753/754
Frequency Source
Thermocouple Measure,
‘Thermocouple Source
RID Measure, Four-Wire
RID Measure, Three-Wire
RID Source,
Loop Power
HART Mode Verification (754 Only)
Calibration
Equipment Required for Calibration
Calibration Status Indicator.
How to Enter Calibration,
Calibration Constant Out of Bounds
How to Calibrate
Maintenance.
Battery Replacement
How to Clean the Product
Calibration Data,
In Case of Difficulty
Service Center Calibration oF Repair.
Replaceable Parts
‘AccessoriesFroquency Measurement
Ranges Resolution 2 Year
Taw ooo Doin Tae
10.1 Reto 1000 FE One ‘One
TAD eo 1,000 0001 Dos
‘avping: AC
anu Arle for Frequency Measierert ase wave:
tateox0ire TAVPE
oem np
rout pence >4 Ni.
Ii Forteqerey meosuerent oss tan 11000 He seca ap or gn wh en ae 5 nena
4DC Voltage Output
‘of Output + Floor
Resolaion ear Year
Tv OTK + OOS DUS + O00
fo 301% 9.00008 001s % + 0.00006
16.0000 V 00 uv ‘001 9+ 0.0008 V ‘0.018% + 00005 V
Mrvum Gul Canene 107A the TOO a ane TOTO VT eto when sug TA.
Facog devotages 10000 accu sol pee RF fas >1 Vin, BMH 70 WHE
Terperae Cote 0001 Wot asp +0001 Wot ange °C 8 C028")
+D¢ Current Source
Rangentooe Rovouton of Outs Floor
Tear 2 Year
Tite DOTA Ta Tae FOREST
Tepe Coats 3 al apeotedasarany'C (18 COI>TEO)
Sauce mA Complone Votage 8 V macrum
Sauce mA Open Crt Vege SOV manu
Performance Verification Tests
Fluke recommends re-cetiication each year. To re-certify, do the verification procedure.
test points are out of tolerance, calibrate the Product and then re-verfy. Two-year
specifications are included if the highest accuracy is not necessary.
Use the subsequent tests to make sure thatthe Producti inside its specification limits.
Verification Equipment
The equipment necessary for verification of the Product is shown in Table 2. I'these
instruments are not available, you can replace them with other source and measure
instruments that have the same the minimum specification requirements,
‘able 2. Equipment Required for Verification
Equipment ‘Minimum Specifieation Recommended Mode!
0.002 % for OC Votage,
Ccaitator Resistance and Curent. 0.01 for | Fake 55224
AC Voit
Frequency Counter 1210 50 kHz, 25 ppm timebase | “Tektronix FCA3000
. 1 He to 50 ka (uty cycle accuracy | ase 409
‘osaitoscoe ts