1730 14920 10160 1825 14445 9975 1855 13495 9605 1910
32 23 16675 12185 1815 15405 11890 1880 14925 11785 1900 13975 11560 1935
21 15 16670 12365 1810 15960 12440 1860 15595 12315 1880 14865 12070 1920
24 17 17210 12930 1885 16140 12605 1990 15775 12450 2030 15045 12145 2100
High 401
27 19 17920 12960 1925 16670 12680 2030 16140 12455 2060 15080 12005 2110
32 23 18630 15215 2020 17210 14845 2095 16675 14710 2115 15615 14440 2155
21 15 15840 11375 1740 15165 11445 1790 14820 11335 1805 14125 11105 1845
0.24 24 17 16350 11900 1810 15335 11600 1915 14990 11460 1950 14295 11175 2020
Medium 331
in.wg 27 19 17025 11925 1850 15840 11665 1950 15335 11465 1980 14330 11050 2030
32 23 17700 14000 1940 16350 13665 2015 15845 13535 2035 14835 13285 2070
21 15 14570 9670 1620 13950 9730 1665 13635 9635 1680 12995 9440 1715
24 17 15045 10115 1685 14110 9860 1780 13790 9740 1815 13150 9500 1875
Low 180
27 19 15665 10140 1720 14570 9920 1815 14110 9740 1840 13180 9395 1885
32 23 16285 11905 1805 15045 11610 1875 14575 11505 1890 13650 11290 1925
46
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT24-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT24-718
38QDMT24-718
Indoor Conditions Outdoor Ambient Temperature
Temp. °C 35°C 43°C 46°C 52°C
Air
ESP Fan Capacity Capacity Capacity Capacity
Flow Input Input Input Input
in.wg Speed DB WB Btu/hr Btu/hr Btu/hr Btu/hr
cfm W W W W
Total Sensible Total Sensible Total Sensible Total Sensible
21 15 23890 19115 2265 22880 19225 2335 22375 19025 2358 21365 18625 2405
24 17 24690 19985 2365 23135 19445 2490 22630 19235 2535 21620 18815 2625
High 755
27 19 25700 20055 2415 23890 19585 2540 23130 19195 2585 21610 18415 2675
32 23 26715 23530 2535 24690 22955 2630 23895 22710 2655 22305 22220 2705
21 15 22700 17590 2175 21740 17690 2245 21260 17505 2265 20300 17135 2310
0 24 17 23460 18390 2275 21980 17890 2395 21500 17700 2435 20540 17310 2520
Medium 675
in.wg 27 19 24415 18455 2320 22700 18020 2440 21975 17660 2485 20530 16945 2570
32 23 25380 21650 2435 23460 21120 2525 22705 20895 2550 21190 20445 2600
21 15 20880 14950 2025 20000 15035 2085 19560 14880 2110 18675 14565 2150
24 17 21580 15630 2115 20220 15210 2225 19780 15045 2265 18900 14715 2345
Low 430
27 19 22465 15685 2160 20880 15320 2270 20220 15015 2310 18890 14405 2390
32 23 23350 18405 2265 21580 17955 2350 20885 17760 2375 19495 17380 2420
21 15 23135 18505 2255 22160 18620 2325 21670 18425 2350 20040 18040 2400
24 17 23900 19375 2355 22395 18820 2480 21905 18620 2525 20930 18215 2615
High 683
27 19 24875 19410 2405 23125 18960 2530 22390 18585 2575 20925 17830 2665
32 23 25855 22765 2525 23900 22220 2620 23130 21985 2645 21590 21510 2700
21 15 21980 17025 2165 21055 17135 2235 20590 16955 2260 19040 16600 2305
0.08 24 17 22705 17825 2265 21280 17315 2385 20810 17135 2425 19885 16760 2515
Medium 603
in.wg 27 19 23635 17860 2310 21970 17445 2430 21275 17100 2475 19880 16405 2560
32 23 24565 20945 2425 22705 20445 2520 21975 20230 2540 20515 19790 2595
21 15 20220 14475 2015 19370 14565 2080 18940 14410 2100 17515 14110 2145
24 17 20890 15155 2105 19575 14720 2215 19145 14565 2255 18295 14245 2335
Low 335
27 19 21745 15180 2150 20215 14830 2260 19570 14535 2300 18290 13945 2380
32 23 22600 17805 2255 20890 17380 2340 20220 17195 2365 18870 16825 2415
21 15 22960 18350 2255 21990 18480 2325 21505 18285 2350 18905 17905 2400
24 17 23700 19225 2355 22210 18665 2480 21725 18465 2525 20755 18065 2615
High 667
27 19 24670 19250 2405 22935 18805 2530 22205 18430 2575 20755 17685 2665
32 23 25640 22575 2525 23700 22035 2620 22940 21805 2645 21415 21335 2695
21 15 21815 16885 2165 20895 17005 2235 20435 16825 2260 17960 16475 2305
0.10 24 17 22515 17685 2265 21100 17175 2385 20640 16995 2425 19720 16620 2515
Medium 587
in.wg 27 19 23440 17710 2310 21790 17300 2430 21100 16960 2475 19720 16270 2560
32 23 24360 20770 2425 22515 20275 2520 21795 20065 2540 20345 19630 2590
21 15 20065 14355 2015 19225 14455 2080 18800 14300 2100 16525 14005 2145
24 17 20715 15035 2105 19415 14600 2215 18990 14445 2255 18145 14130 2335
Low 311
27 19 21565 15055 2150 20045 14710 2260 19410 14415 2300 18140 13830 2380
32 23 22415 17660 2255 20715 17235 2340 20050 17055 2365 18715 16690 2410
21 15 22780 18195 2250 21820 18335 2320 21340 18145 2345 17765 17765 2395
24 17 23500 19070 2350 22020 18510 2475 21540 18310 2520 20580 17910 2610
High 651
27 19 24460 19085 2400 22740 18645 2525 22020 18275 2570 20580 17535 2660
32 23 25425 22385 2520 23500 21850 2615 22745 21620 2640 21235 21160 2690
21 15 21645 16740 2160 20730 16870 2230 20275 16695 2255 16880 16345 2300
0.12 24 17 22325 17545 2260 20920 17030 2380 20465 16850 2420 19555 16480 2510
Medium 571
in.wg 27 19 23240 17560 2305 21605 17155 2425 20920 16815 2470 19555 16135 2555
32 23 24155 20595 2420 22325 20105 2515 21610 19895 2535 20175 19470 2585
21 15 19910 14230 2010 19075 14340 2075 18655 14190 2095 15530 13895 2140
24 17 20540 14915 2100 19250 14475 2210 18830 14320 2250 17990 14010 2335
Low 288
27 19 21380 14925 2145 19875 14585 2255 19250 14295 2295 17990 13715 2375
32 23 22225 17510 2250 20540 17090 2335 19880 16910 2360 18560 16550 2405
47
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT24-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT24-718 38QDMT24-718
Indoor Conditions Outdoor Ambient Temperature
Temp. °C 35°C 43°C 46°C 52°C
Air
ESP Fan Capacity Capacity Capacity Capacity
Flow Input Input Input Input
in.wg Speed DB WB Btu/hr Btu/hr Btu/hr Btu/hr
cfm W W W W
Total Sensible Total Sensible Total Sensible Total Sensible
21 15 22375 17890 2245 21435 18010 2315 20965 17825 2340 18715 17450 2390
24 17 23105 18765 2345 21650 18195 2470 21180 18005 2515 20240 17615 2605
High 614
27 19 24045 18760 2395 22355 18330 2520 21650 17970 2565 20235 17245 2655
32 23 24995 22000 2515 23105 21480 2610 22360 21255 2635 20875 20800 2690
21 15 21260 16460 2160 20365 16570 2225 19920 16400 2250 17780 16055 2295
0.16 24 17 21950 17265 2255 20570 16740 2375 20125 16565 2415 19230 16210 2505
Medium 534
in.wg 27 19 22845 17260 2300 21240 16865 2420 20570 16535 2465 19225 15870 2550
32 23 23750 20240 2415 21950 19765 2510 21245 19555 2530 19835 19140 2585
21 15 19560 13990 2005 18735 14085 2070 18325 13940 2090 16360 13650 2135
24 17 20195 14675 2095 18925 14230 2210 18515 14080 2250 17690 13775 2330
Low 236
27 19 21020 14675 2140 19540 14335 2250 18925 14055 2295 17690 13490 2375
32 23 21850 17205 2250 20195 16800 2335 19545 16625 2355 18245 16270 2405
21 15 21970 17580 2240 21045 17685 2310 20585 17500 2335 19665 17130 2385
24 17 22705 18455 2340 21275 17885 2465 20815 17695 2510 19895 17315 2600
High 580
27 19 23630 18435 2385 21970 18015 2510 21275 17660 2555 19885 16950 2645
32 23 24565 21615 2505 22705 21110 2600 21975 20885 2630 20515 20435 2690
21 15 20875 16175 2155 19995 16275 2220 19560 16100 2245 18685 15760 2290
0.20 24 17 21570 16980 2250 20215 16455 2370 19775 16280 2410 18905 15930 2500
Medium 500
in.wg 27 19 22450 16965 2290 20875 16575 2410 20215 16250 2455 18895 15595 2540
32 23 23340 19890 2405 21570 19425 2500 20880 19215 2525 19490 18805 2585
21 15 19205 13750 2000 18395 13830 2065 17995 13685 2085 17190 13400 2130
24 17 19845 14435 2090 18595 13990 2205 18195 13840 2245 17390 13545 2325
Low 188
27 19 20655 14420 2130 19205 14090 2245 18595 13815 2285 17380 13255 2365
32 23 21470 16905 2240 19845 16510 2325 19210 16335 2350 17935 15985 2405
21 15 21565 17270 2235 20655 17360 2305 20205 17175 2330 20615 16810 2380
24 17 22305 18145 2335 20900 17575 2460 20450 17385 2505 19550 17015 2595
High 545
27 19 23215 18110 2375 21585 17700 2500 20900 17350 2545 19535 16655 2635
32 23 24135 21230 2495 22305 20740 2590 21590 20515 2625 20155 20070 2690
21 15 20490 15890 2150 19625 15975 2215 19195 15805 2240 19585 15470 2285
0.24 24 17 21190 16695 2245 19855 16170 2365 19430 15995 2405 18575 15655 2495
Medium 465
in.wg 27 19 22055 16665 2280 20510 16285 2400 19855 15965 2445 18560 15325 2530
32 23 22930 19535 2400 21190 19085 2490 20515 18875 2520 19150 18465 2585
21 15 18850 13510 2000 18055 13580 2060 17660 13435 2085 18020 13150 2125
24 17 19495 14190 2085 18270 13745 2200 17875 13600 2240 17090 13310 2320
Low 141
27 19 20290 14165 2125 18870 13845 2235 18270 13570 2275 17075 13025 2355
32 23 21095 16605 2230 19495 16220 2315 18870 16045 2345 17620 15695 2405
48
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT30-718 Heat Pump
220-240V/1Ph/50Hz
42QDMT30-718
38QDMT30-718
Indoor Conditions Outdoor Ambient Temperature
Temp. °C 35°C 43°C 46°C 52°C
Air
ESP Fan Capacity Capacity Capacity Capacity
Flow Input Input Input Input
in.wg Speed DB WB Btu/hr Btu/hr Btu/hr Btu/hr
cfm W W W W
Total Sensible Total Sensible Total Sensible Total Sensible
21 15 29295 21520 3440 28035 21600 3555 27405 21375 3590 26145 20925 3665
24 17 30240 22485 3590 28350 21865 3770 27720 21630 3840 26460 21155 3975
High 1080
27 19 31500 22550 3660 29295 22055 3840 28350 21605 3915 26480 20710 4060
32 23 32760 26470 3845 30240 25800 3990 29295 25540 4030 27405 25020 4115
21 15 27900 19925 3305 26700 20000 3415 26100 19790 3450 24900 19370 3520
0 24 17 28800 20815 3450 27000 20240 3625 26400 20025 3690 25200 19585 3820
Medium 910
in.wg 27 19 30000 20875 3515 27900 20420 3690 27000 20005 3760 25215 19175 3900
32 23 31200 24505 3695 28800 23885 3835 27900 23645 3875 26100 23165 3955
21 15 25670 16935 3075 24565 17005 3180 24015 16825 3210 22910 16470 3275
24 17 26500 17695 3210 24840 17210 3375 24290 17020 3435 23185 16650 3555
Low 645
27 19 27600 17745 3270 25670 17360 3435 24840 17010 3500 23200 16305 3630
32 23 28705 20830 3440 26500 20305 3570 25670 20100 3605 24015 19695 3680
21 15 28580 20990 3425 27350 21070 3540 26735 20855 3575 25365 20420 3650
24 17 29495 21935 3570 27655 21330 3750 27045 21065 3820 25815 20530 3955
High 1005
27 19 30725 21995 3635 28585 21520 3820 27665 21075 3890 25825 20205 4030
32 23 31960 25815 3825 29500 25165 3970 28580 24915 4010 26735 24410 4095
21 15 27215 19435 3290 26045 19510 3400 25460 19310 3435 24155 18905 3505
0.08 24 17 28090 20310 3430 26335 19745 3605 25755 19500 3670 24585 19010 3800
Medium 850
in.wg 27 19 29260 20360 3495 27220 19920 3670 26345 19515 3740 24595 18710 3875
32 23 30435 23905 3675 28095 23300 3815 27215 23070 3855 25460 22600 3935
21 15 25040 16520 3060 23965 16585 3165 23425 16415 3195 22225 16070 3260
