Professional Documents
Culture Documents
B-11² C-7¹
diagnosed the fault. Switch - Hydraulic Filter Bypass 103 75 101
J-2¹ C-14² 88 60 95 HR21-UP
Relay - Cold Start 77 WIRING GP - WORK TOOL
H-9² G-7¹
Switch - Stop Pressure 1 104 CD31-UP
J-2¹ G-14²
Relay - Start 78
Failure Mode Identifiers (FMI)¹ H-9² G-7¹
Switch - Stop Pressure 2 105 Volume 2 of 2: Chassis and Engine Wiring
FMI No. Failure Description Resistor - Alternator I-2 79 G-14²
0 Data valid but above normal operational range. F-7¹
91 98
Sender - Fuel Level 80
1 Data valid but below normal operational range. F-14²
2 Data erratic, intermittent, or incorrect.
¹ Schematic locations for 216, 226 and 247 Sales Models. © 2016 Caterpillar, All Rights Reserved Printed in U.S.A.
3 Voltage above normal or shorted high.
² Schematic locations for 236, 242, 252, 257 and 259 Sales Models. RIGHT REAR REAR MACHINE VIEW
4 Voltage below normal or shorted low.
Check Part Numbers in the Parts Manuals for your Specific Machine.
5 Current below normal or open circuit.
6 Current above normal or grounded circuit.
7 Mechanical system not responding properly.
8 Abnormal frequency, pulse width, or period.
9 Abnormal update.
10 Abnormal rate of change.
11 Failure mode not identifiable.
12 Bad device or component.
13 Out of calibration.
14 Parameter failures.
15 Parameter failures. 70
16 Parameter not available.
100 96
17 Module not responding.
18 Sensor supply fault.
19 Condition not met.
20 Parameter failures.
¹The FMI is a diagnostic code that indicates what type of failure has occurred.
63
79
67 65
71 CONN 1
93 72 CONN 2 64
CONN 16 105 CONN 3 92
99 CONN 4 85 CONN 22 77
104 CONN 18 84
78
58
66
67
68
69
102
76 97 74
80 CONN 25
61 CONN 23 94 82 CONN 26
CONN 14
CAB RIGHT HAND FRONT TO REAR CAB UNDERSIDE VIEW MACHINE LEFT SIDE