Professional Documents
Culture Documents
section and follow the instructions (Machine Error – Error Code 2).
NOTE – Be careful with the next move. You could break the bit.
Jog DOWN until you are 1/8” above the plastic (you can change to 0.05 for finer adjustment).
(if you open the cover on the machine – it must be closed before you can continue).
Looking through the front of the machine, the bit should be approx. 1/8”- 1/4″ to the right if the clamp
bar, 1/8” above the plastic.
If this is Correct – Click SET ORIGIN, Enter the password CNC123 (make sure the CNC is uppercase).