24 17 25845 17265 3190 24230 16785 3355 23695 16580 3415 22620 16160 3535
Low 562
27 19 26920 17310 3255 25045 16935 3415 24240 16590 3480 22630 15900 3605
32 23 28005 20320 3420 25850 19810 3550 25040 19615 3590 23425 19210 3660
21 15 28215 20730 3415 27005 20810 3530 26400 20590 3565 25190 20155 3635
24 17 29125 21655 3560 27300 21055 3740 26700 20685 3810 25490 19945 3945
High 976
27 19 30335 21720 3625 28230 21240 3810 27325 20815 3875 25505 19955 4010
32 23 31555 25495 3815 29130 24850 3960 28220 24605 4000 26405 24115 4085
21 15 26870 19190 3280 25715 19265 3390 25140 19065 3425 23990 18665 3495
0.12 24 17 27735 20050 3420 26000 19495 3595 25425 19150 3660 24275 18460 3790
Medium 820
in.wg 27 19 28890 20110 3485 26885 19665 3660 26020 19270 3725 24290 18475 3855
32 23 30050 23605 3665 27740 23005 3805 26875 22780 3845 25145 22325 3925
21 15 24725 16315 3055 23660 16380 3155 23130 16205 3190 22075 15865 3255
24 17 25520 17045 3185 23920 16570 3345 23395 16280 3405 22335 15695 3525
Low 525
27 19 26580 17095 3245 24735 16720 3405 23940 16380 3465 22350 15705 3590
32 23 27650 20070 3410 25525 19560 3540 24725 19365 3580 23135 18980 3655
21 15 27935 20525 3315 26735 20605 3425 26140 20385 3460 24940 19955 3530
24 17 28835 21440 3455 27030 20845 3630 26435 20480 3700 25240 19750 3830
High 954
27 19 30035 21505 3520 27950 21030 3700 27055 20610 3760 25250 19760 3890
32 23 31240 25245 3705 28840 24605 3845 27940 24360 3880 26145 23875 3965
21 15 26605 19000 3185 25460 19075 3290 24890 18875 3325 23755 18480 3395
0.15 24 17 27460 19850 3320 25740 19305 3490 25175 18960 3555 24035 18280 3680
Medium 797
in.wg 27 19 28605 19910 3385 26620 19470 3555 25760 19080 3615 24050 18295 3740
32 23 29750 23370 3560 27465 22775 3695 26610 22555 3730 24895 22105 3810
21 15 24480 16155 2965 23425 16220 3065 22900 16045 3095 21855 15710 3160
24 17 25265 16875 3090 23685 16405 3245 23165 16120 3305 22115 15540 3420
Low 502
27 19 26315 16925 3150 24490 16555 3305 23705 16220 3365 22130 15550 3485
32 23 27375 19870 3310 25270 19365 3435 24480 19175 3475 22905 18795 3550
49
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT30-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT30-718
38QDMT30-718
Indoor Conditions Outdoor Ambient Temperature
Temp. °C 35°C 43°C 46°C 52°C
Air
ESP Fan Capacity Capacity Capacity Capacity
Flow Input Input Input Input
in.wg Speed DB WB Btu/hr Btu/hr Btu/hr Btu/hr
cfm W W W W
Total Sensible Total Sensible Total Sensible Total Sensible
21 15 27855 20460 3405 26655 20545 3520 26065 20330 3555 24580 19905 3625
24 17 28750 21385 3550 26955 20790 3730 26365 20495 3800 25170 19905 3935
High 947
27 19 29950 21435 3615 27870 20975 3800 26970 20550 3865 25175 19700 4000
32 23 31150 25165 3805 28755 24530 3950 27860 24290 3990 26065 23805 4075
21 15 26525 18945 3270 25385 19020 3380 24820 18825 3415 23405 18430 3485
0.16 24 17 27380 19795 3410 25670 19245 3585 25105 18975 3650 23970 18430 3780
Medium 790
in.wg 27 19 28520 19850 3475 26540 19415 3650 25685 19025 3715 23975 18240 3845
32 23 29665 23300 3655 27385 22715 3795 26530 22490 3835 24820 22040 3915
21 15 24405 16105 3045 23355 16170 3145 22835 16000 3180 21535 15670 3245
24 17 25190 16830 3175 23620 16360 3335 23100 16130 3395 22055 15670 3520
Low 495
27 19 26240 16875 3235 24420 16510 3395 23635 16175 3455 22060 15505 3580
32 23 27295 19810 3400 25195 19310 3530 24410 19120 3570 22835 18735 3645
21 15 27490 20195 3395 26310 20275 3505 25720 20070 3545 23960 19655 3615
24 17 28380 21105 3540 26610 20520 3720 26020 20305 3790 24845 19865 3925
High 915
27 19 29560 21160 3605 27505 20695 3790 26620 20280 3855 24845 19440 3990
32 23 30745 24840 3795 28385 24215 3940 27495 23975 3980 25720 23495 4065
21 15 26180 18700 3260 25055 18770 3370 24495 18580 3405 22815 18195 3475
0.20 24 17 27025 19535 3400 25340 19000 3575 24780 18795 3640 23660 18395 3770
Medium 760
in.wg 27 19 28150 19590 3465 26195 19165 3640 25350 18775 3705 23660 18000 3835
32 23 29280 23000 3645 27030 22420 3785 26185 22195 3825 24495 21750 3905
21 15 24090 15900 3035 23055 15955 3135 22540 15795 3170 20990 15470 3235
24 17 24865 16605 3165 23315 16150 3325 22800 15980 3390 21770 15640 3510
Low 453
27 19 25900 16655 3225 24100 16290 3390 23325 15960 3450 21770 15300 3570
32 23 26940 19550 3390 24870 19060 3525 24095 18870 3560 22540 18490 3635
21 15 27130 19940 3380 25965 20010 3495 25385 19800 3535 24230 20355 3605
24 17 28005 20825 3530 26275 20265 3710 25695 20045 3780 24540 19620 3915
High 883
27 19 29170 20885 3595 27145 20440 3780 26270 20025 3850 24515 19180 3995
32 23 30340 24520 3785 28015 23900 3930 27140 23660 3970 25385 23170 4055
21 15 25835 18460 3250 24725 18525 3360 24175 18335 3395 23075 18845 3465
0.24 24 17 26670 19285 3390 25020 18760 3565 24470 18560 3630 23370 18170 3760
Medium 730
in.wg 27 19 27780 19335 3455 25850 18920 3630 25015 18540 3700 23345 17760 3840
32 23 28895 22700 3635 26680 22130 3775 25845 21905 3815 24175 21455 3895
21 15 23770 15695 3025 22750 15750 3125 22245 15585 3160 21230 16025 3225
24 17 24540 16395 3155 23020 15950 3320 22515 15780 3380 21505 15445 3500
Low 411
27 19 25560 16440 3215 23785 16085 3380 23015 15760 3445 21480 15095 3575
32 23 26585 19295 3385 24550 18810 3515 23780 18625 3550 22245 18240 3625
21 15 26765 19670 3370 25615 19740 3485 25050 19540 3525 23915 19140 3595
24 17 27635 20555 3520 25920 19990 3700 25355 19785 3765 24220 19370 3900
High 851
27 19 28785 20610 3585 26785 20165 3765 25915 19760 3840 24185 18925 3985
32 23 29940 24190 3770 27640 23580 3920 26770 23340 3960 25040 22955 4045
21 15 25490 18215 3240 24395 18280 3350 23855 18090 3385 22775 17720 3455
0.28 24 17 26315 19030 3380 24685 18510 3555 24145 18315 3620 23065 17930 3750
Medium 700
in.wg 27 19 27410 19080 3445 25505 18670 3620 24680 18295 3690 23030 17520 3830
32 23 28510 22395 3625 26320 21830 3765 25495 21610 3805 23845 21250 3885
21 15 23455 15485 3015 22445 15540 3120 21950 15380 3150 20955 15070 3215
24 17 24210 16180 3145 22715 15735 3310 22215 15570 3370 21220 15240 3490
Low 369
27 19 25220 16220 3205 23465 15875 3370 22710 15550 3435 21190 14895 3565
32 23 26230 19040 3375 24215 18555 3505 23460 18375 3540 21940 18065 3615
50
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT30-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT30-718
38QDMT30-718
Indoor Conditions Outdoor Ambient Temperature
Temp. °C 35°C 43°C 46°C 52°C
Air
ESP Fan Capacity Capacity Capacity Capacity
Flow Input Input Input Input
in.wg Speed DB WB Btu/hr Btu/hr Btu/hr Btu/hr
cfm W W W W
Total Sensible Total Sensible Total Sensible Total Sensible
21 15 26405 19405 3360 25270 19475 3475 24710 19280 3510 22110 18140 3585
24 17 27260 20275 3505 25570 19720 3680 25010 19510 3755 23880 19100 3890
High 819
27 19 28395 20325 3575 26420 19885 3755 25565 19480 3825 23880 18690 3960
32 23 29535 23865 3760 27265 23260 3910 26410 23030 3950 24700 22555 4030
21 15 25145 17965 3230 24065 18030 3340 23530 17845 3375 21055 16795 3445
0.32 24 17 25960 18770 3370 24350 18255 3535 23815 18065 3610 22740 17680 3740
Medium 670
in.wg 27 19 27040 18820 3435 25160 18410 3610 24345 18035 3675 22740 17305 3805
32 23 28125 22095 3615 25965 21535 3755 25150 21320 3795 23520 20885 3875
21 15 23135 15270 3005 22140 15325 3110 21650 15170 3140 19375 14280 3205
24 17 23885 15955 3135 22405 15525 3290 21910 15360 3360 20925 15035 3480
Low 327
27 19 24880 16000 3195 23150 15650 3360 22400 15330 3420 20925 14710 3540
32 23 25875 18785 3365 23890 18305 3495 23140 18125 3530 21640 17755 3605
51
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT36-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT36-718
38QDMT36-718
Indoor Conditions Outdoor Ambient Temperature
Temp. °C 35°C 43°C 46°C 52°C
Air
ESP Fan Capacity Capacity Capacity Capacity
Flow Input Input Input Input
in.wg Speed DB WB Btu/hr Btu/hr Btu/hr Btu/hr
cfm W W W W
Total Sensible Total Sensible Total Sensible Total Sensible
21 15 34990 25315 3940 33490 25450 4065 32740 25195 4110 31240 24675 4200
24 17 36100 26450 4105 33845 25740 4320 33095 25460 4400 31595 24900 4560
High 1080
27 19 37300 26545 4240 34990 25965 4400 33845 25430 4490 31555 24350 4670
32 23 39105 31150 4400 36100 30375 4570 35000 30105 4615 32800 29560 4705
21 15 33245 23295 3785 31820 23420 3905 31105 23180 3950 29680 22705 4035
0 24 17 34295 24340 3945 32155 23680 4150 31445 23425 4225 30020 22910 4380
Medium 910
in.wg 27 19 35720 24425 4030 33245 23890 4225 32155 23395 4315 29980 22405 4485
32 23 37150 28660 4225 34295 27950 4390 33250 27695 4435 31160 27200 4520
21 15 30585 19800 3520 29275 19905 3630 28615 19705 3670 27305 19300 3750
24 17 31555 20685 3665 29585 20135 3860 28930 19910 3930 27615 19475 4075
Low 645
27 19 32865 20765 3750 30585 20310 3930 29585 19890 4010 27580 19045 4170
32 23 34180 24360 3930 31555 23755 4085 30590 23540 4125 28670 23120 4205
21 15 34175 25630 3925 32715 24860 4050 31980 24610 4095 30510 24110 4185
24 17 35260 25835 4085 33055 25145 4300 32325 24865 4380 30865 24325 4540
High 1005
27 19 36720 25925 4175 34175 25365 4380 33055 24840 4470 30820 23785 4650
32 23 38195 30425 4380 35260 29670 4550 34185 29400 4595 32035 28570 4685
21 15 32470 23580 3770 31080 22870 3890 30385 22640 3935 28985 22185 4020
0.08 24 17 33500 23770 3925 31405 23135 4130 30710 22880 4205 29325 22380 4360
Medium 850
in.wg 27 19 34885 23855 4010 32470 23340 4205 31405 22855 4295 29280 21885 4465
32 23 36290 27995 4205 33500 27295 4370 32480 27055 4415 30435 26285 4500
21 15 29870 20050 3505 28595 19440 3620 27955 19245 3660 26670 18860 3740
24 17 30820 20205 3650 28895 19665 3840 28255 19450 3915 26980 19025 4055
Low 562
27 19 32095 20280 3730 29870 19840 3915 28895 19430 3995 26940 18605 4155
32 23 33385 23795 3915 30820 23200 4065 29880 22995 4105 28000 22340 4185
21 15 33765 28050 3915 32330 24565 4040 31600 24320 4085 30140 23830 4175
24 17 34835 25530 4075 32660 24840 4290 31940 24575 4370 30500 24040 4530
High 976
27 19 36280 25620 4165 33765 25060 4370 32660 24540 4460 30450 23500 4640
32 23 37735 30060 4370 34835 29310 4540 33775 29055 4585 31655 27315 4675
21 15 32080 25810 3760 30715 22600 3880 30020 22380 3925 28635 21925 4010
0.12 24 17 33095 23485 3915 31030 22855 4120 30345 22610 4200 28975 22120 4350
Medium 820
in.wg 27 19 34470 23575 4000 32080 23055 4200 31030 22580 4285 28930 21625 4455
