3. Twist loose No. 1,2 Screws, take out No. 3,4 Screws, 4. Then, take out metal disc(In the blue circle) 5. After removing the metal disc, Clean and sand the dirt inside the bearing, Apply lubricating paste, lubricating oil Reassemble after cleaning,
After assembly:
1. Adjust the zero position of the machine
2. Adjust the spray position of the water pump
1. Loosen and remove the screws, remove the water pump.
2. Jog the machine shrimp needle to this position.
3. Rotate the water pump, when the Max amount of water is sprayed, install it back on the machine.
Screws must be tightened
After all adjustments are completed 1. Spot welding to fix this bearing to avoid sending collision again 2.