askia
Section 11 - Exhaust System - Group 11 Page 11-
Section 11 - Exhaust System - Group 11
Section Contents
Exhaust Connection Pipe ...
Inspect for Reuse...
Rail Applications...
Install oe
Rail Applications...
REMOVE. eeenrenn
Rail Applications.
Exhaust Manifold Heat
Clean ses
Marine Application
Inspect for Reuse.
Marine Applications.
Install 7
Marine Applications.
REMOVE. error
Marine Applications.
Exhaust Manifold, Dry
‘Assemble...
Clean and inspect
Disassemble.
Finishing Steps..
Install ersreen
Preparatory Steps.
Remove.
Exhaust Restrictio
Measure...
Service Tools
Exhaust System...
hield ..skis Service Tools
Section 11 - Exhaust System - Group 11 Page 11-1
Service Tools
Exhaust System
The following special tools are recommended to perform procedures in this section. The use of these tools,
is shown in the appropriate procedute. These tools can be purchased from your local Cummins Authorized
Repair Location.
Tool No. Tool Desc: Too! Illustration
Manometer (Mercury Filled Slack Tube)
Used to measure exhaust restriction. q F
ST-1111-3, KRExhaust Connection Pipe
Page 11-2
askis
Section 11 - Exhaust System - Group 11
Exhaust Connection Pipe (011-001)
Remove
Rail Applications
Rall Applications
Exhaust Transfer Connection and Brackets - Remove
Remove the turbocharger. Refer to Procedure 010-037,
Remove four capscrews from the exhaust transfer
connection and support brackets.
Flemove four capscrews, nuts, gasket, and exhaust
£9 iransier connection from the exhaust manifold. Discard
gasket.
Remove No. 2 and No. 3 rocker lever covers. Refer to
SEask1a
Section 11 - Exhaust System - Group 1%
Remove No. 2 and No. 3 rocker lever assemblies. Refer
to Procedure 003-008, <<)
SE
Remove No. 2 and No. 8 rocker lever housings. Refer to
Ss
Remove four capscrews, and two exhaust transfer
connection brackets from the rocker lever housings.