32 23 35850 27655 4200 33095 26965 4360 32090 26730 4405 30075 25135 4490
21 15 29515 21935 3500 28260 19210 3610 27620 19020 3650 26345 18640 3730
24 17 30450 19965 3640 28545 19430 3835 27920 19220 3905 26660 18800 4045
Low 525
27 19 31710 20035 3720 29515 19600 3905 28545 19195 3985 26615 18380 4145
32 23 32985 23510 3905 30450 22925 4055 29520 22725 4095 27670 21365 4175
21 15 33430 27770 3800 32010 24320 3920 31285 24080 3965 29840 23595 4050
24 17 34490 25275 3955 32335 24595 4165 31625 24330 4240 30195 23800 4395
High 954
27 19 35920 25365 4045 33430 24810 4240 32335 24295 4330 30150 23265 4505
32 23 37360 29760 4240 34490 29020 4405 33440 28765 4450 31340 27045 4535
21 15 31760 25555 3650 30410 22375 3765 29720 22160 3810 28350 21710 3890
0.15 24 17 32765 23255 3800 30720 22630 4000 30045 22385 4075 28690 21900 4220
Medium 797
in.wg 27 19 34130 23340 3880 31760 22825 4075 30720 22355 4160 28645 21410 4325
32 23 35495 27380 4075 32765 26700 4230 31770 26465 4275 29775 24885 4360
21 15 29220 21720 3395 27980 19020 3505 27345 18830 3545 26085 18455 3620
24 17 30150 19770 3535 28260 19240 3720 27645 19030 3790 26395 18615 3925
Low 502
27 19 31395 19835 3610 29220 19405 3790 28260 19005 3870 26350 18200 4025
32 23 32660 23275 3790 30150 22700 3935 29225 22500 3975 27395 21155 4050
52
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT36-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT36-718
38QDMT36-718
Indoor Conditions Outdoor Ambient Temperature
Temp. °C 35°C 43°C 46°C 52°C
Air
ESP Fan Capacity Capacity Capacity Capacity
Flow Input Input Input Input
in.wg Speed DB WB Btu/hr Btu/hr Btu/hr Btu/hr
cfm W W W W
Total Sensible Total Sensible Total Sensible Total Sensible
21 15 33355 25945 3910 31935 24265 4035 31215 24025 4080 29780 23540 4170
24 17 34415 25220 4065 32265 24540 4280 31555 24275 4360 30128 23745 4520
High 947
27 19 35840 25305 4155 33355 24760 4360 32265 24245 4450 30085 23220 4630
32 23 37280 29695 4360 34415 28960 4530 33365 28700 4575 31270 27580 4665
21 15 31690 23870 3755 30340 22330 3875 29655 22105 3920 28295 21660 4005
0.16 24 17 32695 23205 3905 30655 22580 4110 29980 22335 4190 28625 21850 4340
Medium 790
in.wg 27 19 34050 23285 3990 31690 22780 4190 30655 22310 4275 28585 21365 4445
32 23 35420 27325 4190 32695 26645 4350 31700 26405 4395 29710 25375 4480
21 15 29155 20295 3495 27915 18980 3605 27285 18790 3645 26030 18410 3725
24 17 30080 19725 3630 28200 19195 3825 27580 18985 3895 26335 18575 4040
Low 495
27 19 31325 19790 3710 29155 19365 3895 28200 18960 3975 26295 18160 4135
32 23 32585 23225 3895 30080 22650 4045 29165 22445 4085 27330 21570 4165
21 15 32945 23835 3900 31535 23965 4025 30830 23725 4070 29420 23245 4160
24 17 33990 24910 4055 31870 24240 4270 31165 23975 4350 29755 23450 4510
High 915
27 19 35400 24995 4145 32945 24450 4350 31870 23950 4440 29720 22935 4620
32 23 36820 29330 4350 33990 28600 4520 32955 28345 4565 30885 27840 4655
21 15 31300 21930 3745 29960 22055 3865 29290 21830 3910 27950 21390 3995
0.20 24 17 32295 22915 3895 30280 22300 4100 29610 22060 4180 28270 21580 4330
Medium 760
in.wg 27 19 33630 23000 3980 31300 22495 4180 30280 22035 4265 28235 21105 4440
32 23 34980 26985 4180 32295 26315 4340 31310 26080 4385 29345 25615 4470
21 15 28795 18640 3485 27565 18745 3595 26950 18560 3635 25715 18185 3715
24 17 29710 19485 3625 27855 18960 3815 27240 18755 3885 26010 18340 4030
Low 453
27 19 30940 19545 3705 28795 19125 3885 27855 18730 3965 25980 17940 4125
32 23 32185 22940 3885 29710 22370 4040 28805 22170 4080 26995 21770 4160
21 15 32535 23540 3890 31140 23670 4015 30445 23430 4060 29055 22955 4150
24 17 33570 24600 4045 31475 23940 4260 30780 23680 4340 29390 23160 4500
High 883
27 19 34960 24685 4135 32535 24150 4340 31470 23645 4430 29340 22645 4610
32 23 36365 28965 4340 33570 28250 4510 32550 28000 4555 30510 27495 4645
21 15 30910 21660 3735 29585 21775 3855 28925 21555 3900 27605 21120 3985
0.24 24 17 31895 22635 3885 29905 22025 4090 29245 21790 4170 27925 21310 4320
Medium 730
in.wg 27 19 33215 22715 3970 30910 22220 4170 29900 21755 4255 27875 20835 4430
32 23 34550 26650 4170 31895 25990 4330 30925 25765 4375 28985 25295 4460
21 15 28440 18410 3475 27220 18510 3585 26610 18325 3625 25395 17955 3710
24 17 29345 19240 3615 27510 18720 3805 26905 18525 3875 25690 18115 4020
Low 411
27 19 30560 19305 3695 28440 18885 3875 27505 18490 3960 25645 17715 4120
32 23 31785 22655 3875 29345 22095 4030 28450 21900 4070 26670 21505 4150
21 15 32125 23245 3880 30745 23370 4005 30060 23135 4050 28690 22670 4140
24 17 33150 24295 4035 31080 23640 4250 30395 23390 4330 29025 22875 4490
High 851
27 19 34520 24380 4125 32125 23845 4330 31075 23350 4420 28975 22365 4600
32 23 35910 28605 4330 33150 27895 4500 32145 27650 4545 30135 27160 4635
21 15 30520 21390 3725 29210 21500 3845 28560 21290 3890 27260 20860 3975
0.28 24 17 31495 22350 3875 29530 21755 4080 28880 21520 4160 27575 21050 4315
Medium 700
in.wg 27 19 32795 22435 3960 30520 21940 4160 29525 21485 4245 27530 20580 4420
32 23 34115 26320 4160 31495 25665 4320 30540 25440 4365 28630 24990 4450
21 15 28080 18185 3465 26875 18280 3580 26275 18095 3620 25080 17730 3700
24 17 28975 19000 3605 27165 18490 3795 26570 18295 3870 25370 17895 4010
Low 369
27 19 30175 19065 3685 28080 18650 3870 27160 18265 3950 25325 17490 4110
32 23 31390 22375 3870 28975 21820 4020 28095 21625 4060 26340 21245 4140
53
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT36-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT36-718
38QDMT36-718
54
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT36-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT36-718
38QDMT36-518
Indoor Conditions Outdoor Ambient Temperature
Temp. °C 35°C 43°C 46°C 52°C
Air
ESP Fan Capacity Capacity Capacity Capacity
Flow Input Input Input Input
in.wg Speed DB WB Btu/hr Btu/hr Btu/hr Btu/hr
cfm W W W W
Total Sensible Total Sensible Total Sensible Total Sensible
21 15 34435 27170 3865 32955 27320 3985 32220 27035 4030 30745 26485 4120
24 17 35525 28390 4025 33305 27625 4235 32570 27325 4315 31090 26720 4470
High 1080
27 19 37000 28490 4115 34435 27870 4315 33305 27295 4405 31055 26135 4580
32 23 38480 33425 4315 35525 32600 4480 34440 32305 4525 32280 31725 4615
21 15 32715 25000 3710 31315 25135 3830 30610 24880 3875 29210 24365 3955
0 24 17 33750 26120 3870 31645 25420 4070 30945 25140 4145 29540 24590 4295
Medium 910
in.wg 27 19 35150 26210 3950 32715 25640 4145 31645 25110 4230 29505 24045 4400
32 23 36560 30755 4145 33750 29995 4305 32720 29725 4350 30665 29190 4430
21 15 30100 21250 3450 28810 21360 3560 28160 21150 3600 26870 20715 3675
24 17 31055 22200 3595 29115 21610 3785 28470 21370 3855 27175 20900 3995
Low 645
27 19 32340 22285 3675 30100 21800 3855 29115 21345 3930 27140 20440 4090
32 23 33635 26145 3855 31055 25495 4005 30105 25265 4045 28215 24815 4125
21 15 33630 27510 3850 32195 26680 3970 31470 26410 4015 30025 25875 4105
24 17 34700 27725 4005 32530 26985 4215 31810 26690 4295 30375 26105 4450
High 1005
27 19 36135 27825 4095 33630 27225 4295 32530 26660 4385 30330 25525 4560
32 23 37585 32650 4295 34700 31845 4460 33640 31555 4505 31525 30660 4595
21 15 31955 25310 3695 30585 24550 3815 29900 24300 3860 28525 23810 3940
0.08 24 17 32965 25510 3850 30905 24830 4050 30220 24560 4125 28860 24015 4275
Medium 850
in.wg 27 19 34330 25600 3930 31955 25050 4125 30905 24530 4210 28815 23490 4380
32 23 35710 30045 4125 32965 29295 4285 31965 29035 4330 29950 28210 4410
21 15 29395 21520 3435 28140 20870 3550 27510 20655 3590 26245 20240 3670
24 17 30330 21685 3580 28435 21105 3765 27805 20880 3840 26550 20420 3975
Low 562
27 19 31585 21765 3660 29395 21290 3840 28435 20855 3920 26510 19970 4075
32 23 32855 25535 3840 30330 24900 3985 29405 24675 4025 27555 23980 4105
21 15 33225 30100 3840 31815 26365 3960 31095 26105 4005 29660 25575 4095
24 17 34280 27395 3995 32140 26660 4205 31430 26375 4285 30015 25805 4440
High 976
27 19 35700 27495 4085 33225 26900 4285 32140 26340 4375 29965 25220 4550
32 23 37135 32260 4285 34280 31460 4450 33235 31180 4495 31150 29315 4585
21 15 31570 27700 3685 30225 24260 3805 29540 24015 3850 28180 23535 3930
0.12 24 17 32570 25205 3840 30535 24530 4040 29860 24270 4120 28515 23740 4265
Medium 820
in.wg 27 19 33920 25300 3920 31570 24745 4120 30535 24240 4200 28470 23205 4370
32 23 35280 29680 4120 32570 28940 4275 31580 28690 4320 29595 26975 4405
21 15 29045 23540 3430 27810 20620 3540 27180 20415 3580 25925 20010 3660
24 17 29965 21430 3570 28090 20855 3760 27475 20630 3830 26235 20175 3965
Low 525
27 19 31205 21505 3650 29045 21035 3830 28090 20600 3910 26190 19730 4065
32 23 32460 25230 3830 29965 24605 3975 29050 24385 4015 27230 22930 4095
21 15 32895 29800 3725 31500 26105 3845 30785 25845 3885 29365 25320 3975
24 17 33940 27125 3880 31820 26395 4080 31120 26115 4160 29715 25550 4310
High 954
27 19 35345 27225 3965 32895 26635 4160 31820 26080 4245 29670 24970 4415
32 23 36765 31940 4160 33940 31150 4320 32905 30870 4365 30840 29025 4450
21 15 31255 27425 3575 29925 24020 3695 29245 23775 3735 27900 23300 3815
0.15 24 17 32245 24955 3725 30230 24285 3920 29565 24030 4000 28230 23505 4140
Medium 797
in.wg 27 19 33585 25050 3805 31255 24500 4000 30230 24000 4075 28190 22975 4240
32 23 34930 29385 4000 32245 28655 4150 31265 28405 4195 29300 26710 4275
21 15 28755 23305 3330 27535 20415 3435 26910 20215 3475 25670 19810 3555
24 17 29670 21220 3465 27810 20650 3650 27205 20425 3720 25975 19975 3850
Low 502
27 19 30895 21290 3545 28755 20825 3720 27810 20395 3795 25930 19535 3945
32 23 32140 24980 3720 29670 24360 3860 28760 24145 3895 26960 22705 3975
55
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT36-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT36-718
38QDMT36-518
Indoor Conditions Outdoor Ambient Temperature
Temp. °C 35°C 43°C 46°C 52°C
Air
ESP Fan Capacity Capacity Capacity Capacity
Flow Input Input Input Input
in.wg Speed DB WB Btu/hr Btu/hr Btu/hr Btu/hr
cfm W W W W
Total Sensible Total Sensible Total Sensible Total Sensible
21 15 32825 27845 3835 31425 26045 3955 30720 25790 4000 29305 25265 4090
24 17 33865 27065 3985 31750 26340 4195 31055 26055 4275 29650 25485 4430
High 947
27 19 35270 27160 4075 32825 26575 4275 31750 26025 4365 29605 24920 4540
32 23 36685 31875 4275 33865 31080 4440 32835 30800 4485 30770 29600 4575
