Professional Documents
Culture Documents
Occupancy Sensor
•Combines a door switch and room motion sensor
•Automatically activates the temperature set-back function
•Communicates with PTAC and other DigiSmart devices
•Utilizes encrypted 802.15.4 standard for safe communication
Remote Thermostat
•Controls the Amana DigiSmart PTAC from anywhere in the room
•Battery powered
•Communicates with other DigiSmart devices
•Utilizes encrypted 802.15.4 standard for safe communication
Screws Logo
Installation
4. Restore power to the PTAC unit.
5. Reinstall the front polymer cover.
The DD01E – Door Switch/Motion Detector
with magnet holder, will communicate with
the DT01A, installed on the PTAC unit. It will
verify occupancy via the motion detection
and communicate to the DT01A to enter into
occupied state or unoccupied/set beck
status. It will work in concert with both the
DT01A and DS01E and DL01E – DigiSmart
communication platform.
Installation
1. Remove the motion sensor from the mounting
plate by pulling the unit apart (see right)
2. Place the mounting plate on the door trim
directly above the door. Mount the unit as low
as possible on the door frame to be as close
to the door as possible without interfering with
the opening or closing action (choose a
location that will provide good coverage of the
PIR for motion into the room) Do not attach
the Motion Sensor to the mounting
plate until after the BINDING
PROCESS.
3. Install two AA batteries( included) Into the
terminals marked “+” & “-” for polarity. (See
below)
4. DD01E can be hardwired for power (See full
installation instructions for more info)
Installation of Magnet Holder and/or
Spacers