FT-212RH
TECHNICAL SUPPLEMENT
YAESU MUSEN CO., LTD.
C.P.0. BOX 1500
TOKYO, JAPANThis manual is tntenderd to serve at a supplement to the FT-212RH Operating Manual. De-
tailed information regarding functions, specifications, options and operation fas been provided
in the Operating Manual, and 1s aot reprinted Nerein. Therefore, this supplement is not
Intended to serve as an Independent reference, but to be used in conjunction with the infor~
mation provided in ehe Operating Manual
Because of the compactness and complexity of the double-sided glass-epoxy circuit boards
used in the FT-212RH, four layout diagrams are provided for each board. Each side of the
board is identified by the type of the majority of components installed on that side. In
‘most cases one side has only chip components, and the other has either a mixture of both
‘chip and lead components (trimmers, colls, electrolytic capacitors, packaged ICs, etc.), oF
lead components only. The two Tobversa" views depict the board as it is seen when viewed
directly with the eye, while the two "reverse" views depict the unseen side of the board as
|e would appear if one were co peer through the boerd from the other side without seeing
the components and tracks on the near side.
While we believe the technical information in this manual is correct, Yaesu assumes no
liability for damage that may occur as 4 result of sypographical or other errors that may be
present. Your cooperation In pointing out any inconsistencies in the technical information
‘would be appreciated.
‘Yaesu Musen reserves the right to make changes in the circuitry of this transceiv
interest of technological Improvement, without notification of the owners.
nthe
one CONTENTS ~~
CIRCUIT BOARD ACCESS «e100 1
MAIN UNIT PARTS LAYOUT ==" earner 3
MAIN UNIT CIRCUIT DIAGRAM 8
IF UNIT PARTS LAYOUT/CIRCUIT DIAGRAM 9
MIC UNIT PARTS LAYOUT/CIRCUIT DIAGRAM 10
APC UNIT PARTS LAYOUT/CIRCUIT DIAGRAM :
144-VCOUNIT PARTS LAYOUT/CIRCUIT DIAGRAM =~ |
CONTROL. UNIT PARTS LAYOUT 3
CONTROL UNIT CIRCUIT DIAGRAM 6
PA UNIT PARTS LAYOUT ”
| PA UNIT CIRCUIT DIAGRAM 19
SEMICONDUCTOR CROSS-REFERENCE ~~ 2»
BLOCK DIAGRAM - . 21
EXPLODED VIEW 2
ALIGNMENT “23
ALIGNMENT (PLL) 4
ALIGNMENT (Transmitter) B
ALIGNMENT (Receiver) a |
PARTS List ~ a |BOTTOM COVER REMOVAL
The following circuit boards are accessed
by removing the bottom cover
Main Unit (component side)
IF Unic®
Mic Unit*
APE Unit,
¥CO Unit
PA Unie {lower edge only)
To remove the bottom cover, remove the
four screws marked "a " in Figure 1, plus
the four marked "=" if the op cover has
not already been removed. Then lit the
cover away.
+ To access these boards It may be neces~
sary to remove th loudspeaker and
holder:
(1) Referring to Figure 2, unplug the
speaker wire connector from ]1005
fon the Main Unit, and lift the
loudspeaker out of Its bracket. +
(2) Remove the three serews in the
farms of the speaker bracket and
remove the brack
TOP COVER REMOVAL
Removing the top cover exposes the Solder
Side of the Main Unit circuit board and the
top edge of the PA Unit board.
To remove the top cover, remove the four
screws marked " 9 " in Figure 1, plus the
four marked "#" if che bottom cover has
not already been removed. Then lift the
cover away.
FRONT PANEL REMOVAL
Removing the front panel allows access wo
the Control Unit and LCD Unit circuit
boards.
(1) After the top and bottom covers have
been removed, pull off the Selector, VOL.
land SQL knobs.
(2) Remove the nut from the microphone
Jack using a slotted ring wrench os
shown in Figure 3.
The front panel can now be slid forwardL NNN aaa i
MAIN UNIT (No. 1X)
35x81 (01002)
Pc7a08H (01018)
{7909 (o1016)
1042003 01008)
‘obverse view of “component” side
eka2981134R,01017),
=
2802838,01007),
ease.
‘COLLECTOR
‘eirTeR
25010001 (01005)
25033877) (01006)
25420000) (01008)
23K208Y (3) (91013),
reverse view of “component” sideMAIN UNIT PARTS LAYOUT
(91003,1000:1010)
s01623.7) (01014)
1351849) (01014),
135220108) (01609)ere tk
aT
fa
Aas
iS
7
a)
wo
EK
a
a
ci
E
ra
=
z
=
SSSMAIN UNIT PARTS LAYOUT
MAIN UNIT VOLTAGE CHART
(we vours)
REMARKS
ewww [eon] @
aL oe Pa
o2 | 88 | of f
| 128 | 136 | 136 t
| Havas | ossns ose
° 05 | 07
ie ao [ae
Spar | oe
MAIN UNIT IC VOLTAGE CHART (ve yours)
Se eel tele fe [eo [ef fz fie] oT ie] 16 [rons
Toiooe 07) o7 | 0 | wt
aor | aa| 25) a ais) [0 | 15] 0) a4] | 0 | 20) 20| aol axrx
‘ior | is6| 0 | oo L - |
‘ore | 90] 0 | 80reverse view of “Tantalum CAP* side reverse view of “chiponly” side
Frsisty (as0r) ‘25062418V4) (0603608) | 195188(83) (0601) __18S2721A1) (0602)
Framiw!) (0608), ‘2sc16291L6) (0002),
FaiaeM-T281.38) (608
APC UNIT VOLTAGE CHART (oe vars!0 UNIT (No.3 XX)
reverse view of “chip-only” side
VCO UNIT VOLTAGE CHART
2503386828) ‘ se [Low |awe [oo | 0 [nem]
(0201 308208) ‘
FAIFAN-T20;R28)
(9302.08)CONTROL UNIT PARTS LAYO!
CONTROL UNIT (No.2 XXX)
eas.TROL UNIT PARTS
288624) (02000)
250182316) (@20042000)CONTROL UNIT PARTS LAYOUT
sssiaga
ze o4zi04
((irenoazco
v0
rssz260s) (02001)