BHS Operating Instructions
Twin-Shaft Batch Mixer DKX
SONTHOFEN Maintenance - 900360500
22. Replacement of Axial Face Seals
> NOTE!
This repair should not be executed by the user alone, but always with the
assistance of an expert of the mixer manufacturer, who will make available
also the necessary tools and technical documentation.
> ATTENTION!
‘Switch off the machine.
Repair switch to position "OFF" and locked by key
=) Keep key safely against unauthorized use
Put warning sign "Maintenance Work" on repair switch
Wait for siow-down period of moving machine parts
> ATTENTION!
Wait for immobilization of mixing shaft (check on the mixing shaft between
bearing case and machine housing) and opening of locking unit.
> Incase of drive side seal, remove slip-on gear unit, see: Replacement of
slip-on Gear Units.
> Support shaft on both sides of the trough.
>» Then unscrew bearing cover and bearing body and with-draw bearing body
together with self-aligning roller bearing by means of jacking screw.
> Before removing the fixed bearing or replacing the shaft seal on the fixed
bearing side (non-drive end) measure alignment between gear coupling
halves and note down.
> Support the shaft in the trough, unscrew and withdraw locating ring.
>» Dismount axial face seals.
» Clean locating ring and shaft bush, check if parts are OK
> Builds-up - see fig. Replacement of Mixing Shafts - must still exist, so the
axial face seals with O-rings can only be mounted with corresponding
pressure.
> Sealing faces must be smooth without any striae.
> Insert new axial face seals and mount locating ring, bearing body and
bearing cover. Check distance between contact surface of locating ring and
shaft bush
> IMPORTANT!
Correct distance measure refer to: Replacement of Mixing Shafts
29 - 30