21 15 31185 25620 3680 29855 23965 3800 29185 23725 3845 27845 23245 3925
0.16 24 17 32175 24905 3830 30165 24240 4030 29505 23970 4110 28170 23450 4255
Medium 790
in.wg 27 19 33510 24990 3915 31185 24450 4110 30165 23945 4190 28130 22930 4360
32 23 34855 29325 4110 32175 28595 4265 31195 28340 4310 29235 27235 4395
21 15 28690 21780 3430 27470 20370 3535 26850 20165 3575 25615 19755 3655
24 17 29600 21175 3560 27750 20600 3750 27140 20375 3820 25915 19935 3960
Low 495
27 19 30825 21245 3640 28690 20785 3820 27750 20350 3900 25875 19490 4055
32 23 32065 24925 3820 29600 24305 3965 28700 24090 4005 26895 23150 4085
21 15 32420 25580 3825 31035 25725 3945 30340 25465 3990 28950 24950 4080
24 17 33450 26730 3975 31365 26015 4185 30670 25735 4265 29280 25170 4420
High 915
27 19 34835 26825 4065 32420 26240 4265 31365 25705 4355 29245 24615 4530
32 23 36235 31480 4265 33450 30695 4430 32430 30420 4475 30395 29880 4565
21 15 30800 23540 3675 29485 23670 3790 28825 23430 3835 27505 22960 3920
0.20 24 17 31780 24595 3820 29800 23935 4020 29140 23675 4100 27820 23160 4245
Medium 760
in.wg 27 19 33095 24680 3905 30800 24145 4100 29800 23650 4180 27785 22650 4355
32 23 34425 28960 4100 31780 28240 4255 30810 27990 4300 28880 27490 4385
21 15 28335 20010 3420 27125 20120 3525 26520 19920 3565 25305 19515 3645
24 17 29235 20910 3555 27410 20345 3740 26805 20125 3810 25595 19690 3950
Low 453
27 19 30445 20975 3635 28335 20525 3810 27410 20105 3890 25565 19255 4045
32 23 31675 24620 3810 29235 24005 3960 28345 23795 4000 26565 23370 4080
21 15 32015 25265 3815 30645 25405 3935 29960 25145 3980 28595 24635 4070
24 17 33035 26405 3965 30975 25695 4175 30290 25420 4255 28920 24860 4410
High 883
27 19 34405 26495 4055 32015 25915 4255 30970 25380 4345 28875 24300 4520
32 23 35785 31090 4255 33035 30320 4420 32030 30050 4465 30025 29510 4555
21 15 30420 23245 3665 29115 23375 3780 28465 23135 3825 27165 22670 3910
0.24 24 17 31385 24295 3810 29430 23640 4010 28780 23385 4090 27480 22870 4235
Medium 730
in.wg 27 19 32685 24375 3895 30420 23850 4090 29425 23350 4170 27430 22365 4345
32 23 34000 28600 4090 31385 27895 4245 30435 27650 4290 28525 27150 4375
21 15 27985 19755 3410 26785 19865 3515 26185 19670 3555 24990 19270 3640
24 17 28880 20645 3545 27070 20095 3730 26475 19880 3800 25280 19440 3940
Low 411
27 19 30075 20720 3625 27985 20270 3800 27065 19845 3885 25235 19010 4040
32 23 31280 24310 3800 28880 23710 3950 27995 23505 3990 26245 23080 4070
21 15 31615 24950 3805 30255 25080 3925 29580 24830 3970 28235 24325 4060
24 17 32620 26075 3955 30585 25375 4165 29910 25100 4245 28565 24555 4405
High 851
27 19 33970 26165 4045 31615 25590 4245 30580 25060 4335 28515 24000 4510
32 23 35340 30700 4245 32620 29940 4410 31635 29675 4455 29655 29150 4545
21 15 30035 22960 3655 28745 23075 3770 28105 22845 3815 26825 22390 3900
0.28 24 17 30995 23985 3800 29060 23350 4000 28420 23095 4080 27135 22590 4230
Medium 700
in.wg 27 19 32275 24075 3885 30035 23545 4080 29055 23065 4165 27090 22085 4335
32 23 33570 28245 4080 30995 27545 4235 30055 27310 4280 28175 26820 4365
21 15 27635 19515 3400 26445 19620 3510 25855 19420 3550 24680 19030 3630
24 17 28515 20390 3535 26735 19845 3720 26145 19635 3795 24965 19205 3930
Low 369
27 19 29695 20465 3615 27635 20020 3795 26730 19605 3875 24920 18775 4030
32 23 30890 24010 3795 28515 23415 3940 27650 23210 3980 25920 22795 4060
56
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT36-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT36-718
38QDMT36-518
Indoor Conditions Outdoor Ambient Temperature
Temp. °C 35°C 43°C 46°C 52°C
Air
ESP Fan Capacity Capacity Capacity Capacity
Flow Input Input Input Input
in.wg Speed DB WB Btu/hr Btu/hr Btu/hr Btu/hr
cfm W W W W
Total Sensible Total Sensible Total Sensible Total Sensible
21 15 31210 24630 3795 29860 25050 3920 26545 22285 3960 27890 24035 4050
24 17 32205 25745 3945 30195 25050 4160 28275 23720 4235 28185 24230 4395
High 819
27 19 33535 25820 4035 31210 25270 4235 30195 24750 4325 28170 23710 4500
32 23 34885 30310 4235 32205 29555 4405 31220 29290 4445 29255 28765 4535
21 15 29650 22665 3650 28370 23050 3765 25220 20500 3805 26495 22120 3890
0.32 24 17 30595 23680 3790 28690 23050 3995 26860 21830 4070 26775 22290 4220
Medium 670
in.wg 27 19 31865 23760 3880 29650 23250 4070 28690 22775 4155 26760 21820 4325
32 23 33145 27885 4070 30595 27195 4230 29660 26955 4270 27795 26465 4355
21 15 27280 19265 3395 26105 19590 3500 23205 17430 3540 24375 18805 3620
24 17 28150 20130 3525 26395 19590 3715 24715 18555 3785 24635 18950 3920
Low 327
27 19 29315 20195 3605 27280 19760 3785 26395 19365 3865 24620 18545 4020
32 23 30490 23700 3785 28150 23115 3930 27290 22910 3970 25570 22495 4050
57
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT42-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT42-718
38QDMT42-718
Indoor Conditions Outdoor Ambient Temperature
Temp. °C 35°C 43°C 46°C 52°C
Air
ESP Fan Capacity Capacity Capacity Capacity
Flow Input Input Input Input
in.wg Speed DB WB Btu/hr Btu/hr Btu/hr Btu/hr
cfm W W W W
Total Sensible Total Sensible Total Sensible Total Sensible
21 15 37200 29775 4280 35600 30000 4410 34800 29585 4455 33200 28755 4545
24 17 38400 31115 4465 36000 30230 4695 35200 29920 4780 33600 29300 4950
High 1370
27 19 40000 31200 4555 37200 30515 4785 36000 29880 4870 33600 28610 5040
32 23 41600 36600 4780 38400 35715 4965 37200 35335 5015 34800 34575 5115
21 15 35340 27395 4110 33820 27600 4235 33060 27220 4280 31540 26455 4365
0 24 17 36480 28630 4290 34200 27815 4510 33440 27530 4590 31920 26960 4755
Medium 1260
in.wg 27 19 38000 28705 4375 35340 28075 4595 34200 27490 4680 31920 26325 4840
32 23 39520 33675 4590 36480 32860 4770 35340 32510 4815 33060 31810 4915
21 15 32515 23285 3825 31115 23460 3940 30420 23140 3980 29020 22490 4060
24 17 33565 24335 3990 31465 23640 4195 30765 23400 4270 29370 22915 4420
Low 715
27 19 34960 24400 4070 32515 23865 4275 31465 23370 4350 29370 22375 4500
32 23 36360 28625 4270 33565 27930 4435 32515 27635 4480 30420 27040 4570
21 15 36395 29135 4260 34830 29355 4390 34050 28950 4435 32490 28140 4525
24 17 37570 30445 4445 35225 29580 4670 34440 29275 4755 32880 28670 4925
High 1300
27 19 39135 30525 4530 36395 29860 4760 35225 29235 4845 32875 27995 5015
32 23 40700 35810 4755 37570 34945 4940 36395 34575 4990 34050 33695 5090
21 15 34580 26805 4090 33090 27010 4215 32350 26635 4260 30870 25890 4345
0.08 24 17 35695 28010 4270 33465 27215 4485 32720 26935 4565 31240 26380 4730
Medium 1190
in.wg 27 19 37180 28085 4350 34580 27475 4570 33465 26900 4655 31235 25760 4815
32 23 38665 32950 4565 35695 32150 4745 34580 31810 4795 32350 31000 4890
21 15 31810 22785 3805 30445 22960 3920 29760 22640 3960 28400 22010 4040
24 17 32840 23810 3970 30790 23135 4170 30105 22895 4250 28740 22420 4400
Low 636
27 19 34205 23875 4045 31810 23355 4250 30790 22865 4330 28735 21895 4480
32 23 35575 28005 4250 32840 27330 4415 31810 27040 4460 29760 26350 4545
21 15 35995 28810 4250 34445 29030 4380 33675 28630 4425 32135 27830 4515
24 17 37155 30105 4435 34835 29255 4660 34065 28955 4745 32525 28355 4915
High 1255
27 19 38700 30190 4515 35995 29530 4745 34835 28915 4830 32515 27685 5000
32 23 40250 35415 4745 37155 34560 4930 35995 34190 4980 33675 33450 5080
21 15 34200 26510 4080 32725 26710 4205 31995 26340 4250 30530 25605 4335
0.12 24 17 35300 27700 4260 33095 26915 4475 32365 26640 4560 30900 26090 4720
Medium 1145
in.wg 27 19 36765 27775 4335 34200 27170 4560 33095 26605 4640 30890 25475 4800
32 23 38240 32585 4560 35300 31800 4735 34200 31455 4785 31995 30775 4880
21 15 31460 22530 3795 30105 22705 3915 29435 22390 3955 28090 21765 4035
24 17 32475 23545 3960 30450 22880 4165 29775 22645 4240 28430 22175 4390
Low 594
27 19 33825 23610 4035 31460 23095 4240 30450 22615 4315 28420 21650 4465
32 23 35180 27695 4240 32475 27030 4405 31460 26740 4450 29435 26160 4540
21 15 35590 28488 4235 34060 28705 4365 33300 28310 4410 31775 27520 4500
24 17 36740 29770 4420 34445 28925 4645 33680 28630 4730 32155 28035 4900
High 1223
27 19 38265 29850 4500 35590 29200 4730 34445 28590 4815 32150 27375 4985
32 23 39800 35020 4730 36740 34170 4915 35590 33810 4965 33300 32815 5065
21 15 33815 26210 4070 32360 26410 4195 31635 26050 4235 30190 25320 4320
0.16 24 17 34905 27390 4245 32725 26615 4460 32000 26340 4545 30550 25795 4705
Medium 1113
in.wg 27 19 36355 27465 4320 33815 26865 4545 32725 26305 4625 30545 25185 4790
32 23 37810 32220 4545 34905 31440 4720 33815 31110 4770 31635 30190 4865
21 15 31110 22280 3785 29770 22450 3900 29105 22140 3940 27775 21525 4020
24 17 32115 23285 3950 30105 22620 4150 29440 22390 4225 28105 21925 4375
Low 548
27 19 33445 23345 4020 31110 22835 4225 30105 22360 4300 28100 21410 4455
32 23 34790 27390 4225 32115 26725 4390 31110 26440 4435 29105 25665 4525
58
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT42-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT42-718
38QDMT42-718
Indoor Conditions Outdoor Ambient Temperature
Temp. °C 35°C 43°C 46°C 52°C
Air
ESP Fan Capacity Capacity Capacity Capacity
Flow Input Input Input Input
in.wg Speed DB WB Btu/hr Btu/hr Btu/hr Btu/hr
cfm W W W W
Total Sensible Total Sensible Total Sensible Total Sensible
21 15 35185 28165 4220 33675 28380 4350 32920 27990 4395 31410 27210 4485
24 17 36320 29430 4405 34050 28595 4630 33295 28300 4715 31785 27710 4885
High 1187
27 19 37830 29510 4485 35185 28865 4715 34050 28265 4800 31780 27065 4970
32 23 39345 34620 4715 36320 33780 4900 35185 33425 4950 32915 32175 5050
21 15 33430 25915 4055 31995 26110 4180 31275 25755 4220 29840 25035 4310
0.20 24 17 34505 27080 4230 32350 26310 4445 31635 26040 4530 30200 25495 4690
Medium 1077
in.wg 27 19 35940 27150 4310 33430 26560 4530 32350 26005 4610 30195 24900 4775
32 23 37380 31855 4530 34505 31080 4705 33430 30755 4755 31270 29605 4850
21 15 30755 22030 3770 29435 22195 3885 28775 21890 3925 27455 21280 4005
24 17 31745 23015 3935 29760 22365 4135 29100 22135 4210 27785 21670 4365
Low 491
27 19 33065 23080 4005 30755 22575 4210 29760 22105 4290 27780 21165 4440
32 23 34390 27075 4210 31745 26420 4375 30755 26140 4420 28770 25165 4510
21 15 34780 27845 4205 33295 28060 4335 31570 26840 4380 28120 24355 4470
24 17 35905 29095 4390 33660 28270 4620 32910 27975 4705 31410 27390 4875
High 1151
