FOLOSUN
Reflex Sight
een
HS510C)
Corea
Allreflex sights have an objective lens a the rant ofthe unit that
positioned off axis and appears to be tilted when looking atthe
sight This angle ofthe front lens allows the lgnt generated by the LED
ser sees wnen agreendat
|. Aim with beth Eyes open. que
situational awareness
2. Advanced LED technology: Up t0 20.000 hours battery life for
Circle dot or 50.000 hours or dot only.
5 Advanced Super Solar Technology: allows for use even in low
target acquisition and
5. Multi Recticle System Dot, Circle & Circle Dot options
& Shake awake sensor.
7.10 DLE 2NV Compatible Brightness seztings.
9. Battery tray
10. Quick Detach Mount.
11,67 waterprostrating
ieee
1. You must check carefully to make sure your irearm is unloaded
before device installation zereing or changing the battery in your
‘optic. Ensure allrange and “reatme safety procedures are followed
stall times
2, Don't dispose of batteries az household waste, Please use 3
certified slectronicsreeyeting service
Cmnnemoee
button and hold it down until the reticle changes and then release
process to cycle between
Ss
‘Thankyou for purchasing a HS510C Reflex Sight from KOLOSUN
This open reflex sight feat
aluminum nousing and
fs circle dot reticle, 2 ruggea
nium hood. Khas Shake Awake
Technology and is dual powered by solar & battery Technology
Before operation, please read the User's Manual carefully
|. FailSafe operation with a aval power supply relay component and
battery) one high aualty CR2032 Lithium pattery is included with
your sight
2.Aigh quality battery ean
power thisdeview forupro
20.000 Hrlsot-eirele. or
50.000 Hrldot onb
battery (i951)
he included teardrop|
shaped teal inthe battery tay
slot, pry our the tray, and
remove the dead battery.
b.sattery installation tFig $-2)4
Linger the battery int the Sa Ws
battery tray making sure the ~ side faces up an
faces down
Insert and press the tray into the battery compartment
Tighten screws 12
Te [oss 01 damage ofthe seal ting may cause water toleak ince
‘the compartment which could damage the produc
Sn
1. The mount bracket is adaptable to standard Pie
required for mounting. Push the locking wutten, It up hanalle te
loosen the lacking bar Te mount
leverdown & the locking
installation is complete. see 94
eters bu
5 Initia instalation Fgh
proper ‘it,
There is one Torx socket st the end of clamp adjusting bolton the
side ofthe mount (See Fig 5) Before installation loosen the bolt to
loosen the clame using the included Terxwrench
2. Open the carn clamp lever. Side the sight into ralland close che,clamp lever. ensuring the sight ison the rll
3 Tighten the clamp adjusting bolt using the Torx wreneh This will
bbe5-10 nen / pound.
Brier
‘Twa operation modes are available: Auto mode and manual meds.
1 Switch on (see Fig6}: Press and release either brightness button
ror-}te turn an tne sighs
2, Power off Press the'+'and™’buttons simultaneously will turn
‘the power ana motion sensor off
3 Operation mode. Two operation modes are available Auto mode
and manual mode
‘Auto mode cerault)- with solar cell and internal battery wo-
\way power supply: Based upon the ambient lighting level the
sight will switch between battery and solar cellpower
automatically for operation in alllighting conditions
2} Under auto mode, the brightness ofthe reticle is automatically
adjusted to match ambient lighting
') The pattery wllompensate for power ifthe solar cellcannat
drive
the reticle alone,
€)iflighting is low enough. the sight willautoratially switen to
‘thebbattery, While running on battery. you can adjust the reticle
brightness using the "and" buttons to switch between high
and low brightness levels
43) Press down the "button for seconds to enter inte the Manual
Mode.
b) Brightness adjustment. There are 12
19 forreticte
e) Switching backto auto mede-Asingle press of the "button for
seconds will ewiteh the sigh
1) Holding down the button for willeyele between the twe
4. Sleep time mode
11Please note that your green dat will automaticaly enterinto
sleep 1) Please nate tnat your green dot will automatically enter
2) The sight will instantaneously wake up and turn on with any
n detection tolact saved setting
|: Breseand hold the ** button for 10 seconds to enter time:
adjustment mode Thete.are 4 eptions:10 min. th, I2h or the sleep.
mode is disabled.
LED will link (210 min. 251h.3212h. oF
sable sleep mode)
lil Prose the" and“ buttons simultaneously to save the time
setting and power offthe sight
remember the last saved
on and off,
battery velzage is below 2 2Vde
Fas
1. The sight has been pre zeroed. but some additional adjustment
may be necessary as all Frearms ae unique.
2-The elevation agjustmentsctew is st top rear end of the sight.
the windage adjustment screwis on the left side ofthe housing
‘Aajustments ean be made by inserting the included wrench into
the adjustment serew slots and ewisting. {se Fig?)
3. To move the point of impact up or right twist counter:
Clockwise. Te move the point ofimpact down or left. twist
Clockwise. Each click will esultinaV/2 MOA movement
4. The maximum agjustment ange s +40MOA froma
‘Caution: Don's try 0 over rotate the knobs, ifyou feel the knobs
cannot be rotated further. you are 3
Further adjustment may damage the sight. Ifthe requires zero
range s beyond the limits. consider adding excra spacer between
the device and the mount rato expand the agjusting range
limits
he adjustment limit.
97
This device ls precision instrument that deserves reasonsbly
cautious cate The folowing tips ate provides
preduct life The epticalierses are multicaated optical glass
When cleaning the lenses blow away any dust on the surface, wet
ensure s long,
fer eren
‘We provide a limited lifetime warranty rom the date of purchase,
fon parts and workenanship te the eriginalppurchaser.Atour sole
discretion, weil repair or replace preduets found to be defective
under normal use without charge, excluding ary delivery costs,
which willbe born by purchaser We will net be liable for
incidental, consequential or special damages arising eut of rin
‘any connection with these or performance af ths produet This
warranty 's void i
neglected, or disassembled prio
FOLOSUN
Holosun Technologies Inc.
Hss10¢ ‘wreihosun.cor
Circle Dot sight [SEIT
Fox 1908) 598.4888,
Emaik warantystholesuncom
4 vis.