Solve the given problems below and present a complete and
organized solution in a separate sheet of clean paper.
Kindly submit your work not later than September 21,
2021 send it on this g-mail (francisvvillacorta@gmail.com)
PROBLEM: A reinforced concrete beam has a width of 300mm
and an effective depth to the tension reinforcement of 618mm. Compression reinforcement if required will be placed at a depth of 60mm from extreme compression fiber. If f’c = (20+ N/5)MPa and fy = (400 + N)MPa and the beam is to support a moment of Mu = 650kN.m.,
1. Prove that the beam will be designed as singly reinforced
only if:
a. the maximum tension steel reinforcement ratio is
0.75 of the computed balanced steel reinforcement ratio.
b. the maximum tension steel reinforcement ratio is
determined when the strain of steel = 0.005 at same time that concrete strain is = 0.003.
Hint; required area of tension steel reinforcement must be
less than maximum steel reinforcement area.
2. Compute the tension steel reinforcement area in sq.mm.
3. Compute the minimum tension reinforcement area in sq.mm.
4. How many 28 mm diameter bars are needed for the beam?