27 19 32395 29175 4470 34780 28535 4695 33610 27900 4780 31270 26630 4950
32 23 38895 34250 4700 35905 33400 4885 34780 33040 4935 32530 32320 5035
21 15 33045 25620 4040 31635 25820 4165 29995 24695 4205 26715 22410 4295
0.24 24 17 34110 26770 4215 31980 26010 4440 31265 25740 4520 29840 25200 4680
Medium 1041
in.wg 27 19 30780 26845 4295 33045 26255 4510 31930 25670 4590 29710 24500 4755
32 23 36955 31510 4515 34110 30730 4690 33045 30400 4740 30905 29735 4835
21 15 30400 21775 3755 29100 21945 3875 27595 20990 3915 24580 19050 3995
24 17 31385 22755 3920 29420 22110 4125 28765 21880 4205 27455 21420 4355
Low 434
27 19 28315 22815 3995 30400 22315 4195 29380 21820 4270 27330 20825 4420
32 23 33995 26785 4200 31385 26120 4365 30400 25840 4410 28435 25275 4500
21 15 34375 27520 4190 32910 27740 4320 32175 27355 4365 30705 26595 4455
24 17 35485 28760 4375 33265 27940 4605 32525 27650 4690 31045 27075 4860
High 1115
27 19 26960 28835 4455 34375 28205 4680 33270 27620 4765 31060 26455 4935
32 23 38440 33880 4685 35490 33015 4870 34380 32660 4920 32160 31955 5020
21 15 32660 25320 4025 31265 25525 4150 30570 25170 4195 29170 24470 4280
0.28 24 17 33715 26460 4200 31605 25705 4425 30900 25440 4505 29495 24910 4670
Medium 1005
in.wg 27 19 25615 26530 4280 32660 25950 4495 31610 25415 4575 29510 24340 4740
32 23 36520 31170 4500 33720 30375 4680 32665 30050 4725 30555 29400 4820
21 15 30045 21525 3745 28765 21695 3860 28125 21395 3900 26840 20800 3980
24 17 31015 22495 3910 29075 21850 4115 28430 21625 4190 27135 21175 4340
Low 377
27 19 23565 22550 3980 30045 22060 4180 29080 21600 4255 27150 20690 4410
32 23 33600 26495 4185 31020 25820 4350 30050 25545 4395 28110 24990 4485
21 15 33970 27195 4175 32520 27410 4305 31790 27030 4350 30325 26270 4440
24 17 35070 28420 4360 32875 27610 4585 32140 27320 4670 30675 26745 4840
High 1079
27 19 36525 28495 4440 33970 27870 4670 32875 27290 4755 30680 26130 4925
32 23 37990 33430 4670 35070 32620 4855 33970 32275 4905 31775 31065 5005
21 15 32275 25020 4010 30895 25220 4135 30205 24870 4180 28810 24170 4265
0.32 24 17 33320 26150 4190 31235 25405 4405 30535 25135 4485 29145 24610 4650
Medium 969
in.wg 27 19 34700 26220 4265 32275 25645 4485 31235 25110 4565 29150 24040 4730
32 23 36095 30760 4485 33320 30015 4665 32275 29695 4710 30190 28580 4805
21 15 29690 21270 3730 28425 21435 3845 27785 21140 3885 26505 20545 3965
24 17 30655 22225 3895 28735 21595 4095 28095 21365 4170 26810 20915 4325
Low 320
27 19 31925 22285 3965 29690 21795 4170 28735 21345 4250 26815 20435 4400
32 23 33205 26145 4170 30655 25510 4335 29690 25240 4380 27775 24295 4470
59
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT42-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT42-718
38QDMT42-718
Indoor Conditions Outdoor Ambient Temperature
Temp. °C 35°C 43°C 46°C 52°C
Air
ESP Fan Capacity Capacity Capacity Capacity
Flow Input Input Input Input
in.wg Speed DB WB Btu/hr Btu/hr Btu/hr Btu/hr
cfm W W W W
Total Sensible Total Sensible Total Sensible Total Sensible
21 15 33565 26873 4160 32133 27085 4290 31413 26710 4335 29965 25960 4425
24 17 34655 28085 4345 32488 27285 4570 31763 27000 4655 30305 26423 4825
High 1043
27 19 36090 28158 4425 33568 27540 4655 32488 26970 4740 30315 25820 4910
32 23 37540 33035 4655 34655 32235 4840 33570 31895 4890 31395 30695 4990
21 15 31890 24725 3995 30530 24920 4120 29845 24575 4165 28470 23885 4250
0.36 24 17 32925 25840 4175 30865 25105 4390 30175 24840 4470 28790 24310 4635
Medium 933
in.wg 27 19 34290 25910 4250 31890 25340 4470 30865 24815 4555 28800 23755 4715
32 23 35665 30395 4470 32925 29660 4650 31895 29345 4695 29830 28240 4795
21 15 29340 21015 3715 28085 21185 3835 27455 20890 3875 26190 20305 3955
24 17 30290 21965 3880 28395 21340 4085 27765 21115 4160 26490 20665 4310
Low 263
27 19 31545 22020 3955 29340 21540 4160 28395 21095 4235 26500 20195 4385
32 23 32810 25835 4160 30290 25210 4325 29345 24945 4370 27440 24005 4460
21 15 33160 26550 4145 31745 26760 4275 31035 26390 4320 29605 25650 4410
24 17 34240 27750 4330 32100 26960 4555 31385 26680 4640 29935 26100 4810
High 1007
27 19 35655 27820 4410 33165 27210 4640 32100 26650 4725 29950 25510 4895
32 23 37090 32640 4640 34240 31850 4825 33170 31515 4875 31015 30325 4975
21 15 31505 24430 3980 30160 24620 4105 29485 24280 4150 28125 23600 4235
0.40 24 17 32530 25530 4160 30495 24805 4375 29820 24550 4455 28440 24015 4620
Medium 897
in.wg 27 19 33875 25595 4235 31510 25035 4455 30495 24520 4540 28455 23470 4700
32 23 35240 30030 4455 32530 29305 4635 31515 28995 4680 29465 27900 4780
21 15 28985 20765 3705 27750 20930 3820 27125 20640 3860 25875 20060 3940
24 17 29930 21705 3870 28060 21085 4070 27435 20865 4145 26165 20415 4295
Low 206
27 19 31165 21760 3940 28990 21280 4145 28060 20845 4220 26180 19950 4375
32 23 32420 25525 4145 29930 24910 4310 28995 24645 4355 27110 23715 4445
60
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT42-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT42-718
38QDMT42-518
Indoor Conditions Outdoor Ambient Temperature
Temp. °C 35°C 43°C 46°C 52°C
Air
ESP Fan Capacity Capacity Capacity Capacity
Flow Input Input Input Input
in.wg Speed DB WB Btu/hr Btu/hr Btu/hr Btu/hr
cfm W W W W
Total Sensible Total Sensible Total Sensible Total Sensible
21 15 39990 33355 4155 38270 33605 4280 37410 33145 4325 35690 32215 4410
24 17 41280 34855 4335 38700 33865 4555 37840 33520 4640 36120 32825 4805
High 1370
27 19 43000 34950 4420 39990 34185 4645 38700 33475 4725 36120 32055 4890
32 23 44720 41000 4640 41280 40010 4820 39990 39590 4865 37410 38735 4965
21 15 37995 30690 3990 36360 30920 4110 35540 30495 4155 33910 29635 4235
0 24 17 39220 32075 4165 36765 31165 4375 35950 30840 4455 34315 30205 4615
Medium 1260
in.wg 27 19 40850 32160 4245 37995 31455 4460 36765 30800 4540 34315 29490 4695
32 23 42485 37730 4455 39220 36810 4630 37995 36420 4675 35540 35640 4770
21 15 34955 26090 3715 33450 26280 3825 32705 25925 3865 31200 25200 3940
24 17 36085 27265 3875 33825 26485 4070 33075 26215 4145 31575 25670 4290
Low 715
27 19 37585 27335 3950 34955 26735 4150 33825 26185 4220 31575 25070 4365
32 23 39090 32070 4145 36085 31290 4305 34955 30960 4350 32705 30295 4435
21 15 39125 32645 4135 37445 32890 4260 36605 32435 4305 34930 31530 4390
24 17 40390 34105 4315 37870 33140 4530 37025 32800 4615 35350 32120 4780
High 1300
27 19 42075 34195 4395 39125 33450 4620 37870 32755 4700 35345 31360 4865
32 23 43755 40120 4615 40390 39150 4795 39125 38735 4845 36605 37750 4940
21 15 37175 30035 3970 35575 30260 4090 34780 29840 4135 33190 29005 4215
0.08 24 17 38375 31380 4145 35975 30490 4355 35175 30180 4430 33585 29555 4590
Medium 1190
in.wg 27 19 39970 31465 4220 37175 30785 4435 35975 30135 4520 33580 28860 4675
32 23 41565 36915 4430 38375 36020 4605 37175 35640 4655 34780 34725 4745
21 15 34200 25525 3695 32730 25725 3805 31995 25365 3845 30530 24660 3920
24 17 35305 26680 3855 33100 25920 4045 32365 25650 4125 30900 25120 4270
Low 636
27 19 36775 26750 3925 34200 26165 4125 33100 25615 4205 30895 24530 4350
32 23 38245 31375 4125 35305 30615 4285 34200 30295 4330 31995 29520 4410
21 15 38695 32280 4125 37030 32525 4250 36205 32075 4295 34550 31180 4380
24 17 39945 33725 4305 37450 32775 4525 36620 32440 4605 34965 31770 4770
High 1255
27 19 41605 33820 4380 38695 33080 4605 37450 32395 4690 34955 31020 4850
32 23 43270 39675 4605 39945 38720 4785 38695 38300 4835 36205 37475 4930
21 15 36765 29700 3960 35180 29925 4080 34395 29510 4125 32820 28690 4205
0.12 24 17 37950 31035 4135 35580 30155 4345 34795 29845 4425 33220 29230 4580
Medium 1145
in.wg 27 19 39525 31115 4205 36765 30440 4425 35580 29810 4505 33210 28545 4660
32 23 41110 36505 4425 37950 35625 4595 36765 35240 4645 34395 34475 4735
21 15 33820 25240 3685 32365 25440 3800 31645 25085 3840 30200 24385 3915
24 17 34915 26380 3845 32735 25635 4045 32010 25370 4115 30565 24845 4260
Low 594
27 19 36365 26455 3915 33820 25875 4115 32735 25340 4190 30555 24255 4335
32 23 37820 31030 4115 34915 30285 4275 33820 29960 4320 31645 29310 4405
21 15 38260 31915 4110 36615 32160 4235 35800 31715 4280 34160 30830 4365
24 17 39500 33350 4290 37030 32405 4510 36210 32075 4590 34570 31410 4755
High 1223
27 19 41135 33440 4365 38260 32710 4590 37030 32030 4675 34565 30670 4840
32 23 42785 39235 4590 39500 38280 4770 38260 37880 4820 35800 36765 4915
21 15 36355 29365 3950 34790 29590 4070 34010 29185 4110 32455 28365 4195
0.16 24 17 37525 30685 4120 35180 29820 4330 34400 29510 4410 32845 28895 4565
Medium 1113
in.wg 27 19 39085 30770 4195 36355 30095 4410 35180 29470 4490 32840 28215 4650
32 23 40650 36095 4410 37525 35220 4580 36355 34850 4630 34010 33820 4720
21 15 33445 24965 3675 32005 25150 3785 31290 24805 3825 29860 24115 3900
24 17 34525 26090 3835 32365 25345 4030 31650 25085 4100 30215 24560 4245
Low 548
27 19 35955 26155 3900 33445 25585 4100 32365 25050 4175 30210 23990 4325
32 23 37400 30685 4100 34525 29940 4260 33445 29620 4305 31290 28750 4390
61
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT42-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT42-718
38QDMT42-518
Indoor Conditions Outdoor Ambient Temperature
Temp. °C 35°C 43°C 46°C 52°C
Air
ESP Fan Capacity Capacity Capacity Capacity
Flow Input Input Input Input
in.wg Speed DB WB Btu/hr Btu/hr Btu/hr Btu/hr
cfm W W W W
Total Sensible Total Sensible Total Sensible Total Sensible
21 15 37825 31555 4095 36205 31795 4220 35390 31355 4265 33770 30485 4355
24 17 39045 32970 4275 36605 32035 4495 35795 31705 4575 34170 31045 4740
High 1187
27 19 40670 33060 4355 37825 32335 4575 36605 31665 4660 34165 30320 4825
32 23 42300 38785 4575 39045 37845 4755 37825 37445 4805 35385 36045 4900
21 15 35940 29035 3935 34395 29250 4055 33625 28855 4095 32080 28050 4185
0.20 24 17 37095 30340 4105 34780 29475 4315 34010 29175 4395 32465 28565 4550
Medium 1077
in.wg 27 19 38640 30420 4185 35940 29755 4395 34780 29135 4475 32460 27895 4635
32 23 40185 35685 4395 37095 34820 4565 35940 34455 4615 33620 33170 4705
21 15 33065 24680 3660 31645 24865 3770 30935 24525 3810 29515 23845 3885
24 17 34130 25785 3820 31995 25055 4015 31285 24800 4085 29870 24280 4235
Low 491
27 19 35545 25860 3885 33065 25290 4085 31995 24765 4165 29865 23715 4310
32 23 36970 30335 4085 34130 29600 4245 33065 29290 4290 30930 28195 4375
