You are on page 1of 2

ASSESSMENT - 3

Name : Devang Garg

Reg. No : 20BCI0115

Slot : L 41+L 42

Subject : NETWORK AND COMMUNICATION (NETCOM- CSE1004)

Faculty : RAJKUMAR R
Q Implement a scenario of 2 PC’s , 1 Switch and a Router and send packets using cisco packet
tracer

Algorithm

1. Run Cisco Packet Tracer

2. Fetch 2 pc’s from End Devices Section located at the bottom left corner

3. Mark the IP’s for each of the Pc’s

4. Connect a Switch(2960-24TT) to all the PC’s through copper straight through wires and make sure
all ports are switched on

5. Mark a note of IP’s beside the PC’s

6. Connect a Router (2901) to the switch from Network Devices section located at bottom left corner
through copper straight through wires and make sure all ports are switched on

7. Drag a packet from menu bar and place it at PC0 and PC1 , simulate it

8. Record Output

Snip before packets are being sent

1|Page
Snip after packets are being sent

Output

The packet transfer was successful as shown in the simulation.

2|Page

You might also like