21 15 37390 31195 4080 35795 31435 4205 33940 30070 4250 30230 27285 4340
24 17 38600 32595 4260 36185 31675 4485 35380 31340 4565 33770 30685 4730
High 1151
27 19 34825 32685 4340 37390 31970 4555 36135 31255 4640 33620 29835 4805
32 23 41815 38370 4560 38600 37415 4740 37390 37015 4790 34970 36205 4885
21 15 35525 28705 3920 34010 28930 4045 32245 27670 4080 28720 25110 4170
0.24 24 17 36670 29990 4090 34380 29140 4310 33610 28840 4385 32080 28230 4540
Medium 1041
in.wg 27 19 33090 30075 4170 35525 29415 4375 34325 28760 4455 31940 27450 4615
32 23 39730 35300 4380 36670 34425 4550 35525 34055 4600 33225 33315 4690
21 15 32680 24395 3645 31285 24590 3760 29665 23515 3800 26425 21345 3880
24 17 33740 25495 3805 31630 24770 4005 30925 24515 4080 29515 24000 4225
Low 434
27 19 30440 25565 3880 32680 25000 4070 31585 24450 4145 29380 23335 4290
32 23 36545 30005 4075 33740 29260 4235 32680 28950 4280 30570 28320 4365
21 15 36955 30830 4065 35380 31080 4195 34590 30650 4235 33010 29795 4325
24 17 38150 32220 4245 35760 31305 4470 34965 30975 4550 33375 30335 4715
High 1115
27 19 28985 32305 4325 36955 31600 4540 35770 30945 4625 33390 29635 4790
32 23 41325 37955 4545 38155 36990 4725 36960 36585 4775 34575 35800 4870
21 15 35110 28365 3905 33610 28595 4030 32865 28200 4070 31360 27420 4155
0.28 24 17 36245 29640 4075 33980 28800 4295 33220 28500 4370 31710 27905 4530
Medium 1005
in.wg 27 19 27540 29720 4155 35110 29075 4365 33985 28475 4440 31725 27270 4600
32 23 39260 34920 4365 36250 34030 4540 35115 33665 4585 32850 32935 4680
21 15 32300 24115 3635 30925 24305 3745 30235 23970 3785 28855 23300 3865
24 17 33345 25205 3795 31260 24480 3995 30565 24230 4065 29175 23725 4210
Low 377
27 19 25335 25265 3865 32300 24715 4055 31265 24200 4130 29190 23180 4280
32 23 36120 29685 4060 33350 28930 4220 32305 28620 4265 30220 27995 4355
21 15 36520 30465 4050 34960 30710 4180 34175 30285 4220 32600 29435 4310
24 17 37705 31840 4230 35345 30935 4450 34555 30605 4530 32980 29965 4695
High 1079
27 19 39265 31925 4310 36520 31225 4530 35345 30575 4615 32985 29270 4780
32 23 40840 37450 4530 37705 36545 4710 36520 36160 4760 34160 34800 4855
21 15 34700 28030 3890 33215 28255 4015 32475 27865 4055 30975 27080 4140
0.32 24 17 35820 29300 4065 33580 28465 4275 32830 28165 4355 31335 27575 4515
Medium 969
in.wg 27 19 37305 29375 4140 34700 28730 4355 33580 28130 4430 31340 26935 4590
32 23 38805 34460 4355 35820 33630 4530 34700 33270 4570 32455 32020 4665
21 15 31920 23835 3620 30560 24015 3730 29870 23685 3770 28495 23020 3850
24 17 32955 24900 3780 30895 24195 3975 30205 23935 4045 28825 23430 4200
Low 320
27 19 34320 24970 3850 31920 24415 4045 30895 23915 4125 28830 22895 4270
32 23 35700 29295 4045 32955 28580 4205 31920 28275 4250 29860 27220 4340
62
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT42-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT42-718
38QDMT42-518
Indoor Conditions Outdoor Ambient Temperature
Temp. °C 35°C 43°C 46°C 52°C
Air
ESP Fan Capacity Capacity Capacity Capacity
Flow Input Input Input Input
in.wg Speed DB WB Btu/hr Btu/hr Btu/hr Btu/hr
cfm W W W W
Total Sensible Total Sensible Total Sensible Total Sensible
21 15 36085 30105 4040 34545 30345 4165 33770 29925 4205 32215 29085 4295
24 17 37255 31465 4215 34925 30570 4435 34150 30245 4520 32580 29600 4685
High 1043
27 19 38800 31545 4295 36090 30855 4520 34925 30215 4600 32590 28930 4765
32 23 40360 37010 4520 37255 36115 4695 36090 35735 4745 33750 34390 4845
21 15 34285 27700 3880 32820 27920 4000 32085 27530 4045 30610 26760 4125
0.36 24 17 35395 28950 4050 33180 28125 4260 32440 27830 4340 30950 27235 4500
Medium 933
in.wg 27 19 36865 29025 4125 34285 28390 4340 33180 27805 4420 30960 26615 4575
32 23 38340 34050 4340 35395 33225 4515 34290 32880 4555 32070 31640 4655
21 15 31545 23545 3605 30195 23735 3720 29515 23405 3760 28155 22750 3840
24 17 32565 24610 3765 30525 23910 3965 29850 23655 4040 28480 23150 4185
Low 263
27 19 33915 24670 3840 31545 24135 4040 30525 23635 4110 28490 22625 4255
32 23 35275 28945 4040 32565 28245 4200 31550 27950 4240 29500 26895 4330
21 15 35650 29745 4025 34130 29980 4150 33365 29565 4195 31830 28735 4280
24 17 36810 31090 4205 34510 30205 4420 33740 29890 4505 32185 29240 4670
High 1007
27 19 38330 31170 4280 35655 30485 4505 34510 29855 4585 32200 28580 4750
32 23 39875 36565 4505 36810 35680 4685 35660 35305 4730 33345 33970 4830
21 15 33870 27370 3865 32425 27585 3985 31700 27205 4030 30235 26440 4110
0.40 24 17 34970 28600 4040 32785 27795 4245 32060 27505 4325 30575 26905 4485
Medium 897
in.wg 27 19 36420 28675 4110 33875 28050 4325 32785 27470 4405 30590 26295 4560
32 23 37885 33645 4325 34970 32830 4500 33880 32480 4540 31675 31255 4640
21 15 31160 23265 3595 29835 23445 3710 29160 23125 3745 27820 22475 3825
24 17 32175 24320 3755 30165 23625 3950 29495 23375 4025 28130 22875 4170
Low 206
27 19 33505 24380 3825 31165 23845 4025 30165 23355 4095 28145 22355 4245
32 23 34855 28595 4025 32175 27905 4185 31170 27610 4225 29145 26570 4315
63
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT48-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT48-718
38QDMT48-518
64
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT48-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT48-718 38QDMT48-518
Indoor Conditions Outdoor Ambient Temperature
Temp. °C 35°C 43°C 46°C 52°C
Air
ESP Fan Capacity Capacity Capacity Capacity
Flow Input Input Input Input
in.wg Speed DB WB Btu/hr Btu/hr Btu/hr Btu/hr
cfm W W W W
Total Sensible Total Sensible Total Sensible Total Sensible
21 15 39670 31470 3875 37970 31700 3995 37105 31270 4040 35405 30415 4120
24 17 40945 32885 4050 38385 31940 4255 37535 31615 4335 35830 30955 4490
High 1187
27 19 42645 32975 4120 39660 32245 4327 38385 31575 4440 35830 30240 4585
32 23 44350 38675 4335 39965 37740 4505 39665 37345 4555 39070 36545 4645
21 15 37690 28955 3720 36075 29170 3840 35250 28770 3880 33635 27985 3960
0.20 24 17 38900 30260 3890 36470 29390 4085 35660 29090 4165 34040 28485 4315
Medium 1077
in.wg 27 19 40515 30335 3960 37680 29670 4155 36470 29055 4265 34040 27820 4405
32 23 42135 35585 4165 37970 34720 4325 37685 34360 4375 37120 33620 4460
21 15 34675 24615 3460 33190 24790 3570 32430 24455 3610 30945 23785 3680
24 17 35790 25720 3620 33550 24980 3800 32810 24730 3875 31320 24215 4010
Low 491
27 19 37275 25790 3680 34665 25220 3865 33550 24695 3965 31320 23650 4095
32 23 38765 30250 3875 34930 29515 4025 34670 29205 4070 34150 28585 4150
21 15 39325 31200 3860 33910 28320 3980 33150 27940 4025 31635 27170 4105
24 17 40595 32600 4040 34480 28695 4245 33720 28400 4325 32195 27820 4480
High 1151
27 19 42270 32690 4105 35040 28490 4315 33915 27905 4390 31665 26730 4540
32 23 43965 38340 4320 37265 35195 4490 36990 25130 4535 36440 35885 4630
21 15 37360 28705 3710 32215 26055 3825 31495 25705 3865 30055 25000 3945
0.24 24 17 38570 29995 3880 32760 26405 4080 32035 26130 4155 30590 25595 4305
Medium 1041
in.wg 27 19 40160 30080 3945 33290 26215 4145 32220 25675 4215 30085 24595 4360
32 23 41770 35275 4150 35405 32380 4315 35145 23125 4355 34620 33020 4445
21 15 34375 24400 3450 29640 22150 3555 28975 21850 3595 27650 21250 3665
24 17 35485 25495 3610 30140 22445 3790 29475 22210 3865 28140 21760 4000
Low 434
27 19 36945 25565 3665 30625 22280 3855 29645 21825 3920 27680 20910 4055
32 23 38430 29985 3860 32570 27525 4010 32330 19655 4050 31850 28070 4135
21 15 38985 30925 3845 35445 24935 3965 34655 29200 4005 33070 28400 4090
24 17 40235 32325 4025 35940 25450 4230 35140 29605 4310 33545 28995 4465
High 1115
27 19 41900 32405 4090 36835 24730 4300 35650 29330 4375 33285 28095 4525
32 23 43575 38005 4305 38095 32640 4475 37810 35600 4520 37245 36680 4615
21 15 37040 28455 3695 33675 22945 3810 32925 26870 3845 31420 26130 3930
0.28 24 17 38225 29740 3865 34145 23420 4065 33385 27240 4140 31870 26675 4290
Medium 1005
in.wg 27 19 39805 29810 3930 34995 22750 4130 33870 26985 4200 31625 25855 4345
32 23 41400 34970 4135 36195 30035 4300 35920 32755 4340 35385 33745 4435
21 15 34075 24190 3435 30980 19505 3540 30290 22840 3580 28905 22210 3655
24 17 35170 25280 3595 31415 19905 3780 30715 23150 3850 29320 22675 3990
Low 377
27 19 36625 25340 3655 32195 19340 3840 31160 22940 3910 29095 21975 4040
21 23 38085 29725 3845 33300 25530 4000 33050 27840 4040 32555 28685 4125
21 15 38645 30655 3830 36975 30875 3950 36150 30465 3990 34500 29630 4075
24 17 39885 32035 4015 37400 31120 4220 36565 30805 4300 34910 30165 4455
High 1079
27 19 41530 32115 4075 38625 31400 4275 37380 30755 4355 34895 29460 4505
32 23 43190 37665 4290 38920 36760 4460 38635 36370 4505 38055 37475 4600
21 15 36715 28205 3680 35130 28410 3795 34345 28035 3835 32775 27260 3915
0.32 24 17 37895 29475 3855 35530 28630 4055 34740 28340 4130 33165 27755 4280
Medium 969
in.wg 27 19 39455 29550 3915 36695 28890 4105 35515 28295 4185 33155 27105 4325
32 23 41035 34655 4120 36975 33820 4285 36705 33465 4325 36155 34480 4420
21 15 33780 23975 3420 32320 24150 3530 31600 23825 3565 30155 23170 3640
24 17 34860 25055 3585 32690 24335 3770 31960 24090 3840 30515 23595 3980
Low 320
27 19 36300 25120 3640 33760 24560 3820 32675 24055 3890 30500 23040 4025
32 23 37750 29455 3835 34020 28745 3985 33770 28445 4025 33265 29310 4110
65
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT48-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT48-718 38QDMT48-518
66
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT60-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT60-718
38QDMT60-518
67
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT60-518 Heat Pump 42QDMT60-718
380-420V/3Ph/50Hz 38QDMT60-518
Indoor Conditions Outdoor Ambient Temperature
Temp. °C 35°C 43°C 46°C 52°C
Air
ESP Fan Capacity Capacity Capacity Capacity
Flow Input Input Input Input
in.wg Speed DB WB Btu/hr Btu/hr Btu/hr Btu/hr
cfm W W W W
Total Sensible Total Sensible Total Sensible Total Sensible
21 15 46600 35590 4360 44595 35775 4505 43595 35400 4550 41595 34645 4640
24 17 48105 37210 4545 45100 36195 4775 44100 35800 4860 42100 35010 5030
High 1314
27 19 50100 38270 4635 46595 36500 4865 45100 35760 4955 42110 34275 5135
32 23 52115 43790 4870 48100 42720 5055 46615 42300 5105 43645 41460 5205
21 15 44270 32745 4190 42370 32915 4325 41420 32570 4370 39520 31875 4455
0.20 24 17 45700 34235 4365 42845 33305 4585 41895 32940 4670 39995 32210 4830
Medium 1219
in.wg 27 19 47595 35210 4450 44270 33580 4675 42845 32895 4760 40005 31535 4930
32 23 49510 40290 4680 45695 39305 4855 44285 38920 4905 41465 38145 5000
21 15 40730 27835 3895 38980 27980 4025 38105 27685 4065 36355 27095 4145
24 17 42045 29100 4060 39420 28310 4265 38545 28000 4340 36800 27380 4495
Low 703
27 19 43790 29925 4140 40725 28545 4345 39420 27965 4425 36805 26810 4585
32 23 45550 34245 4350 42040 33410 4515 40745 33080 4560 38150 32425 4650
21 15 46190 35285 4340 44210 35470 4485 43215 35095 4530 38525 32090 4620
24 17 47685 36890 4525 44715 35890 4755 43725 35500 4840 41745 34715 5010
High 1283
27 19 49660 37935 4615 46185 36185 4850 44710 35450 4940 41760 33995 5125
32 23 51660 43410 4850 47675 42340 5035 46225 41945 5085 43325 41165 5185
21 15 43885 32465 4170 42000 32635 4310 41055 32290 4350 36600 29525 4440
0.24 24 17 45305 33940 4345 42480 33020 4565 41540 32665 4650 39660 31940 4810
Medium 1188
in.wg 27 19 47180 34905 4435 43880 33290 4660 42475 32620 4745 39675 31280 4920
32 23 49080 39940 4660 45295 38955 4835 43915 38595 4885 41160 37875 4980
21 15 40375 27595 3875 38640 27740 4005 37770 27445 4045 33675 25100 4125
24 17 41680 28850 4040 39085 28070 4250 38220 27765 4325 36490 27155 4475
Low 678
27 19 43405 29670 4125 40370 28300 4335 39080 27725 4415 36500 26590 4580
32 23 45155 33955 4335 41670 33110 4500 40405 32805 4540 37870 32190 4630
21 15 45780 34975 4325 44820 35965 4470 43810 35580 4515 41795 34815 4605
24 17 47260 36560 4510 44315 35570 4740 43335 35185 4825 41365 34400 4995
High 1252
27 19 49220 37600 4595 45775 35865 4825 44315 35140 4915 41390 33695 5095
32 23 51200 43025 4830 47250 41965 5015 45815 41575 5065 4290 40800 5165
21 15 43495 32180 4155 42580 33090 4295 41620 32735 4335 39710 32035 4425
0.28 24 17 44900 33640 4330 42100 32730 4555 41170 32370 4635 39300 31650 4800
Medium 1157
in.wg 27 19 46760 34595 4415 43490 33000 4635 42100 32335 4720 39325 31000 4895
32 23 48640 39585 4640 44890 38610 4815 43525 38250 4865 4080 37540 4960
21 15 40015 27355 3865 39175 28125 3995 38290 27825 4035 36530 27230 4115
24 17 41310 28590 4030 38735 27820 4235 37875 27515 4310 36155 26905 4460
Low 653
27 19 43020 29405 4105 40010 28045 4310 38735 27485 4390 36175 26350 4550
32 23 44750 33645 4315 41300 32820 4480 40045 32515 4525 3750 31910 4615
21 15 45365 34655 4310 43420 34835 4455 42440 34465 4500 40485 33725 4590
24 17 46835 36230 4495 43915 35245 4725 42940 34860 4810 40985 34080 4980
High 1221
27 19 48780 37260 4575 45365 35540 4805 43915 34820 4895 41015 33390 5075
32 23 50740 42640 4810 46825 41590 4995 45400 41195 5045 42550 40425 5145
21 15 43100 31885 4140 41250 32050 4280 40320 31710 4320 38465 31030 4410
0.32 24 17 44495 33335 4320 41720 32430 4540 40795 32070 4620 38940 31360 4785
Medium 1126
in.wg 27 19 46345 34280 4395 43100 32695 4615 41720 32040 4700 38965 30720 4875
32 23 48205 39230 4620 44485 38265 4800 43130 37900 4845 40425 37190 4940
21 15 39650 27100 3850 37950 27245 3980 37095 26955 4020 35385 26375 4100
24 17 40935 28335 4015 38385 27565 4220 37530 27265 4295 35825 26655 4450
Low 628
27 19 42635 29140 4085 39650 27795 4290 38385 27235 4375 35850 26110 4535
32 23 44350 33345 4295 40930 32525 4460 39680 32220 4505 37190 31615 4595
68
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT60-518 Heat Pump
42QDMT60-718
380-420V/3Ph/50Hz 38QDMT60-518
69
14. Operating Limits - Heating
HEATING
Dry Bulb Wet Bulb
Difference
Temp. C° Temp. C°
Indoor temperature
Maximum 27 -
Outdoor temperature
Maximum 24 18
Minimum 2 1
53QDMT18-718
53QDMT24-718
220-240/1/50 198 254
53QDMT30-718
53QDMT36-718
53QDMT42-718
53QDMT36-518
53QDMT42-518
380-420/3/50 342 462
53QDMT48-518
53QDMT60-518
NOTES:
* When the unit is operated above or below these limits for a long time,
system diagnostics may detect a malfunction and the unit will not operate properly.
** During heat pump operation, the system will undergo several defrost cycles to eliminate ice that
might possibly collect on the outdoor unit in very low ambient temperatures.
After completion of defrost cycle, the system will normally operate
70
15. System Heating Performance Data
Ducted Split System
53QDMT12-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT12-718
38QDMT12-718
71
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT12-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT12-718
38QDMT12-718
72
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT18-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT18-718
38QDMT18-718
Indoor Conditions Outdoor Ambient Temperature
Air 24/18°C DB/WB 7/6°C DB/WB 2/1°C DB/WB
ESP Fan Temp. °C
Flow Capacity Input Capacity Input Capacity Input
in.wg Speed DB
cfm Btu/hr W Btu/hr W Btu/hr W
73
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT18-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT18-718
38QDMT18-718
Indoor Conditions Outdoor Ambient Temperature
Air 24/18°C DB/WB 7/6°C DB/WB 2/1°C DB/WB
ESP Fan Temp. °C
Flow Capacity Input Capacity Input Capacity Input
in.wg Speed DB
cfm Btu/hr W Btu/hr W Btu/hr W
74
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT24-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT24-718
38QDMT24-718
75
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT24-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT24-718
38QDMT24-718
76
System Heating Performance Data (Cont.)
77
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT30-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT30-718
38QDMT30-718
78
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT30-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT30-718
38QDMT30-718
79
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT36-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT36-718
38QDMT36-718
80
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT36-718 Heat Pump
42QDMT36-718
220-240V/1Ph/50Hz
38QDMT36-718
81
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT36-718 Heat Pump
42QDMT36-718
220-240V/1Ph/50Hz
38QDMT36-718
82
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT36-518 Heat Pump
42QDMT36-718
380-420V/3Ph/50Hz
38QDMT36-518
83
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT36-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT36-718
38QDMT36-518
84
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT36-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT36-718
38QDMT36-518
85
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT42-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT42-718
38QDMT42-718
86
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT42-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT42-718
38QDMT42-718
87
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT42-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT42-718
38QDMT42-718
88
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT42-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT42-718
38QDMT42-518
89
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT42-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT42-718
38QDMT42-518
90
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT42-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT42-718
38QDMT42-518
91
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT48-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT48-718
38QDMT48-518
92
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT48-518 Heat Pump
42QDMT48-718
380-420V/3Ph/50Hz
38QDMT48-518
93
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT48-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT48-718
38QDMT48-518
94
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT60-518 Heat Pump
42QDMT60-718
380-420V/3Ph/50Hz
38QDMT60-518
95
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT60-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT60-718
38QDMT60-518
96
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT60-518 Heat Pump
42QDMT60-718
380-420V/3Ph/50Hz
38QDMT60-518
97
16. Electrical Data
Electrical Consumption
Split Starting System
Cooling Heating Circuit
System Current Power
35 °C 43 °C 46 °C 52 °C Breaker
Model (Note 1) Supply *****
* ** *** ****
Heat Pump Amp V/Ph/Hz Amp Watt Amp Watt Amp Watt Amp Watt Amp Watt Amp
53QDMT12-718 35 220-240 5.9 1265 6.5 1330 6.8 1355 7.3 1400 5.1 1045 16
53QDMT18-718 58 220-240 9.2 1985 10.4 2095 10.9 2135 11.9 2215 7.8 1695 20
53QDMT24-718 72 220-240 11.2 2415 12.4 2540 12.9 2585 13.8 2675 10.2 2125 25
53QDMT30-718 91 220-240 16.3 3515 18.5 3690 19.4 3760 21.1 3900 12.3 2755 32
53QDMT36-718 115 220-240 20.9 4195 23.7 4400 24.7 4490 26.7 4670 16.8 3220 40
53QDMT36-518 61 380-420 7.2 4105 8.3 4315 8.6 4405 9.3 4580 5.9 3200 20
53QDMT42-718 115 220-240 22.5 4555 25.3 4785 26.4 4870 28.4 5040 16.9 3200 40
53QDMT42-518 61 380-420 7.2 4245 8.3 4460 8.6 4540 9.3 4695 5.4 2975 20
53QDMT48-518 61 380-420 7.5 4200 8.6 4415 9.0 4490 9.7 4645 6.7 3795 20
53QDMT60-518 77 380-420 8.3 4725 9.4 4960 9.8 5050 10.6 5230 7.6 4155 20
NOTES
2. Operating Conditions.
* @ 35ºC db outdoor temperature :
27/19ºC db/wb Indoor Temperature. High air flow of indoor unit
98
17. Wiring Diagrams
Wiring Diagram
53QDMT12-718 Heat Pump 220-240/1/50
53QDMT18-718 Heat Pump 220-240/1/50
TO WIRED CONTROLLER
99
Wiring Diagrams (Cont.)
Wiring Diagram
53QDMT12-718 Heat Pump 220-240/1/50
53QDMT18-718 Heat Pump 220-240/1/50
LEGEND : INDOOR UNIT
CAP1 : INDOOR FAN CAP. KM1 : RELAY FOR COMPRESSOR
CN1-CN33 : P.C.B SOCKETS RT1 : INDOOR – AIR SENSOR
T4 : TRANSFORMER RT2 : INDOOR COIL SENSOR
FAN1 : INDOOR MOTOR XT1 : 8-WAY TERMINAL
XP1 ˜ 4 : CONNECTORS K3 : WATER LEVEL SWITCH
XS1 ˜ 4 : CONNECTORS RY6 : COMP. RELAY WIRING
LEGEND : OUTDOOR UNIT
COMP : COMPRESSOR RVS : 4 WAY REVERSING VALVE
FM : FAN MOTOR RT3 : OUTDOOR COIL SENSOR
CONT : CONTACTOR CTB : COND. TERMINAL BLOCK
DC : DUAL CAPACITOR
LEGEND : TERMINAL BOX
1 : LIVE CONNECTION 3 : REVERSING VALVE CONTROL
2 : NEUTRAL CONNECTION 4 : OUTDOOR FAN CONTROL
LEGEND : WIRE COLORS
WH : WHITE BR : BROWN
BK : BLACK BL : BLUE
RD : RED OR : ORANGE
GR : GREEN YL : YELLOW
YL/ GR : YELLOW / GREEN
NOTES
➀ MAIN SWITCH ➁ TIME DELAY FUSE OR CIRCUIT BREAKER
➂ DOTTED WIRES TO BE FITTED BY INSTALLER ➃ ALL ITEMS IN DASHED RECTANGLES ARE OPTIONAL
➄ THE SYSTEM SHALL BE INSTALLED ACCORDING TO NATIONAL WIRING REGULATIONS
100
Wiring Diagrams (Cont.)
Wiring Diagram
53QDMT24-718 Heat Pump 220-240/1/50
53QDMT30-718 Heat Pump 220-240/1/50
53QDMT36-718 Heat Pump 220-240/1/50
53QDMT42-718 Heat Pump 220-240/1/50
101
Wiring Diagrams (Cont.)
Wiring Diagram
53QDMT24-718 Heat Pump 220-240/1/50
53QDMT30-718 Heat Pump 220-240/1/50
53QDMT36-718 Heat Pump 220-240/1/50
53QDMT42-718 Heat Pump 220-240/1/50
LEGEND : INDOOR UNIT
CAP1 : INDOOR FAN CAP. KM1 : RELAY FOR COMPRESSOR
CN1-CN33 : P.C.B SOCKETS RT1 : INDOOR AIR SENSOR
T4 : TRANSFORMER RT2 : INDOOR COIL SENSOR
FAN1 : INDOOR MOTOR XT1 : 8-WAY TERMINAL
XP1 ˜ 4 : CONNECTORS K3 : WATER LEVEL SWITCH
XS1 ˜ 4 : CONNECTORS CN20 : NET CONTROL INTERFACE
LEGEND : OUTDOOR UNIT
COMP : COMPRESSOR RVS : 4 WAY REVERSING VALVE
OFM : OUTDOOR FAN MOTOR RT3 : OUTDOOR COIL SENSOR
CONT : CONTACTOR CTB : COND. TERMINAL BLOCK
DC : DUAL CAPACITOR
LEGEND : TERMINAL BOX
L : LIVE CONNECTION 1 : COMPRESSOR CONTROL
N : NEUTRAL CONNECTION 2 : REVERSING VALVE CONTROL
3 : OUTDOOR FAN CONTROL
WIRE COLORS
WH : WHITE OR : ORANGE
BK : BLACK BL : BLUE
BR : BROWN RD : RED
YL : YELLOW YL/ GR : YELLOW / GREEN
NOTES
➀ MAIN SWITCH ➁ TIME DELAY FUSE OR CIRCUIT BREAKER
➂ DOTTED WIRES TO BE FITTED BY INSTALLER ➃ ALL ITEMS IN DASHED RECTANGLES ARE OPTIONAL
➄ THE SYSTEM SHALL BE INSTALLED ACCORDING TO NATIONAL WIRING REGULATIONS
102
Wiring Diagrams (Cont.)
Wiring Diagram
53QDMT36-518 Heat Pump 380-420/3/50
53QDMT42-518 Heat Pump 380-420/3/50
53QDMT48-518 Heat Pump 380-420/3/50
53QDMT60-518 Heat Pump 380-420/3/50
2 3 1
103
Wiring Diagrams (Cont.)
Wiring Diagram
53QDMT36-518 Heat Pump 380-420/3/50
53QDMT42-518 Heat Pump 380-420/3/50
53QDMT48-518 Heat Pump 380-420/3/50
53QDMT60-518 Heat Pump 380-420/3/50
LEGEND : INDOOR UNIT
CAP1 : INDOOR FAN CAP. RT1 : INDOOR AIR SENSOR
CN1-CN33 : P.C.B SOCKETS RT2 : INDOOR COIL SENSOR
T4 : TRANSFORMER XT1 : 8-WAY TERMINAL
FAN1 : FAN MOTOR K3 : WATER LEVEL SWITCH
XP1 ˜ 4 : CONNECTORS KM1 : RELAY FOR COMPRESSOR
XS1 ˜ 4 : CONNECTORS CN20 : NET CONTROL INTERFACE
LEGEND : OUTDOOR UNIT
COMP : COMPRESSOR RT3 : OUTDOOR COIL SENSOR
CONT : CONTACTOR FC : FAN CAPACITOR
CTB : COND. TERMINAL BLOCK FM : OUTDOOR FAN MOTOR
OL : OVERLOAD R : RESISTANCE
RVS : 4 WAY REVERSING VALVE C-HTR : CRANKCASE HEATER
LEGEND : TERMINAL BOX
A1 : LIVE CONNECTON W2 : OUTDOOR FAN CONTROL
N1 : NEUTRAL CONNECTON O : REVERSING VALVE CONTROL
Y : COMPRESSOR CONTROL
WIRE COLORS
WH : WHITE OR : ORANGE
BK : BLACK BL : BLUE
BR : BROWN RD : RED
YL : YELLOW YL/ GR : YELLOW / GREEN
NOTES
➀ MAIN SWITCH ➁ TIME DELAY FUSE OR CIRCUIT BREAKER
➂ DOTTED WIRES TO BE FITTED BY INSTALLER ➃ ALL ITEMS IN DASHED RECTANGLES ARE OPTIONAL
➄ THE SYSTEM SHALL BE INSTALLED ACCORDING TO NATIONAL WIRING REGULATIONS
104
18. Optional Accessories For Installation ( Field Supplied )
18.1 Branched Supply Air Front Panel
Branched supply air front panel can be field supplied and installed where
desired by using flexible ducts.
Comfortable air conditioning can be achieved without affecting the rooms
layout or decor.
Installation examples are shown below :
Rectangular Room
L-Shaped Room
Large Room
105
Optional Accessories For Installation ( Field Supplied ) (Cont.)
Branched Supply Air Front Panel (Cont.)
Indoor Branched Supply Air Front Panel
Unit
Size Shape Details
12K
18K
24K
30K
36K
42K
48K
60K
106
Optional Accessories For Installation ( Field Supplied ) (Cont.)
18.2 Convas Air Passage
Indoor Convas Air Passage
Unit
Size Shape Details
12K
18K
24K
30K
36K
42K
48K
60K
107
Optional Accessories For Installation ( Field Supplied ) (Cont.)
18.3 Front panel for Ducted Indoor unit size 12K
Front Panel
108
Optional Accessories For Installation ( Field Supplied ) (Cont.)
18.4 Front panel for Ducted Indoor unit size 18K
Front Panel
109
Optional Accessories For Installation ( Field Supplied ) (Cont.)
18.5 Front panel for Ducted Indoor unit size 24K
Front Panel
110
Optional Accessories For Installation ( Field Supplied ) (Cont.)
18.6 Front panel for Ducted Indoor units sizes 30K – 36K – 42K – 48K – 60K
Front Panel
111
19. Troubleshooting
Solving steps for typical malfunction
(1) For indoor unit
a. Indoor air sensor is abnormal
Whether the resistance of the air sensor is 10K No Replace indoor air sensor
Yes
Replace indoor PCB
Whether the resistance of indoor coil sensor is No Replace indoor coil sensor
10K
Yes
Replace indoor PCB
Whether the resistance of outdoor coil sensor is No Replace outdoor coil sensor
10K
Yes
Replace indoor PCB
112
Troubleshooting (Cont.)
Solving steps for typical malfunction (Cont.)
For indoor unit (Cont.)
d. Outdoor unit malfunction
Yes
Measure whether the voltage of the
communication line’s red and black end No Replace outdoor unit board
between the indoor and outdoor unit is +5V
Yes
Check the indoor unit main board CN5 or
replace the main control board
Yes
Replace indoor PCB
e. EEPROM malfunction
EEPROM malfunction
No
Check whether the main control chip 9177
is broken No Replace 9177 chip
No
Check PCB board or replace the main
control board
113
Troubleshooting (Cont.)
Solving steps for typical malfunction (Cont.)
For indoor unit (Cont.)
f. Full-water malfunction
Full-water malfunction
Check whether the water-level switch is No Insert the water-level switch well
inserted well
Yes
Check whether the water-level switch is broken Yes Replace the water-level switch
No
Check whether the water pump is normal No Replace the water pump
Yes
Check PCB board or replace the main control
board
114
Troubleshooting (Cont.)
Solving steps for typical malfunction (Cont.)
(2) For outdoor unit
a. Phase sequence error
Phase sequence error
b. Overload of current
Overload of current
c. Lack of phase
Lack of phase
Yes
Check the connection between power supply and terminal,
is the voltage in outdoor terminal is 3 phase, 380-420V?
Yes
Outdoor PCB is defective
115
Troubleshooting (Cont.)
Solving steps for typical malfunction (Cont.)
For outdoor unit (Cont.)
d. Protection of pressure or temp.
Protection of pressure or temp.
Yes
Is it k1 or K2 open ?
Yes Yes
Possible reason Possible reason
1. The wires is loose to K1 1. The wires is loose to K2
2. Air or other gas in the refrigerant. 2. Air or other gas in the refrigerant.
3. Heat exchanger is dirty 3. Heat exchanger is dirty
4. Outdoor fan or fan blade is defective 4. Outdoor fan or fan blade is defective
5. Outdoor unit is bad ventilation 5. Outdoor unit is bad ventilation
6. Refrigerant is leakage 6. Refrigerant is too much
7. K1 switch is defective 7. K2 switch is defective
Yes
Check the resistance of the temp. sensor according
to Annex 1
Yes
Indoor PCB is defective.
116
Troubleshooting (Cont.)
Solving steps for typical malfunction (Cont.)
For outdoor unit (Cont.)
f. Open-circuit and short-circuit trouble of T4
Is connection to connector of temp. sensor good? No Repair connector
Yes
Check the resistance of the temp. sensor according to Annex 1
Yes
Indoor PCB is defective.
Yes
Possible reason
1. Air or other gas in the refrigerant.
2. Outdoor coil is dirty
3. Outdoor fan or fan blade is defective
4. Outdoor unit is bad ventilation
5. Refrigerant is leakage
6. Outdoor PCB is defective
117
Troubleshooting (Cont.)
Appendix
Sensor Resistance Value Table ( °C – K )
Indoor Air Sensor
Indoor Coil Sensor
Outdoor Coil Sensor
°C K Ohm °C K Ohm °C K Ohm °C K Ohm
-20 115.266 20 12.6431 60 2.35774 100 0.62973
-19 108.146 21 12.0561 61 2.27249 101 0.61148
-18 101.517 22 11.5000 62 2.19073 102 0.59386
-17 96.3423 23 10.9731 63 2.11241 103 0.57683
-16 89.5865 24 10.4736 64 2.03732 104 0.56038
-15 84.2190 25 10.000 65 1.96532 105 0.54448
-14 79.3110 26 9.55074 66 1.89627 106 0.52912
-13 74.5360 27 9.12445 67 1.83003 107 0.51426
-12 70.1698 28 8.71983 68 1.76647 108 0.49989
-11 66.0898 29 8.33566 69 1.70547 109 0.48600
-10 62.2756 30 7.97078 70 1.64691 110 0.47256
-9 58.7079 31 7.62411 71 1.59068 111 0.45957
-8 56.3694 32 7.29464 72 1.53668 112 0.44699
-7 52.2438 33 6.98142 73 1.48481 113 0.43482
-6 49.3161 34 6.68353 74 1.43498 114 0.42304
-5 46.5725 35 6.40021 75 1.38703 115 0.41164
-4 44.0000 36 6.13059 76 1.34105 116 0.40060
-3 41.5878 37 5.87359 77 1.29078 117 0.38991
-2 39.8239 38 5.62961 78 1.25423 118 0.37956
-1 37.1988 39 5.39689 79 1.21330 119 0.36954
0 35.2024 40 5.17519 80 1.17393 120 0.35982
1 33.3269 41 4.96392 81 1.13604 121 0.35042
2 31.5635 42 4.76253 82 1.09958 122 0.3413
3 29.9058 43 4.57050 83 1.06448 123 0.33246
4 28.3459 44 4.38736 84 1.03069 124 0.32390
5 26.8778 45 4.21263 85 0.99815 125 0.31559
6 25.4954 46 4.04589 86 0.96681 126 0.30754
7 24.1932 47 3.88673 87 0.93662 127 0.29974
8 22.5662 48 3.73476 88 0.90753 128 0.29216
9 21.8094 49 3.58962 89 0.87950 129 0.28482
10 20.7184 50 3.45097 90 0.85248 130 0.27770
11 19.6891 51 3.31847 91 0.82643 131 0.27078
12 18.7177 52 3.19183 92 0.80132 132 0.26408
13 17.8005 53 3.07075 93 0.77709 133 0.25757
14 16.9341 54 2.95896 94 0.75373 134 0.25125
15 16.1156 55 2.84421 95 0.73119 135 0.24512
16 15.3418 56 2.73823 96 0.70944 136 0.23916
17 14.6181 57 2.63682 97 0.68844 137 0.23338
18 13.9180 58 2.53973 98 0.66818 138 0.22776
19 13.2631 59 2.44677 99 0.64862 139 0.22231
118